Vehicle report

2023 BENTLEY FLYING SPUR

Compare every BENTLEY FLYING SPUR yearNHTSA and EPA records

Service bulletins

486 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

2057841/5

Service Bulletin/Repair Instructions

Windscreen replacement criteria whilst under manufacturers warranty.

2078038/5

Service Bulletin/Repair Instructions

Service info: Paint Damage/Anomalies | All Models

2061369/14

Service Bulletin/Repair Instructions

Engine Overheating - Warning in the DIP | V8 Kovomo. Customer statement / workshop findings: One or a combination of the following symptoms are evident • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2083061/1

Service Bulletin/Repair Instructions

Real Wear Setup and Guide using VYSOR

2078395/3

Service Bulletin/Repair Instructions

Service info: Leather Damage/Anomalies | All Models

2061369/13

Service Bulletin/Repair Instructions

Engine Overheating - Warning in the DIP | V8 Kovomo. Customer statement / workshop findings: One or a combination of the following symptoms are evident: • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2070638/3

Service Bulletin/Repair Instructions

Water evident on the A-Post pillar seam - Water dripping behind the door seal - Sunroof specified vehicles only.

2051562/17

Service Bulletin/Repair Instructions

12 volt - Battery condition checks - Battery replacement requirements

2055036/9

Service Bulletin/Repair Instructions

My Bentley - Connected services. Customer statement / workshop findings: Complaints relating to My Bentley connected services.

2071933/5

Service Bulletin/Repair Instructions

Headlamp Control Unit Replacement | Bentayga and Flying Spur. Customer statement / workshop findings: Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or Daytime running light malfunction / operational issues (Inner lamp) Or Turn signal malfunction / operational issues (Outer lamp)

2078190/7

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Leakage Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2081085/2

Service Bulletin/Repair Instructions

V8 Engine - Ticking Noise, Misfiring and Possible Low Oil Pressure Indications. Customer statement: The customer may report an audible ticking noise from the top of the engine, low oil pressure warnings / MIL on the Driver Information Panel, and/or misfiring during engine operation

2028794/10

Service Bulletin/Repair Instructions

Engine coolant mixture - Restrictions on use of desalinated water.

2057978/10

Service Bulletin/Repair Instructions

Engine Lubricating Oil - Replenishment. Customer statement / workshop findings: Engine lubricating oil lamp illuminated on driver instrument panel. Engine lubricating oil requires “topping up” between services.

2063729/6

Service Bulletin/Repair Instructions

Fitment of control modules from donor vehicles for test purposes.

2064648/7

Service Bulletin/Repair Instructions

ACC Unavailable-Traffic Assist Failure-Safeguard Failure-Radar Malfunction Warning DIP - Numerous DTC's within 0013. Customer statement: One or numerous of the following issues are evident: • ACC Failure • Traffic Assist Failure • Safeguard Failure • Radar Malfunction

2068946/12

Service Bulletin/Repair Instructions

Dynamic ride system warning visible - DTC P0B2500 logged within address 0021 (Battery Energy Control Module 2). Customer statement: Bentley dynamic ride system fault is displayed within the Drivers Instrument Panel (DIP)

2073377/4

Service Bulletin/Repair Instructions

TPMS - Warning within the Drivers Information Panel (DIP) - Tyre pressure sensor - Low battery.

2075318/5

Service Bulletin/Repair Instructions

Engine light in the DIP - Various Camshaft adjuster DTC’s logged within the Engine Control Module(s).

2077519/4

Service Bulletin/Repair Instructions

Exterior Gap and Profile Information. Customer statement / workshop findings: Customer and/or retailer may raise an issue with panel gaps/alignment or flushness.

2078038/4

Service Bulletin/Repair Instructions

Service info: Paint Damage/Anomalies | All Models

2080097/2

Service Bulletin/Repair Instructions

Service info: Conversion of imported vehicles. Technical background: Conversion of a vehicle for use in a market other than the one for which it was originally designed or intended is not supported. Enquiries related to conversions or retrofits of vehicles from (or to) other markets (e.g. reimport from USA or UK) are not supported by Technical Support. Vehicles are developed and constructed according to specific market requirements of the respective destination country. As the compatibility of different components (e.g. control units) cannot be defined comprehensively regarding their mutual dependence and interaction in the case of modifications, and in order to prevent danger or risks due to constructional changes, support or advice regarding these modifications cannot be provided.

2080680/2

Service Bulletin/Repair Instructions

Organ stop air regulator jammed / broken / electrical value wrong reading. Customer Statement: Airflow from the organ stops (air regulators) is not functioning correctly; vents may be stuck, broken, or showing incorrect operation.

2080795/2

Service Bulletin/Repair Instructions

Service Info: Cleaning and Care Guidance for Dinamica Interior Trim Materials

2080814/2

Service Bulletin/Repair Instructions

Service Info: Interior Veneer Replacement. Customer statement / workshop findings: For any interior veneer replacement: raise and obtain approval of a Technical DISS query before ordering. This ensures VIN correct specification and prevents visual mismatch.

2080901/2

Service Bulletin/Repair Instructions

Sporadic entries - Nano connector contact testing. Customer statement / workshop findings: Sporadic entries in control units that use Nanotype terminals, including the airbag control unit J234, the engine control unit J623 and the emergency call and communication unit J949. These may be accompanied by intermittent electrical behaviour or repeated DTCs after earlier diagnostic checks.

2081243/2

Service Bulletin/Repair Instructions

Service Info: Engine Control Module (ECM) 5V Reference Circuits. Customer statement / workshop findings: This TPI provides supplementary technical information to support diagnosis of ECM 5V reference circuit DTCs. It details the sensors associated with each reference circuit (A, B, and C) and outlines relevant guidance to assist in isolating faults when any of the following DTCs are stored in the Engine Electronics (diagnostic address: 0001) • Sensor Reference Voltage “A” Circuit – Open / High / Low (P0641, P0643, P0642) • Sensor Reference Voltage “B” Circuit – Open / High / Low (P0651, P0653, P0652) • Sensor Reference Voltage “C” Circuit – Open / High / Low (P0697, P0699, P0698)

2081721/2

Service Bulletin/Repair Instructions

Vehicle Central Locking – Door Locking / Unlocking Functional Complaints. Customer Statement: The customer reports that the vehicle door locking and/or unlocking does not function correctly. This may include intermittent operation, non-response to remote or interior commands, or inconsistent locking behaviour.

2028808/10

Service Bulletin/Repair Instructions

Service info: Engine oil – Specific oil type and oil consumption reference.

2051187/13

Service Bulletin/Repair Instructions

Poor Engine Running Complaints (Misfires) Petrol Engines Only. Customer statement / workshop findings: • Poor engine running • Reduced power • Engine warning lamp illuminated • Symptom related DTC’s evident within the applicable engine control unit(s)

2063855/13

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - evident within address 0019 and/or DTC U112300 evident in 00A5. Customer statement / workshop findings: • Lane Assist and / or Traffic Assist are not functional • DTC - B17B801 - Steering Wheel Touch Recognition Control Module evident within address 0019 And/or • DTC B17B804 - Steering Wheel Touch Recognition Control Module electrical error - evident within address 0019 And/or • DTC U112300 with symptom Code 1123220 within address 00A5

2068273/6

Service Bulletin/Repair Instructions

Multiple random misfires evident during PDI.

2075331/5

Service Bulletin/Repair Instructions

Engine light in the DIP - Various oxygen sensor / Fuel ratio DTC’s logged within the Engine Control Module(s). Customer statement / workshop findings: Engine light in the DIP - Various oxygen sensor / Fuel ratio DTC’s logged within the Engine Control Module (s)

2075786/3

Service Bulletin/Repair Instructions

Airbag, fire, accident (safety-related enquiry - reporting forms) There is a reporting obligation in the following cases: • Airbag/belt released/not released • General accident • Fire and scorching damage for all Bentley Vehicle models - every model year.

2082308/1

Service Bulletin/Repair Instructions

Satellite Values Not Displayed in MVBs - J949 Emergency Call Control Module (Conbox). Customer statement / workshop findings: During diagnosis using ODIS, Measured Value Blocks (MVBs) for: Visible satellites, tracked satellites (within J949 Emergency Call Control Module – Conbox) may display blank or no value. This condition may be interpreted as a GPS reception fault, antenna issue or connectivity malfunction. Diagnostic logs may also show absence of satellite values.

2061369/12

Service Bulletin/Repair Instructions

Engine Overheating - Warning in the DIP | V8 Kovomo One or a combination of the following symptoms are evident: • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2071131/6

Service Bulletin/Repair Instructions

Measured values - Cycle recording instructions Condition: In some cases Measured value traces may be requested in XML format for analysis by Product Support Technical Background: The instructions within the Measure section of this TPI have been generated to guide operatives through the process for recording Measured values in cycles by using self diagnosis, the Instructions also detail how to locate corresponding files which are required for analysis

2081882/1

Service Bulletin/Repair Instructions

Navigation Map Update Process - MIB2 Infotainment Systems. Customer statement / workshop findings: The customer requests improved and/or newer navigation functionality, including access to the latest navigation maps and updated map content.

2082002/1

Service Bulletin/Repair Instructions

B200FFE - Internal Malfunction Logged in Sway Stablization Control Units (00D4/00D5). Customer statement / workshop findings: During fault finding, the following may be observed: DTC B200FFE (Internal Malfunction) stored in the following diagnostic address: • Front Sway Stablization Control Unit (00D4)Or • Rear Sway Stablization Control Unit (00D5)

2075140/3

Service Bulletin/Repair Instructions

Engine cooling system over cooling - One or a combination of DTC's may be evident P218100 - P1BB400.

2074992/3

Service Bulletin/Repair Instructions

Flying B mascot clear wings replacement procedure. Customer statement / workshop findings: One or both of the Flying B mascot clear wings are missing

2078190/6

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Leakage. Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2081987/1

Service Bulletin/Repair Instructions

Panorama Sliding Sunroof - Creaking Noise from Rear Rail Area | Flying Spur

2078038/3

Service Bulletin/Repair Instructions

Service info: Paint Damage/Anomalies | All Models Customer statement / workshop findings: In rare instances the customer and/or retailer may identify visual damage/anomalies in the paint finish during or post pre-delivery inspection. These may include: • Uneven sheen or texture • Patchy or blotchy appearance • Inconsistent under lighting • Staining, discolouration, or surface blemishes

2081947/1

Service Bulletin/Repair Instructions

W12 Engine - DTC P192400 control module pin code implausible signal logged in 0001 /0011. Customer Statement: The customer may report one or more of the following after vehicle repairs: • Engine does not start following workshop work • Drive System Fault warning displayed in the instrument cluster (Kombi).

2054635/8

Service Bulletin/Repair Instructions

Fluid leak from front air spring.

2063729/5

Service Bulletin/Repair Instructions

Fitment of control modules from donor vehicles for test purposes. Technical background If an issue is suspected for one of the control modules listed below: • Onboard supply control unit (J519) • Convenience system central control unit (J393) • Data bus diagnostics interface (J533) • Control unit 1 for Information Electronics (J794) • Control unit in dash panel insert (J285) • Emergency call module control unit (J949) The fitment of donor parts from another vehicle is not advisable and only possible if approved from Product Support via an open DISS query.

2081721/1

Service Bulletin/Repair Instructions

Vehicle Central Locking – Door Locking / Unlocking Functional Complaints Customer Statement The customer reports that the vehicle door locking and/or unlocking does not function correctly. This may include intermittent operation, non-response to remote or interior commands, or inconsistent locking behaviour.

2066480/9

Service Bulletin/Repair Instructions

Headlamp switch not working / not illuminated - Numerous DTC's within 0009-Central Electrics (BCM1) Customer statement: • Headlamp switch not working / not illuminated when the ignition is switched on (following an ignition switch off) And/or • Yellow warning light/message within DIP (Adaptive lighting fault) And / or • Loss of rear fog light activation And / or • Loss of all-weather lighting mode activation And / or • Headlamps will default to dipped beam (however, high beam activation will still be possible manually)

2051562/16

Service Bulletin/Repair Instructions

12 volt - Battery condition checks - Battery replacement requirements. Customer statement / workshop findings: 12 volt battery flat or unserviceable

2057841/4

Service Bulletin/Repair Instructions

Windscreen replacement criteria whilst under manufacturers warranty. Customer statement / workshop findings: Windscreen cracked/damaged

2081608/1

Service Bulletin/Repair Instructions

Bring Your Own Content - Over The Air (OTA) Update to software version R14.0.8 – Maintenance Release. An Over The Air Update (OTA) could be required for both of the Bring Your Own Content (BYOC) screens. The update includes the following: • Fixes for casting issues across multiple apps • Expanded app support • Chromium browser upgrade to v114 • Improved OTA download speed in China • Fixes for minor bugs from previous maintenance phase • Patches addressing identified cybersecurity vulnerabilities.

2071525/4

Service Bulletin/Repair Instructions

Driver / Passenger door(s) creak on close - All models (front and / or rear). Customer statement / workshop findings: Driver and / or Passenger door creak during the “Power close” function - Front and / or rear (Depending on vehicle type)

2081472/1

Service Bulletin/Repair Instructions

Water Ingress in the Door Infill Panel Area | Flying Spur Customers may report one or more of the following concerns: • Evidence of water ingress into the cabin, typically visible on or around the lower door trim area. • Damp carpet or moisture traces following rainfall or vehicle washing

2055036/8

Service Bulletin/Repair Instructions

My Bentley - Connected services. Customer statement / workshop findings: Complaints relating to My Bentley connected services

2079115/2

Service Bulletin/Repair Instructions

Turbo Charger Under-boost - DTC P029900 is evident in 0001 | V8 Kovomo | All Models. Customer Statement: The engine warning light comes on and the vehicle loses power.

2080902/2

Service Bulletin/Repair Instructions

DTC B101629 and/or B12F129 and/or B151329 evident with 0015 (Airbag) with Airbag Indicator Lamp - Illuminated. Customer Statement: The customer reports that the airbag warning lamp is illuminated in the instrument cluster and the front passenger airbag indicator lamp within the roof console does not function.

2071933/4

Service Bulletin/Repair Instructions

Headlamp Control Unit Replacement | Bentayga and Flying Spur | 20,21,22,24,25,26MY. Customer statement / workshop findings: Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or Daytime running light malfunction / operational issues (Inner lamp) Or Turn signal malfunction / operational issues (Outer lamp)

2081243/1

Service Bulletin/Repair Instructions

Service Info: Engine Control Module (ECM) 5V Reference Circuits. This TPI provides supplementary technical information to support diagnosis of ECM 5V reference circuit DTCs. It details the sensors associated with each reference circuit (A, B, and C) and outlines relevant guidance to assist in isolating faults when any of the following DTCs are stored in the Engine Electronics (diagnostic address: 0001)

2078190/5

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Leakage. Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2081029/1

Service Bulletin/Repair Instructions

W12 Engine - Ticking Noise and Possible Low Oil Pressure Indications. The customer may report a ticking noise from the upper engine area, low oil pressure warnings, or a flashing MIL during engine operation.

2081085/1

Service Bulletin/Repair Instructions

V8 Engine - Ticking Noise, Misfiring and Possible Low Oil Pressure Indications. The customer may report an audible ticking noise from the top of the engine, low oil pressure warnings / MIL on the Driver Information Panel, and/or misfiring during engine operation.

2073225/2

Service Bulletin/Repair Instructions

Infotainment screen stuck on loading - Message visible within the Infotainment screen. Condition: One or a combination of the following issues are evident: • Infotainment screen stuck on initialising Or • Loading messages are visible at start up (within multiple tiles) Or • Bentley Rotating Display (BRD) doesn’t return to its previous state

2067831/3

Service Bulletin/Repair Instructions

Connected car user list - Error message shown within the MMI. Customer statement / workshop findings: The user list is not populated when selected on the MMI, the following message is evident: Connected Car User List Could Not Be Obtained Due to Communication Problem error message shown within the MMI

2051562/15

Service Bulletin/Repair Instructions

12 volt - Battery condition checks - Battery replacement requirements. Customer statement / workshop findings: 12 volt battery flat or unserviceable

2055036/7

Service Bulletin/Repair Instructions

My Bentley - Connected services Customer statement / workshop findings: Complaints relating to My Bentley connected services.

2080097/1

Service Bulletin/Repair Instructions

Service info: Conversion of imported vehicles

2080902/1

Service Bulletin/Repair Instructions

Front Passenger Airbag Indicator Lamp - Illuminated / Indicator Not Functioning. Customer Statement: The customer reports that the airbag warning lamp is illuminated in the instrument cluster and the front passenger airbag indicator lamp within the roof console does not function. Figure

2062257/7

Service Bulletin/Repair Instructions

Keyless door entry does not work - Front Outside Door Handle(s) - Touch Sensor DTC B147613 and/or B147713 are present.

2080795/1

Service Bulletin/Repair Instructions

Service Info: Cleaning and Care Guidance for Dinamica Interior Trim Materials. Condition: Customers and retailers may raise enquiries regarding the cleaning and appearance of Dinamica interior trim materials. Workshop inspection confirms no material defects, with concerns related solely to approved cleaning and maintenance guidance

2080901/1

Service Bulletin/Repair Instructions

Sporadic entries - Nano connector contact testing. Condition: Sporadic entries in control units that use Nanotype terminals, including the airbag control unit J234, the engine control unit J623 and the emergency call and communication unit J949. These may be accompanied by intermittent electrical behaviour or repeated DTCs after earlier diagnostic checks.

2080753/1

Service Bulletin/Repair Instructions

58‑Way Transmission Control Module (TCM) Connector - Terminal Replacement. Customers may report one or more of the following concerns: • Transmission related warning messages displayed in the instrument cluster. • Irregular or unexpected gearshift behaviour. • Intermittent drivability concerns.

2080808/1

Service Bulletin/Repair Instructions

Side Mirror - Loud Noise During Folding Operation. Customer Statement: Customers may report a loud or abnormal noise from one side mirror during the automatic folding or unfolding operation.

2080814/1

Service Bulletin/Repair Instructions

Service Info: Interior Veneer Replacement. Condition: For any interior veneer replacement: raise and obtain approval of a Technical DISS query before ordering. This ensures VIN correct specification and prevents visual mismatch.

2051562/14

Service Bulletin/Repair Instructions

12 volt - Battery condition checks - Battery replacement requirements. Condition: 12 volt battery flat or unserviceable

2058354/7

Service Bulletin/Repair Instructions

New Flying Spur - Flying "B" Mascot. Condition: This Technical Product Information (TPI) Document is designed to give repair guidance and standardised fault reporting for Flying “B” functionality, poor finish and damage concerns.

2075318/4

Service Bulletin/Repair Instructions

Engine light in the DIP - Various Camshaft adjuster DTC's logged within the Engine Control Module(s).

2075331/4

Service Bulletin/Repair Instructions

Engine light in the DIP - Various oxygen sensor / Fuel ratio DTC's logged within the Engine Control Module(s)

2060446/9

Service Bulletin/Repair Instructions

Clicking noise from the front wheels when conducting a static lock to lock steering maneuver. Condition: Clicking noise from the front wheels whilst performing a static lock to lock steering maneuver.

2062184/10

Service Bulletin/Repair Instructions

Electronic Parking Brake (EPB) functionality issues. The following issues could be evident during PDI or found whilst in service: • Electronic Parking Brake (EPB) found not operating to specification • EPB may not hold the car effectively • Parking brake components showing signs of wear • Parking brake warning light may also be evident within the DIP, stating ‘Parking brake fault detected. Stop the vehicle in a safe place and refer to the owner’s manual.’

2079115/1

Service Bulletin/Repair Instructions

Turbo Charger Under-boost - DTC P029900 is evident in 0001 | V8 Kovomo | All Models. Customer Statement: The engine warning light comes on and the vehicle loses power. Workshop Findings: Customer statement can be verified and the following entries may be logged within the engine control unit. • P029900: Turbo/Super Charger Under-boost, passive/sporadic.

2080680/1

Service Bulletin/Repair Instructions

2079600/1

Service Bulletin/Repair Instructions

Belt tensioner damper replacement guidelines | V8 Kovomo. Condition: The belt tension damper is exhibiting oil leakage or signs of residual oil staining.

2078190/4

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Leakage. Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2079669/1

Service Bulletin/Repair Instructions

Questionnaire For All Technical Connected Car Queries. Condition: This questionnaire is designed to gather all necessary information from retailers before escalating a technical request through DISS for connected car related issues.

2061369/11

Service Bulletin/Repair Instructions

Engine Overheating - Warning in the DIP | V8 Kovomo. One or a combination of the following symptoms are evident • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2068946/11

Service Bulletin/Repair Instructions

2075318/3

Service Bulletin/Repair Instructions

Engine light in the DIP - Various Camshaft adjuster DTC's logged within the Engine Control Module(s). Condition: Engine light in the DIP - Various Camshaft adjuster DTC’s logged within the Engine Control Module(s)

2071239/5

Service Bulletin/Repair Instructions

Engine Overheating - Coolant Pump Leaking and Low Coolant Warning | W12. Condition: One or a combination of the following is evident: • Coolant leaking from the mechanical coolant pump • Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump • Low coolant level warning displayed within the DIP

2066669/4

Service Bulletin/Repair Instructions

Engine coolant - Overheat condition - Warning evident within the DIP - DTC's P2B6500 and P2B8600 are evident. Customer statement: • Engine cooling system overheating And/or • Coolant loss And/or • Warning light in Drivers Information Panel (DIP)

2071239/4

Service Bulletin/Repair Instructions

Engine Overheating - Coolant Pump Leaking and Low Coolant Warning | W12. One or a combination of the following is evident: • Coolant leaking from the mechanical coolant pump • Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump • Low coolant level warning displayed within the DIP Or • Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113 or air in the coolant DTC’s (various) is evident, in this scenario the operative should also refer to TPI 2051893/-

2061195/4

Service Bulletin/Repair Instructions

Telephone Functionality Complaint - Minimum Standards Required For Analysis Of Concerns.

2078395/2

Service Bulletin/Repair Instructions

Service info: Leather Damage/Anomalies | All Models

2028808/9

Service Bulletin/Repair Instructions

Service info: Engine oil - Specific oil type and oil consumption reference. Technical Background: The use of the correct oil for each engine type is critical for its continued performance, reliability and ultimately warranty. The workshop manual should always be the first point of reference, ensuring the correct lubricant is used for each specific model year and engine type Should oil be required the parts catalogue must be referred to ensuring the correct VIN is always used when ordering

2051187/12

Service Bulletin/Repair Instructions

Poor Engine Running Complaints (Misfires) Petrol Engines Only. Condition: • Poor engine running • Reduced power • Engine warning lamp illuminated • Symptom related DTC’s evident within the applicable engine control unit(s)

2052785/10

Service Bulletin/Repair Instructions

Brake noise identification

2056407/7

Service Bulletin/Repair Instructions

Running gear - Noise identification. Condition Customer statement: Noise complaint from the suspension and/or steering Workshop findings: The noise can be reproduced and clearly assigned to the suspension system from either of the axles And/or The noise can be reproduced and clearly assigned to the steering system

2057978/9

Service Bulletin/Repair Instructions

Engine Lubricating Oil - Replenishment

2063855/12

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - evident within address 0019 and/or DTC U112300 evident in 00A5. Condition: • Lane Assist and / or Traffic Assist are not functional • DTC - B17B801 - Steering Wheel Touch Recognition Control Module evident within address 0019 And/or • DTC B17B804 - Steering Wheel Touch Recognition Control Module electrical error - evident within address 0019 And/or • DTC U112300 with symptom Code 1123220 within address 00A5

2068273/5

Service Bulletin/Repair Instructions

Multiple random misfired evident during PDI. Condition: Multiple random cylinder misfire DTC’s detected during PDI - DTC P030000: Random/Multiple Cylinder Misfire Detected (misfires on multiple cylinders) within the following control units: • V8 - ECM 1 - V8 (Address 01) ECM control unit • W12 - ECM 1 - (Address 01) and/or ECM 2 (Address 11)

2075331/3

Service Bulletin/Repair Instructions

Engine light in the DIP - Various oxygen sensor / Fuel ratio DTC's logged within the Engine Control Module(s).

2075786/2

Service Bulletin/Repair Instructions

Airbag, fire, accident (safety-related enquiry - reporting forms). There is a reporting obligation in the following cases: • Airbag/belt released/not released • General accident • Fire and scorching damage for all Bentley Vehicle models - every model year.

2077529/3

Service Bulletin/Repair Instructions

Seat Fans Inoperative | All Models | 17-25MY. Condition: Customer may report that the seat ventilation system is not functioning with no airflow from the seat ventilation ducts.

2028794/9

Service Bulletin/Repair Instructions

2063651/5

Service Bulletin/Repair Instructions

Tyre tread/sidewall crack(s)

2064337/4

Service Bulletin/Repair Instructions

Usage of E10 fuel. Condition In the event a customer asks if E10 fuel can be used, the operative must refer to the Technical background section of this TPI.

2065895/6

Service Bulletin/Repair Instructions

Rotating display/screen noise - Diagnosis for complaints relating to noise during operation and/or during a drive cycle.

2073377/3

Service Bulletin/Repair Instructions

TPMS - Warning within the Drivers Information Panel (DIP) - Tyre pressure sensor - Low battery.

2074835/3

Service Bulletin/Repair Instructions

Calendar function - No longer available. Condition: Calendar feature in the MMI does not work although the tile is visible Calendar feature in the ‘MyBentley’ App no longer visible

2064648/6

Service Bulletin/Repair Instructions

2078190/3

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Evaporator leak | Continental GT/GTC/Flying Spur | 18 - 26MY. Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2068946/10

Service Bulletin/Repair Instructions

2077519/3

Service Bulletin/Repair Instructions

Exterior Gap and Profile Information | 17 - 26MY. Condition: Customer and/or retailer may raise an issue with panel gaps/alignment or flushness.

2071131/5

Service Bulletin/Repair Instructions

Measured values - Cycle recording instructions. Condition: In some cases Measured value traces may be requested in XML format for analysis by Product Support.

2069493/4

Service Bulletin/Repair Instructions

Right and/or left hand front rearmost lower suspension lever inner hydraulic mount replacement guidelines. Condition: The right and/or left hand front rearmost lower suspension lever inner hydraulic mounts are leaking oil or showing signs of dry oil stains

2061362/6

Service Bulletin/Repair Instructions

DIP pop up 'Engine start system: fault' | Continental GT/GTC/Flying Spur | 18-24MY. Customer statement: Customer unable to intermittently start the engine with the start button Or Engine starts but customer gets a pop up error within the Drivers Information Panel (DIP)

2069806/7

Service Bulletin/Repair Instructions

HVAC refrigerant leakage suspected or reports of a damp/musty smell within the cabin - Diagnosis guidelines

2078395/1

Service Bulletin/Repair Instructions

Service info: Leather Damage/Anomalies | All Models. Condition: In rare instances the customer and/or retailer may identify the presence of damage or visual anomalies on leather trimmed surfaces within the vehicle cabin during or post pre-delivery inspection.

2078709/1

Service Bulletin/Repair Instructions

Failure of the Door Subframe Mounting Housing | Continental GT/GTC & Flying Spur. Condition: Failure of the door subframe mounting housing

2070768/2

Service Bulletin/Repair Instructions

New Continental GT/C & New Flying Spur - Air suspension warning light in the DIP. Customer statement: Air suspension warning light within the DIP.

2050542/8

Service Bulletin/Repair Instructions

Front Exterior Lighting Steamed Up/Leaks | 12-24MY.

2064555/3

Service Bulletin/Repair Instructions

Unusual Suspension Behaviour whilst static | Continental GT/GTC/Flying Spur | 18-24MY. Customer statement: Unusual air suspension behaviour when the vehicle is static for example: • Air suspension raising and lowering without request NOTE: Customer complaints regarding ‘hard’ suspension when driving the vehicle may also be received

2069806/6

Service Bulletin/Repair Instructions

HVAC refrigerant leakage suspected or reports of a damp/musty smell within the cabin - Diagnosis guidelines.

2078338/1

Service Bulletin/Repair Instructions

Rear Door Blind Defective Operation | Flying Spur | 20-26MY. Customer may report one or more of the following issues with the rear door blind: • Blind does not retract or extend properly • Blind fabric appears damaged or distorted • Letterbox-style flap is loose or detached • Audible rattling or clicking noise from door panel • Blind assembly partially or fully inoperative.

2078190/1

Service Bulletin/Repair Instructions

AC System not Cooling - HVAC Evaporator leak | Continental GT/GTC/Flying Spur | 18 - 25MY. Customer Statement: The customer may find that the A/C system not blowing cold air and / or Cooling performance has declined over time.

2071933/3

Service Bulletin/Repair Instructions

Headlamp Control Unit Replacement | Bentayga and Flying Spur | 20,21,22,24MY. Condition: Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or Daytime running light malfunction / operational issues (Inner lamp) Or Turn signal malfunction / operational issues (Outer lamp).

2061369/10

Service Bulletin/Repair Instructions

2071933/2

Service Bulletin/Repair Instructions

Headlamp Control Unit Replacement | Bentayga and Flying Spur | 20,21,22,24MY. Condition Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or Daytime running light malfunction / operational issues (Inner lamp) Or Turn signal malfunction / operational issues (Outer lamp).

2071239/3

Service Bulletin/Repair Instructions

2075786/1

Service Bulletin/Repair Instructions

2077519/2

Service Bulletin/Repair Instructions

Exterior Gap and Profile Information | 17 - 25MY. Condition: Customer and/or retailer may raise an issue with panel gaps/alignment or flushness.

2077529/2

Service Campaign

Seat Fans Inoperative | All Models | 17-25MY. Condition: Customer may report that the seat ventilation system is not functioning with no airflow from the seat ventilation ducts.

2064200/4

Service Bulletin/Repair Instructions

Groan/Creak noise during brake pedal operation | Continental GT/GTC/Flying Spur | 18-24MY. Condition: Groaning/creaking noise heard from the brake pedal during light application, in particular when the vehicle is at operating temperature.

2064555/2

Service Bulletin/Repair Instructions

2067955/5

Service Bulletin/Repair Instructions

BRD Fault Diagnosis - Mechanical Malfunction DTC B140107 | Continental GT/GTC/Flying Spur. Condition: • Bentley Rotational Display (BRD) operational issues • Mechanical malfunction DTC B140107 evident within 005F

2077519/1

Service Bulletin/Repair Instructions

Exterior Gap and Profile Information | 17 - 25MY. Condition: Customer and/or retailer may raise an issue with panel gaps/alignment or flushness

2077529/1

Service Bulletin/Repair Instructions

Seat Fans Inoperative | All Models | 17-25MY

2051519/14

Service Bulletin/Repair Instructions

HVAC distribution/operational issues - HVAC Motor defect DTC's logged | Continental GT/GTC & Bentayga Series. Condition: • HVAC distribution/operational issues • HVAC motor defect (DTC’s) evident within address 08 - Climatronic control unit, the DTC’s can be static or Intermittent

2066872/6

Service Bulletin/Repair Instructions

Fuel Pressure DTC P008700 / P008800 / Engine speed warning evident in the DIP | Continental GT/GTC & Flying Spur W12.

2051187/11

Service Bulletin/Repair Instructions

2061369/9

Service Bulletin/Repair Instructions

Engine overheating - Warning in the DIP (V8 Kovomo). Condition: One or a combination of the following symptoms are evident: • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2075140/2

Service Bulletin/Repair Instructions

Engine cooling system over cooling - One or a combination of DTC's may be evident P218100 - P1BB400.

2068273/4

Service Bulletin/Repair Instructions

Multiple random misfires evident during PDI. Condition: Multiple random cylinder misfire DTC’s detected during PDI - DTC P030000: Random/Multiple Cylinder Misfire Detected (misfires on multiple cylinders) within the following control units: • V8 - ECM 1 - V8 (Address 01) ECM control unit • W12 - ECM 1 - (Address 01) and/or ECM 2 (Address 11)

2070041/4

Service Bulletin/Repair Instructions

Engine coolant overheat warning in the DIP - One or a combination of DTC's may be evident P017B00 - P017C00 - P017E00. Customer statement: Engine coolant overheat warning within the DIP

2075318/2

Service Bulletin/Repair Instructions

Engine light in the DIP - Various Camshaft adjuster DTC's logged within the Engine Control Module(s).

2071131/3

Service Bulletin/Repair Instructions

Measured values - Cycle recording instructions. Condition: In some cases, Measured value traces may be requested in XML format for analysis by Product Support

2028794/8

Service Bulletin/Repair Instructions

Engine coolant mixture - Restrictions on use of desalinated water. Technical Background: An important factor of influencing the cooling system efficiency is the water used in the mixture Due to the different ingredients and characteristics existing in each country or even region, Bentley has decided to define the quality of water for cooling systems Demineralised water according to standard VDE 0510 meets all requirements and can be purchased worldwide Therefore undiluted coolant should be mixed in the correct ratio using demineralised water as detailed in Elsa Pro coolant specification, this will detail the ratio and type of coolant to use The use of desalinated water in the engine cooling system is specifically prohibited

2057978/8

Service Bulletin/Repair Instructions

Engine Lubricating Oil - Replenishment. Condition: Engine lubricating oil lamp illuminated on driver instrument panel. Engine lubricating oil requires “topping up” between services.

2059149/6

Service Bulletin/Repair Instructions

Engine OIl - Consumption - V8 Kovomo. Condition: Engine oil warning lamp illuminated within the Drivers Instrument Panel (DIP) Engine oil requires “topping up” between services Excessive engine oil consumption

2064337/3

Service Bulletin/Repair Instructions

Usage of E10 fuel. Condition: In the event a customer asks if E10 fuel can be used, the operative must refer to the Technical background section of this TPI Technical Background: Details on the introduction of E10 fuel which contains 10% ethanol and its usage on Bentley products • All vehicles produced post 1990 Model year can be run using E10 fuel However • All vehicles produced before 1990 Model year MUST NOT use E10 fuel

2064679/5

Service Bulletin/Repair Instructions

Oil leaking from tell tale hole - CDA actuator fixings or Fuel rail fixings or Vaccum assembly fixings - V8 Kovomo.

2065215/2

Service Bulletin/Repair Instructions

V8 Kovomo engine replacement (Fitment of ancillary components). Condition: Torque values for ancillary components (used during engine replacement) are not currently available within the Repair manual The affected components and torque values are as listed within the Technical background section of this TPI

2075331/2

Service Bulletin/Repair Instructions

Engine light in the DIP - Various oxygen sensor / Fuel ratio DTC's logged within the Engine Control Module(s),

2028808/8

Service Bulletin/Repair Instructions

Service info: Engine oil - Specific oil type and oil consumption reference. Condition: Engine oil level requires top up between services Technical Background: The use of the correct oil for each engine type is critical for its continued performance, reliability and ultimately warranty. The workshop manual should always be the first point of reference, ensuring the correct lubricant is used for each specific model year and engine type Should oil be required the parts catalogue must be referred to ensuring the correct VIN is always used when ordering

2063855/11

Service Bulletin/Repair Instructions

2069252/3

Service Bulletin/Repair Instructions

Warnings within the DIP for the rear steering system - DTC B200096 and/or P060700 evident within diagnostic address 00CB. Customer statement: • Rear Steering Fault warning present within the DIP.

2063410/7

Service Bulletin/Repair Instructions

Infotainment Main unit (5F / J794) fault finding/diagnosis procedure. Condition: Issue suspected with the Infotainment Main unit (5F / J794) - For example: • MMI screen image flickers or goes blank • No response to selection • Audio cuts out

2056407/6

Service Bulletin/Repair Instructions

Running gear - Noise identification. Customer statement: Noise complaint from the suspension and/or steering.

2063017/4

Service Bulletin/Repair Instructions

Road wheel inspection procedure. Condition: In the event a complaint is received regarding road wheel/s condition for example: • Scratches • Corrosion • Damage • Blemishes • Chipping

2063651/4

Service Bulletin/Repair Instructions

Tyre tread/sidewall crack(s)

2064648/5

Service Bulletin/Repair Instructions

2065148/5

Service Bulletin/Repair Instructions

V8 Kovomo - Engine MIL light on - DTC ' P04F000: EVAP system high pressure purge line performance' evident. Customer statement: • Engine MIL light illuminated within the DIP Workshop findings and observations: • DTC ‘P04F000: EVAP system high pressure purge line performance’ evident

2068946/9

Service Bulletin/Repair Instructions

2071674/3

Service Bulletin/Repair Instructions

V8 Kovomo - DTC - P025C00: Fuel Pump Module Control Circuit Low logged in 0001. Condition: • Engine management light illuminated within the DIP • DTC P025C00 Fuel Pump Module Control Circuit Low is evident within 0001 (Engine control unit)

2073377/2

Service Bulletin/Repair Instructions

TPMS - Warning within the Drivers Information Panel (DIP) - Tyre pressure sensor - Low battery.

2052785/9

Service Bulletin/Repair Instructions

Brake noise identification. Technical Background: Brake noises can be attributed to many causes, the most common causes are as follows: • Brake discs or pads are close to their wear limit • New brake pads and/or discs have not been properly bedded in after installation • Aftermarket pads or discs are installed • There is debris such as small stones, grit, road salt or sand between the brake disc and pad • Discs are covered in rust. Rust can form when the vehicle has been stationary for long periods of time

2066480/8

Service Bulletin/Repair Instructions

Headlamp switch not working / not illuminated - Numerous DTC's within 0009-Central Electrics (BCM1). Customer statement: • Headlamp switch not working / not illuminated when the ignition is switched on (following an ignition switch off) And/or • Yellow warning light/message within DIP (Adaptive lighting fault) And / or • Loss of rear fog light activation And / or • Loss of all-weather lighting mode activation And / or • Headlamps will default to dipped beam (however, high beam activation will still be possible manually)

2075533/1

Service Bulletin/Repair Instructions

Rear mood lighting strip replacement guidelines.

2075697/1

Service Bulletin/Repair Instructions

Front carpets / Mats wet - Musty smell in the cabin - Suspected leak from the water and condensate drains. Customer statement / workshop findings: • Water ingress into the left and/or right hand foot well • Front carpets and/or foot mats are wet • Musty smell in the cabin

2075769/1

Service Bulletin/Repair Instructions

Gear selection not possible after replacing the transmission or hydraulic control unit.

2075810/2

Service Bulletin/Repair Instructions

Rear Shock absorber leaking (Left and / or Right)

2075810/1

Service Bulletin/Repair Instructions

Customer statement / workshop findings: Oil leak evident from the rear shock absorber (Left and / or Right)

2075699/1

Service Bulletin/Repair Instructions

Water ingress into the front cabin footwell/bulkhead - Glass misting on the inside - Front carpets/mats wet.

2070638/2

Service Bulletin/Repair Instructions

Water evident on the A-Post pillar seam - Water dripping behind the door seal - Sunroof specified vehicles only.

2073954/2

Service Bulletin/Repair Instructions

Continental GT / C and Flying Spur - Rattle / Creak from the dashboard demister panel.

2075562/1

Service Bulletin/Repair Instructions

Keyless entry system (KESSY) function was found to be disabled when the vehicle was parked for a short duration of time. Customer statement / workshop findings: Keyless entry system (KESSY) function is disabled when the vehicle is parked for a short duration of time Technical background: The reported symptom is due to the Battery management shut off stages being too early due to the battery size being incorrectly entered on replacement

2075624/1

Service Bulletin/Repair Instructions

Front windscreen - Water ingress - Left or right hand side Or water ingress from the top of the front windscreen.

2075642/1

Service Bulletin/Repair Instructions

Rear window glass - Water ingress - Left Or right hand side or water ingress from the top of the rear window glass.

2075711/1

Service Bulletin/Repair Instructions

Bentley Rotational Display (BRD) clashing with the switch pack during rotation. Customer statement / workshop findings: Bentley Rotational Display (BRD) clashing with the MMI switch pack during rotation.

2061369/8

Service Bulletin/Repair Instructions

Engine overheating - Warning in the DIP (V8 Kovomo) Customer statement / workshop findings: One or a combination of the following symptoms are evident • Engine overheat warning in the DIP (Engine overheating) • Unusual cooling fan operation at high temperatures • P19F700: Low engine coolant temperature indicator lamp coolant too warm • Signs of coolant in the vacuum hoses for switch valve N649

2071131/2

Service Bulletin/Repair Instructions

Measured values - Cycle recording instructions. Technical background The instructions within the Measure section of this TPI have been generated to guide operatives through the process for recording Measured values in cycles by using self diagnosis, the Instructions also detail how to locate corresponding files which are required for analysis.

2073973/2

Service Bulletin/Repair Instructions

Continental GT / C and New Flying Spur - Outer dashboard speaker grille lifted / Incorrect flushness. Customer statement / workshop findings: Outer demister panel (speaker grille) lifted / Incorrect flushness.

2075419/1

Service Bulletin/Repair Instructions

DTC P057300: Brake Switch "A" Circuit High evident within the ECM(s) - Various warnings evident within the DIP. Customer statement / workshop findings: The following symptoms may be evident (depending on Model Year) 23 Model Year: • Drive system warning / safeguard warning in the DIP • DTC P057300: Brake Switch "A" Circuit High evident within the Engine Control Module(s) 24 Model Year: • Engine warning light evident within the DIP along with Drive system warning / safeguard warning in the DIP • DTC P057300: Brake Switch "A" Circuit High evident within the Engine Control Module(s)

2061743/6

Service Bulletin/Repair Instructions

Rear Shock absorber leaking (Left or Right. Customer statement / workshop findings: Oil leak evident from the rear shock absorber/s (Left and/or Right

2075318/1

Service Bulletin/Repair Instructions

Engine light in the DIP - Various Camshaft adjuster DTC’s logged within the Engine Control Module(s). Customer statement / workshop findings: Engine light in the DIP - Various Camshaft adjuster DTC’s logged within the Engine Control Module(s).

2075331/1

Service Bulletin/Repair Instructions

2075354/1

Service Bulletin/Repair Instructions

Fuel gauge operational issues - DTC's B103E1B and/or B10581B evident within address 0046. Customer statement: Fuel gauge does not change during a long journey or after refuelling the vehicle and does not show full after filling the fuel tank.

2070041/3

Service Bulletin/Repair Instructions

Engine coolant overheat warning in the DIP - One or a combination of DTC's may be evident P017B00 - P017C00 - P017E00. Customer statement: Engine coolant overheat warning within the DIP

2075140/1

Service Bulletin/Repair Instructions

Engine cooling system over cooling - One or a combination of DTC's may be evident P218100 - P1BB400. Customer statement / workshop findings: • DTC P218100 - Cooling System Performance and / or DTC P1BB400 Cylinder head temperature too low is stored in the Engine Control Module (ECM). • Emission Control Lamp illuminated on the Driver Instrument Panel.

2074992/2

Service Bulletin/Repair Instructions

Flying B mascot clear wings replacement procedure. Customer statement / workshop findings: One or both of the Flying B mascot clear wings are missing.

2075018/2

Service Bulletin/Repair Instructions

Issues with mobile phone wireless charging - Wireless charging does not work. The customer complains that the mobile device sometimes cannot be charged wirelessly.

2061362/5

Service Bulletin/Repair Instructions

Engine intermittently fails to start/DIP pop up 'Engine start system: fault'. Customer statement Customer unable to intermittently start the engine with the start button Or Engine starts but customer gets a pop up error within the Drivers Information Panel (DIP).

2074995/1

Service Bulletin/Repair Instructions

Front and/or rear internal door trim panel - Poor retention between the trim panel and door. Customer statement / workshop findings: Front and/or rear internal door trim panel - Poor retention between the door trim panel trim clips and door panel tucker studs.

2071525/3

Service Bulletin/Repair Instructions

Driver / Passenger door(s) creak on close - All models (front and / or rear).

2066480/7

Service Bulletin/Repair Instructions

Headlamp switch not working / not illuminated - Numerous DTC's within 0009-Central Electrics (BCM1).

2075018/1

Service Bulletin/Repair Instructions

Issues with wireless charging/wireless charging does not work. Customer statement / workshop findings: The customer complains that the mobile device sometimes cannot be charged wirelessly. One of the following three situations is described: • The phone gets very hot while charging and charging is cancelled. • The phone is not charged and the following message is shown on the MMI: “The device cannot be charged as there is another object in the charging cradle.” • The phone does not start charging after it has been placed in the charging cradle. • The phone or individual processes are switched off to protect the phone as a result of heat generation. The mobile device supports wireless charging or the customer uses a charging cover that enables wireless charging

2075037/1

Service Bulletin/Repair Instructions

‘High pitched noise’ from the roof console(s). Technical background: If the complaint is confirmed please refer to the instructions within the Measure section of this TPI

2074980/1

Service Bulletin/Repair Instructions

Boot release switch (Door) warranty guidelines. Customer statement / workshop findings: Boot release switch (Door) is loose or the switch has dropped into the front door aperture

2074992/1

Service Bulletin/Repair Instructions

Flying B mascot clear wings replacement procedure.

2060205/7

Service Bulletin/Repair Instructions

Engine Cooling System over cooling - DTC P218100 - V8 Kovomo. Technical background It is possible for the engine coolant Thermostat to corrode over time, this corrosion is due to an adverse reaction of the Thermostat material with the engine coolant. The corrosion and subsequent build-up of debris prevents the correct operation of the thermostat when closing, resulting in over cooling. The ECM triggers a DTC when the target engine temperature is outside of the specified parameter.

2068847/3

Service Bulletin/Repair Instructions

Rear side window blind/s fail to operate - Parts return requirement.

2074228/1

Service Bulletin/Repair Instructions

Rattle from the MMI switchpack. Customer statement / workshop findings: Rattle from the MMI switchpack at the locations shown in Figure 1. Technical background: The noise may be from the left and / or right hand metallic clip(s) as shown in Figure 2

2068946/8

Service Bulletin/Repair Instructions

DTC P0B2500 logged within address 0021 (Battery Energy Control Module 2) - Dynamic ride system warning visible. Customer statement: Bentley dynamic ride system fault is displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500 - Hybrid/EV Battery "A" Voltage low is stored within address 21- Battery Energy Control Module 2 Technical background: Possible internal fault with the super capacitor

2073973/1

Service Bulletin/Repair Instructions

New Continental GT / C and New Flying Spur - Outer dashboard speaker grille lifted / Incorrect flushness. Customer statement / workshop findings: Outer demister panel (speaker grille) lifted / Incorrect flushness.

2070643/5

Service Bulletin/Repair Instructions

Rear screen sunblind operational issues. Customer statement / workshop findings: One or a combination of the following symptoms are evident: Rear sunblind does not operate Rear sunblind is noisy during operation Rear sunblind operates sporadically Rear sunblind is detached on one side

2068946/7

Service Bulletin/Repair Instructions

DTC P0B2500 logged within address 0021 (Battery Energy Control Module 2) - Dynamic ride system warning visible. Customer statement / workshop findings Customer statement: Bentley dynamic ride system fault is displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500 - Hybrid/EV Battery "A" Voltage low is stored within address 21- Battery Energy Control Module 2 Technical background: Possible internal fault with the super capacitor

2069611/3

Service Bulletin/Repair Instructions

Flying B mascot clear wings replacement procedure. Customer statement / workshop findings One or both of the Flying B mascot clear wings are missing. In the event that one Flying B wing is missing the operative must replace both wings to eliminate a repeat repair.

2066236/5

Service Bulletin/Repair Instructions

Unintended sounding of the Alarm siren - Following activation of the ignition or whilst the vehicle is left standing. Workshop findings The following DTC’s could also be evident within diagnostic address 0046 and/or 00BB and/or 00BC • B131DF5: alarm system siren supply voltage lower limit value less than • B131D29: sirens / alarm horn for anti-theft warning system Range/Performance • B131D29: anti-theft alarm system siren / alarm horn signal, not valid

2072330/2

Service Bulletin/Repair Instructions

Front seat adjustment switch broken / damaged - Warranty exclusion for damaged / broken parts. Customer statement / workshop findings: Front seat adjustment switch is broken / damaged.

2071238/2

Service Bulletin/Repair Instructions

Coolant pump leaking (part number 07P 121 008B) - Low coolant warning - Engine overheating - DTC's evident. Customer statement / workshop findings: One or a combination of the following is evident: • Coolant leaking from the mechanical coolant pump • Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump • Low coolant level warning displayed within the DIP Or • Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113 or air in the coolant DTC’s (various) is evident in this scenario the operative should refer to TPI 2051893/-

2071239/2

Service Bulletin/Repair Instructions

Coolant pump leaking (part number 07P 121 008C) - Low coolant warning - Engine overheating - DTC's evident. Customer statement / workshop findings: One or a combination of the following is evident: • Coolant leaking from the mechanical coolant pump • Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump • Low coolant level warning displayed within the DIP Or • Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113 or air in the coolant DTC’s (various) is evident, in this scenario the operative should also refer to TPI 2051893

2073954/1

Service Bulletin/Repair Instructions

New Continental GT / C and New Flying Spur - Rattle / Creak from the dashboard demister panel. Customer statement / workshop findings Rattle / Creaking noise from the dashboard demister panel.

2066480/6

Service Bulletin/Repair Instructions

2069806/5

Service Bulletin/Repair Instructions

HVAC refrigerant leakage suspected or reports of a damp/musty smell within the cabin - Diagnosis guidelines. Customer statement / workshop findings: HVAC not cooling / HVAC cooling less than expected / HVAC refrigerant leakage confirmed Or The customer reports a damp/musty smell within the cabin Note: For this scenario please see the pre requisites below - Should no HVAC leak be evident and a damp/musty smell has been reported/identified the operative should first confirm that water is not leaking into the cabin please refer to all VIN applicable TPIs - Should there be no water leaks evident, the operative should check the HVAC and body drains for blockages, in the event the drains are blocked the drains must be unblocked, once this has been completed the operative should confirm if the damp/musty smell is still evident.

2070643/4

Service Bulletin/Repair Instructions

2073225/1

Service Bulletin/Repair Instructions

Infotainment screen stuck on loading - Message visible within the Infotainment screen. Customer statement / workshop findings: One or a combination of the following issues are evident: - Infotainment screen stuck on initialising Or - Loading messages are visible at start up (within multiple tiles) Or - Bentley Rotating Display (BRD) doesnt return to its previous state Technical background: Should the symptoms within the Customer statement/Workshop findings section be evident please conduct the instructions within the Measure section.

2051562/12

Service Bulletin/Repair Instructions

12 Volt - Battery condition checks. Customer statement / workshop findings: 12 volt battery flat or unserviceable Technical background: For all 12 volt battery issues relating to warranty or a parts warranty claim refer to the instructions within the Measure section.

2073377/1

Service Bulletin/Repair Instructions

TPMS - Warning within the Drivers Information Panel (DIP) - Tyre pressure sensor - Low battery. Customer statement: Tyre pressure sensor: low battery warning is evident with the Drivers Information Panel (DIP). Workshop findings: One or a combination of the following DTCs may also be evident: - C105016 Left Front Tyre Pressure Monitoring Sensor Voltage too low - C105116 - Right Front Tyre Pressure Monitoring Sensor Voltage too low - C105216 - Left Rear Tyre Pressure Monitoring Sensor Voltage too low - C105316 - Right Rear Tyre Pressure Monitoring Sensor Voltage too low.

2065895/5

Service Bulletin/Repair Instructions

Rotating display/screen noise - Diagnosis for complaints relating to noise during operation and/or during a drive cycle. Customer statement / workshop findings: Various rotating display screen noise during operation.

2066236/4

Service Bulletin/Repair Instructions

Unintended sounding of the Alarm siren - Following activation of the ignition or whilst the vehicle is left standing. Customer statement: Unintended sounding of the alarm siren following activation of the ignition Or Unintended sounding of the alarm siren whilst the vehicle is left standing. Workshop findings: - B131DF5: alarm system siren supply voltage lower limit value less than - B131D29: sirens / alarm horn for anti-theft warning system Range/Performance - B131D29: anti-theft alarm system siren / alarm horn signal, not valid

2066872/5

Service Bulletin/Repair Instructions

Fuel Pressure DTC's P008700 and / or P008800 and / or Max engine speed 4000 rpm warning evident in the DIP - W12 only. Customer statement / workshop findings: One or a combination of the following are evident: - DTCs P008700 and / or P008800 are evident within the master and/or slave engine control modules - Emission control warning lamp (Figure 1) illuminated within the Drivers Information Panel (DIP) - The Max engine speed 4000 rpm warning lamp may also be evident within the Drivers Information Panel (DIP) as shown in Figure 2

2067579/4

Service Bulletin/Repair Instructions

Repeated traction control interventions experienced upon reaching 30km/h. Technical background: In the event the issue is as exactly as described, refer to the instructions within the Measure section.

2068946/6

Service Bulletin/Repair Instructions

DTC P0B2500 logged within address 0021 (Battery Energy Control Module 2) - Dynamic ride system warning visible. Customer statement: Bentley dynamic ride system fault is displayed within the Drivers Instrument Panel (DIP). Workshop findings: DTC P0B2500 - Hybrid/EV Battery "A" Voltage low is stored within address 21- Battery Energy Control Module 2.

2066872/4

Service Bulletin/Repair Instructions

2073021/1

Service Bulletin/Repair Instructions

The Netflix application cannot be updated within the (BYOC) rear seat entertainment system. Customer statement / workshop findings: Netflix application update prompt is shown within the (BYOC) rear seat entertainment system. Technical background: In the event the issue described is evident the operative should conduct the instructions within the Measure section.

2061369/6

Service Bulletin/Repair Instructions

Engine overheating - Warning on the DIP - V8 Kovomo. Customer statement / workshop findings: - Customer reports an engine overheat warning within the DIP - Engine overheating - Unusual cooling fan operation at high temperatures - There are no obvious signs of coolant leaks both internally or externally Workshop findings - P19F700: Low engine coolant temperature indicator lamp Coolant too warm - Signs of coolant in the vacuum hoses (Refer to the video on the Bentley Hub referencing TPI 2061369.

2068946/5

Service Bulletin/Repair Instructions

DTC P0B2500 logged within address 0021 (Battery Energy Control Module 2) - Dynamic ride system warning visible. Customer statement / workshop findings: Bentley dynamic ride system fault is displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500 - Hybrid/EV Battery "A" Voltage low is stored within address 21- Battery Energy Control Module 2.

2069252/2

Service Bulletin/Repair Instructions

Warnings within the DIP for the rear steering system - DTC B200096 and/or P060700 evident within diagnostic address 00CB. Customer statement / workshop findings: - Rear Steering Fault warning present within the DIP. Workshop findings: The following DTCs could be evident within diagnostic address 00CB - Rear Axle Steering control module - DTC B200096 and/or P060700 - The rear wheels may also be tracking incorrectly. Technical background: In the event the symptom described with the Customer statement/workshop findings section is evident the operative should conduct the instructions within the Measure section.

2054599/9

Service Bulletin/Repair Instructions

Diagnosis guidelines relating to Headlamp operation/Daytime running lights (Inner lamp) and/or Turn signal (Outer lamp). Customer statement / workshop findings: Operational issues are evident with one or a combination of the following: - Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or - Daytime running light malfunction / operational issues (Inner lamp) Or - Turn signal malfunction / operational issues (Outer lamp) Or Numerous static and/or intermittent DTCs are evident within the left light control unit (Diagnostic address D6) and/or the right light control unit (Diagnostic address D7)

2055846/9

Service Bulletin/Repair Instructions

Infotainment screen turns red sporadically. Customer statement / workshop findings Infotainment screen 'Goes Red Fully or partially' within the MMI Screen.

2059149/5

Service Bulletin/Repair Instructions

Engine Oil - Consumption - V8 Kovomo. Customer statement / workshop findings: Engine oil warning lamp illuminated within the Drivers Instrument Panel (DIP) Engine oil requires topping up between services. Excessive engine oil consumption.

2061537/7

Service Bulletin/Repair Instructions

Infotainment home screen - Loading messages visible on start up in multiple tiles. Customer statement / workshop findings Upon start-up of the Home screen, loading messages can be seen in some or all of the tiles. Measure: A delay when loading tiles is normal, this is due to the amount of external data that is required to load each individual tile, including multiple pages of external data that can be associated with each individual tile.

2067955/4

Service Bulletin/Repair Instructions

Rotating display/screen - Fault diagnosis - Mechanical malfunction DTC B140107 is evident within 005F. Customer statement / workshop findings: - Bentley Rotational Display (BRD) operational issues - Mechanical malfunction DTC B140107 evident within 005F

2070041/2

Service Bulletin/Repair Instructions

Coolant warning lamp within the DIP - One or a combination of DTC's is evident P218100 - P017B00 - P017C00 - P017E00. Customer statement: Customer reports a red engine coolant overheat warning within the DIP Workshop findings. One or a combination of the following DTCs are evident within the engine control unit: - P218100 - Malfunction in cooling system - P017B00 - Cylinder head temperature sensor implausible signal - P017C00 - Cylinder head temperature sensor short circuit to ground - P017E00 - Cylinder head temperature sensor open circuit/loose contact.

2071933/1

Service Bulletin/Repair Instructions

Headlamp control unit replacement and/or turn signal control unit replacement. Customer statement / workshop findings: Headlamp low beam / high beam malfunction / operational issues (Inner lamp) Or Daytime running light malfunction / operational issues (Inner lamp) Or Turn signal malfunction / operational issues (Outer lamp).

2072330/1

Service Bulletin/Repair Instructions

Front seat adjustment switch broken / damaged - Warranty replacement guidelines. Customer statement / workshop findings: Front seat adjustment switch is broken / damaged

2072468/2

Service Bulletin/Repair Instructions

2062184/9

Service Bulletin/Repair Instructions

Electronic Parking Brake (EPB) functionality issues. Customer statement / workshop findings: The following issues could be evident during PDI or found whilst in service: - EPB may not hold the car effectively - Parking brake components showing signs of wear - Parking brake warning light may also be evident within the DIP.

2071525/1

Service Bulletin/Repair Instructions

Driver / Passenger door(s) creak on close - All models (frond and/or rear). Customer statement / workshop findings: Driver and / or Passenger door creak during the Power close function - Front and / or rear (Depending on vehicle type) Technical background: Ensure the fault is as described within the Customer statement Workshop findings section before continuing.

2066040/3

Service Bulletin/Repair Instructions

Oil leak from the oil separator/breather connection - Intake manifold whistle - Engine warning lamp illuminated. Customer statement - Engine warning lamp illumintaed within the DIP And/or - Whistling noise(s) from the Inlet manifold Workshop findings: Oil leak between the oil separator tank and the Bank 1 breather line connection

2068847/2

Service Bulletin/Repair Instructions

Rear side window blind/s fail to operate - Parts return requirement. Customer statement / workshop findings Rear side window blind(s) do not operate - Rear blind/s do not operate following a CAN bus sleep - Rear blind/s do not operate if the switch operation is a prolonged hold instead of a Press and release operation - Rear blind/s do not operate following the loss of control module basic settings - Rear blind/s will also not operate if the Child Lock is on - Rear blind/s will cease to operate if there are repeated operations of the blind sufficient to trigger a failsafe mode (usually between 10 to 15 operations in a very short period) - As instructed within the owners handbook, the rear blind/s will not operate if the rear window is in the lowered position - The blind will also not operate in extreme cold temperature for example -10 degrees Celsius or 14 degrees, Fahrenheit.

2072055/1

Service Bulletin/Repair Instructions

Spurious DTC identification. Customer statement / workshop findings: Customers will not be aware of any DTCs, workshop operatives may discover spurious DTCs whilst running Guided Fault Finding (GFF) when using ODIS Technical background: To determine the course of action which should be taken the operative should refer to the Bentley Hub referencing the following: Spurious DTC list for TPI 2072055 The document contains all known spurious DTCs for all applicable vehicle variants.

2072280/1

Service Bulletin/Repair Instructions

Tyre sealant - Incorrect expiry date. Customer statement / workshop findings: The date shown on the tyre sealant canister (04/2023) indicates the sealant has expired.

2058423/11

Service Bulletin/Repair Instructions

New Continental GT/GTC, New Flying Spur and Bentayga - Low Oil Pressure Warning During Early Vehicle Life - W12 only. Customer statement / workshop findings: Warning on the Driver Instrument Panel (DIP) - Oil pressure too low DTCs relating to oil pressure may also be stored within the Master ECU. Diagnostic Trouble Codes (DTC) P052400: Engine Oil Pressure Too Low and/or P15AA00: Engine oil pressure - Lower limit not reached stored in the Master Engine Control Unit (ECU).

2070643/3

Service Bulletin/Repair Instructions

Rear screen sunblind not operating to specification - Minimum diagnosis requirements before replacing the sunblind. Customer statement / workshop findings The rear screen sunblind is not operating to specification Or a combination of the following symptoms are evident - Rear sunblind does not operate - Rear sunblind is noisy during operation - Rear sunblind operates sporadically - Rear sunblind is detached on one side.

2062257/6

Service Bulletin/Repair Instructions

Keyless door entry does not work - Front Outside Door Handle(s) - Touch Sensor DTC B147613 and/or B147713 are present. Customer statement / workshop findings: Keyless entry does not work Workshop findings: Front outside door handle(s) touch sensor open circuit DTC(s) present within address 0046.

2063855/9

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - evident within address 0019 and/or DTC U112300 evident in 00A5. Customer statement: Lane Assist and/or Traffic Assist are not functional Workshop findings: - DTC - B17B801 - Steering Wheel Touch Recognition Control Module evident within address 0019 And/or - DTC B17B804 - Steering Wheel Touch Recognition Control Module electrical error - evident within address 0019 And/or - DTC U112300 with symptom Code 1123220 within address 00A5.

2051519/13

Service Bulletin/Repair Instructions

HVAC distribution/operational issues - HVAC Motor defect DTCs logged. Customer statement / workshop findings: - HVAC distribution/operational issues - HVAC motor defect (DTCs) evident within address 08 - Climatronic control unit, the DTCs can be static or Intermittent Technical background: Where VIN applicable the operative MUST first conduct Service Campaign EB28 (Bentayga) or EB29 (New Continental GT/GTC).

2071149/2

Service Bulletin/Repair Instructions

Testing electrical circuits - Diagnosis guidelines - Training videos. Customer statement / workshop findings: Technical DISS queries with extended downtime can be caused by incorrect diagnosis and testing of the vehicles electrical circuits In a small number of isolated cases basic electrical faults were found to be overlooked. Technical background: The information within this TPI has been generated to make retailers aware of two specific videos (Figure 1) Advanced Vehicle Electrics - Measurements of Circuits Video - Voltage drop testing - Voltage drop testing using the VAS 6356 scope Advanced Vehicle Electrics - Actuators & Voltage Supply Diagnosis - Terminal drag testing

2071772/1

Service Bulletin/Repair Instructions

New Continental GT, GTC and Flying Spur - Front anti roll bar link - Diagnosis guidelines. Customer statement / workshop findings Workshop findings: Front anti roll bar link lower bushes have small cracks on the surface. Technical background Front anti roll bar links have been incorrectly diagnosed and unnecessarily replaced Front anti roll bar links were replaced due to minor splits being identified during a routine service inspection or noise complaints. Do Not replace the front anti roll bar links when small splits are identified on the lower bushes as shown in Figure 1.

2065895.4

Service Bulletin/Repair Instructions

Rotating Display/screen noise - Diagnosis for complaints relating to noise during operation and/or during a drive cycle Customer Statement: -Various rotating display screen noise during operation

2067955.3

Service Bulletin/Repair Instructions

Rotating display/screen - fault diagnosis - mechanical malfunction DTC B140107 is evident within 005f Customer Statement: -Bentley Rotational Display (BRD) operational issues -Mechanical malfunction DTC B140107 evident within 005F

2028794.7

Service Bulletin/Repair Instructions

Engine Coolant Mixture - Restrictions on use of desalinated water Customer Statement: -Engine coolant requires topping up or replacing

2051937.9

Service Bulletin/Repair Instructions

Front centre console lid (cup holder assembly) fails to latch/unlatch Technical Background: -Application of grease to both of the centre console storage box frame ribs as described within the Measure section is required.

2052785.8

Service Bulletin/Repair Instructions

Brake Noise Identification: Customer Statement: -Noise/squeal complaint from the braking system Technical Background: -The noise/squeal can be reproduced and clearly assigned to the braking system

2060446.8

Service Bulletin/Repair Instructions

Clicking noise from the front wheels whilst performing a static lock to lock steering manoeuvre Technical Background: -Verify the customer complaint matches the video within the Bentley Hub - Reference TPI Transaction number 2060446/-

2071606.1

Service Bulletin/Repair Instructions

EPB fault warning within the DIP - DTC C1000C07 with symptom code 0x50100 stored in address 03 (J104) Customer statement: -EPB fault warning within the DIP

2071674.2

Service Bulletin/Repair Instructions

V8 Kovomo - DTC - P025C00: Fuel Pump Module Control Circuit Low Logged in 0001 Customer Statement: -Engine management light illuminated within the DIP -DTC P025C00 Fuel Pump Module Control Circuit Low is evident within 0001

2060605.6

Service Bulletin/Repair Instructions

New Flying Spur - Rear Entertainment - Component Protection Customer Statement: -Rear Entertainment display screen shows (Component Protection Active). Diagnostic Trouble Code (DTC) U110100 Component Protection Active stored within 004E (Display/Control head HR) and/or 005E (Display/Control Head LH).

2060645.5

Service Bulletin/Repair Instructions

New Flying Spur - Boot open/close function inoperative Customer Statement: -Boot operational issues for example: >The boot does not open or close as expected

2061195/3

Service Bulletin/Repair Instructions

Telephone Functionality Complaint - Minimum Standards Required For Analysis Of Concerns. Customer statement / workshop findings: The feedback method within this TPI is required should a complaint of telephone functionality and/or quality be reported. Technical background: The minimum standards check list document within the Measure section is required to capture an accurate description of customer telephone issues.

2061288/6

Service Bulletin/Repair Instructions

Various and/or numerous Transmission control module DTCs logged - V8 Kovomo engine. Customer statement / workshop findings: Drive system fault active on DIP. Workshop findings: Various and/or numerous Transmission control module DTCs logged. Technical background: Loose pins within the transmission link harness to the Mechatronic unit for dual clutch gearbox -J743- connections can lead to various and/or numerous Transmission control module DTCs being logged. Carry out the checks within the Measure section of this TPI.

2061362/4

Service Bulletin/Repair Instructions

Engine intermittently fails to start/Kombi pop up 'Engine start system: fault. Customer statement: Customer unable to intermittently start the engine with the start button Or Engine starts but customer gets a pop up error on the Kombi. Technical background: The Access/start authorization button requires a certain amount of force applying to activate the internal switches If all 3 switches within the Access/start authorization button are not engaged multiple times in a row the above DTC will store and the customer will get a pop up on the Kombi. The engine however, will still start up.

2061536/7

Service Bulletin/Repair Instructions

Infotainment screen stalls at Initializing. Customer statement / workshop findings Upon start-up of the Infotainment system, the home screen appears to be stuck in the Initializing stage, when this scenario is evident a spinning wheel is visible.

2061537/6

Service Bulletin/Repair Instructions

Infotainment home screen - Loading messages visible on start up in multiple tiles. Customer statement / workshop findings: Upon start-up of the Home screen, loading messages can be seen in some or all of the tiles.

2061743/5

Service Bulletin/Repair Instructions

Rear Shock absorber leaking (Left or Right). Customer statement / workshop findings: Oil leak evident from the rear shock absorber/s (Left and/or Right) Technical background: Should oil be leaking from the left or right rear shock absorber as shown in Figures 1 - 2 and 3, the operative should refer to the Measure section of this TPI.

2062016/5

Service Bulletin/Repair Instructions

DTC's P014800 and/or P008A00 - Rough running & potentially poor start up performance - MIL light on - Possible misfires. Customer statement: - The Engine management light is on - Rough running and potentially poor start up performance. and/or - Engine misfires. Technical background: Debris in the fuel system can lead to a blockage in the low pressure fuel injectors, ultimately causing a cylinder misfire

2062184/8

Service Bulletin/Repair Instructions

Electronic Parking Brake (EPB) functionality issues. The following issues could be evident during PDI or found whilst in service - Electronic Parking Brake (EPB) found not operating to specification - EPB may not hold the car effectively - Parking brake components showing signs of wear - Parking brake warning light may also be evident within the DIP (See example shown in Figure 1)

2062257/5

Service Bulletin/Repair Instructions

Keyless door entry does not work - Front Outside Door Handle(s) - Touch Sensor DTC B147613 present. Customer statement: Keyless entry does not work. Workshop findings: Front Outside Door Handle(s) Touch Sensor open circuit DTCs present within address 0046. NOTE: The afore mentioned issue does not affect the ability to lock/unlock the vehicle manually by inserting the key into either of the front door locks or by using the lock/unlock buttons on the ignition key fob.

2063029.4

Service Bulletin/Repair Instructions

EPB fault warning within the DIP - DTCs stored in address 03 - C100C01 and C1246F9 Customer Statement: -EPB fault warning within the DIP with one or both DTCs as listed below: C100C01: Electro-mechanical parking brake button electrical error And/or C1246F9: Electromechanical parking brake Button interruption.

2063410.5

Service Bulletin/Repair Instructions

Infotainment Main unit (5F / J794) fault finding/diagnosis procedure Customer Statement: Issue suspected with the Infotainment Main unit (5F / J794) - For example: MMI screen image flickers or goes blank No response to selection Audio cuts-out

2063651.3

Service Bulletin/Repair Instructions

Tyre tread/sidewall crack(s) Customer Statement: -Cracks evident in the sidewall and/or tread pattern (See the examples in Figures 1 and 2 showing cracks within the tread pattern)

2063729.4

Service Bulletin/Repair Instructions

Fitment of Control Modules from Donor Vehicles For Test Purposes Technical Background: If an issue is suspected for one of the control modules listed below: Onboard supply control unit (J519) Convenience system central control unit (J393) Data bus diagnostics interface (J533) Control unit 1 for Information Electronics (J794) Control unit in dash panel insert (J285) Emergency call module control unit (J949)

2063954.5

Service Bulletin/Repair Instructions

Engine warning light illuminated within the DIP during acceleration - DTC P029900 evident - W12 TSI only Customer Statement: -Engine warning light and max engine speed 4000 rpm warning evident within the DIP during acceleration - Warning on DIP first appears when accelerating (During boost)

2064477.5

Service Bulletin/Repair Instructions

Knock/clunk noise from the rear of the vehicle (Rear axle) Customer Statement: -Knock/clunking noise heard from the rear of the vehicle when changing direction at low speed

2064648.4

Service Bulletin/Repair Instructions

ACC Unavailable-Traffic Assist Failure-Safeguard Failure-Radar Malfunction Warning DIP - Numerous DTCs within 0013 Customer Statement: One or numerous of the following issues are evident: ACC Failure Traffic Assist Failure Safeguard Failure Radar Malfunction

2064791.3

Service Bulletin/Repair Instructions

Knocking noise from the front and/or rear (Driving over an uneven road surface) Technical Background: The noise present in the sound file can be caused by worn anti roll bar bushes, the noise can appear when driving over an uneven road surface or during a large suspension input for example: Speed humps or potholes

2065085.3

Service Bulletin/Repair Instructions

Knocking noise from the front and/or rear - DTC C1298F1 evident within D4 and/or D5 Customer Statement: -Knocking noise from the underside of the vehicle (front and/or rear) when driving on uneven road surfaces - DTC C1298F1 (Suspension stabilization actuator Regulation not possible) evident within diagnostic address D4 and/or D5 -Bentley Dynamic ride fault evident within the DIP

2065698.3

Service Bulletin/Repair Instructions

V8 Kovomo - Emission control warning illuminated within the DIP - Exhaust Gas Temperature Sensor DTCs evident Customer Statement: -Emission control system warning lamp illuminated (Figure 1) within the Driver Information Panel (DIP)

2065922.3

Service Bulletin/Repair Instructions

Bentley dynamic ride system warning displayed - DTC P0B2600 with symptom code 28672 Customer Statement: -Bentley dynamic ride system fault warning displayed within the DIP

2066236.3

Service Bulletin/Repair Instructions

Unintended sounding of the Alarm siren - Following activation of the ignition or whilst the vehicle is left standing Customer Statement: Unintended sounding of the alarm siren following activation of the ignition Or Unintended sounding of the alarm siren whilst the vehicle is left standing

2066669.3

Service Bulletin/Repair Instructions

Engine coolant - Overheat condition - Warning evident within the DIP - DTCs P2B6500 and P2B8600 are evident Customer Statement: -Engine cooling system overheating And/or Coolant loss And/or Warning light in Drivers Information Panel (DIP) as Figure 1

2066852.4

Service Bulletin/Repair Instructions

Shaker Speaker - Diagnostic Checks Customer Statement: -Customer complains of poor quality music output from the shaker speaker due to a rattling noise/sound distortion

2067483.4

Service Bulletin/Repair Instructions

(Drive System Fault) warning present within the DIP - Under full throttle conditions Symptoms: Acceleration limitation with erratic engine behaviour under full throttle conditions Under acceleration the vehicle appears to be slow and unresponsive The engine appears to be underpowered during acceleration Drive System Fault warning evident within the DIP

2067579.3

Service Bulletin/Repair Instructions

Repeated traction control interventions experienced upon reaching 30km/h Customer Statement: -Repeated traction control interventions experienced upon reaching 30km/h (Figure 1) Technical Background: -In the event the issue is as exactly as described, refer to the instructions within the Measure section

2068273.3

Service Bulletin/Repair Instructions

Multiple Random Misfires Evident During PDI Customer Statement: -Multiple random cylinder misfire DTCs detected during PDI - DTC P030000: Random/Multiple Cylinder Misfire Detected (misfires on multiple cylinders) within the following control units: -V8 - ECM 1 - V8 (Address 01) ECM control unit -W12 - ECM 1 - (Address 01) and/or ECM 2 (Address 11)

2071668.1

Service Bulletin/Repair Instructions

V8 Kovomo - Engine Misfires - Engine management light illuminated within the DIP Customer Statement: -Engine misfiring -Engine running rough (not refined) -Engine misfire DTCs evident -Engine management light illuminated within the DIP -Knocking noise from the cylinder head

2050542.7

Service Bulletin/Repair Instructions

Service info: body/equipment: front exterior lighting steamed up/leaks Customer Statement: -1. The lenses of the headlights (illustration 1a) /front fog lamps (illustration 1b) are steamed up/damp from the inside with minor drips. 2. Water is in the headlight (illustration 2a) / front fog lamp (illustration 2b), big drips.

2051219.10

Service Bulletin/Repair Instructions

W12 TSI Camshaft Phaser Position Related DTC Customer Statement: -Customer reporting (Emission Control Warning Indicator) displayed. Engine running rough.

2051776.5

Service Bulletin/Repair Instructions

Key blade can be difficult to remove from key fob. Technical Background: -Deviations in the key blade and key fob assembly could make it difficult to remove the key blade.

2053350.5

Service Bulletin/Repair Instructions

W12 - Oil leak from engine Technical Background: -The breather return line and the oil dipstick tube Orings can split causing an external oil leak. This can be misdiagnosed as the engine sump leaking.

2053351.9

Service Bulletin/Repair Instructions

Buzzing noise from engine area Workshop Findings: -Buzzing noise heard at idle from the sump area when the vehicle is elevated on a workshop ramp. The noise cannot be heard from inside the cabin or outside of the vehicle in normal circumstances.

2053429.6

Service Bulletin/Repair Instructions

Emission control system lamp illuminated - DTC P044100 evident Customer Statement: -Emission control system warning lamp illuminated (Figure 1) within the Driver Information Panel (DIP) in conjunction with DTC - P044100: EVAP Emission Contr.Sys.Incorrect Purge Flow - logged within one or both engine control modules

2055772.6

Service Bulletin/Repair Instructions

Battery conditioner inoperative Technical Background: -Corrosion on the contact surfaces of the charger socket and charger lead. If the charging socket or charger lead are wet when the charger is connected this can cause corrosion on the contacts.

2055846.8

Service Bulletin/Repair Instructions

Infotainment screen turns red sporadically Customer Statement: -Infotainment screen 'Goes Red Fully or partially' within the MMI Screen (Figure 1)

2056407.5

Service Bulletin/Repair Instructions

Running gear - Noise identification Workshop Findings: -The noise can be reproduced and clearly assigned to the suspension system from either of the axles And/or The noise can be reproduced and clearly assigned to the steering system Prior to starting the instructions within this TPI, the Retailer must check and confirm the vehicle is in standard factory condition and has not had any non-approved aftermarket modifications conducted including the modification of the engine control modules (chip tuning) Check the history of the vehicle to confirm Should any aftermarket modifications be found, the Retailer must make Product Support aware by raising a DISS query to report the details of the modification, you must then await feedback from Product Support before conducting any further work

2057978.7

Service Bulletin/Repair Instructions

Engine Lubricating Oil - Replenishment Customer Statement: -Engine lubricating oil lamp illuminated on driver instrument panel. Engine lubricating oil requires topping up between services.

2058354.6

Service Bulletin/Repair Instructions

New Flying Spur - Flying (B) Mascot Customer Statement: -This Technical Product Information (TPI) Document is designed to give repair guidance and standardised fault reporting for Flying (B) functionality, poor finish and damage concerns.

2058423.10

Service Bulletin/Repair Instructions

New Continental GT/GTC, New Flying Spur and Bentayga - Low Oil Pressure Warning During Early Vehicle Life - W12 only Customer Statement: -Warning on the Driver Instrument Panel (DIP) - Oil pressure too low DTCs relating to oil pressure may also be stored within the Master ECU. Diagnostic Trouble Codes (DTC) (P052400: Engine Oil Pressure Too Low) and/or (P15AA00: Engine oil pressure - Lower limit not reached stored in the Master Engine Control Unit (ECU)

2058837.5

Service Bulletin/Repair Instructions

DTC's C135DF0 and/or C12F000 evident within the Steering rack and power steering control unit (J500) Customer Statement: -DTC's C135DF0 and/or C12F000 evident within the Steering rack and power steering control unit (J500) Diagnostic address 44

2059068.6

Service Bulletin/Repair Instructions

Transmission communication DTC's (Numerous) - W12 engine Customer Statement: -Drive system fault active on DIP (Figure 1)

2059333.5

Service Bulletin/Repair Instructions

Unable to open, or delay in opening the Drivers or Front passenger door from outside using the door handle (Keyless) Technical Background: -In the event there is a customer complaint regarding the opening of the door from the outside of the vehicle when using the door handle (Keyless entry) please refer to the Measure section of this TPI

2059489.4

Service Bulletin/Repair Instructions

Start/Stop system inhibit - Driver's seat belt unfastened Customer Statement: -The Start/Stop system functions with the drivers seat belt not fastened although the Owners handbook states that the drivers seat belt must be fastened for the Start/Stop system to function

2062259.6

Service Bulletin/Repair Instructions

Air suspension warning light within the DIP - DTC's P089200 - C104707 - C103B13 - Evident within Address 74 Customer Statement: -Air suspension warning light within the DIP

2063017.3

Service Bulletin/Repair Instructions

Road wheel inspection procedure Customer Statement: In the event a complaint is received regarding road wheel/s condition for example: - Scratches - Corrosion - Damage - Blemishes - Chipping Please refer to the onward instructions

2065895.3

Service Bulletin/Repair Instructions

Rotating display/screen noise - Diagnosis for complaints relating to noise during operation and/or during a drive cycle Customer Statement: -Various rotating display/screen noises during operation

2068946.4

Service Bulletin/Repair Instructions

Bentley dynamic ride system warning - DTC P0B2500: Hybrid/EV Battery (A) Voltage low stored (48 volt system) Customer Statement: -(Bentley dynamic ride system: fault) displayed within the Drivers Instrument Panel (DIP)

2070344.3

Service Bulletin/Repair Instructions

Headlamp control unit replacement - Bentayga and New Flying Spur Customer Statement: -Headlamp is not working or the headlamp is flickering

2051562/11

Service Bulletin/Repair Instructions

2053177/19

Service Bulletin/Repair Instructions

All Vehicle Variants - Spurious DTC List. Customer statement / workshop findings: Customers will not be aware of any fault codes Workshop may discover spurious fault codes whilst running a Diagnostic Trouble Code (DTC) log as part of other investigations on the vehicle Technical background: The operative should refer to the Bentley Hub referencing TPI 2053177/- The document (loaded onto the Hub) contains all of the current known Spurious DTCs for all vehicle variants Should a particular TPI be listed as Archived, the TPI can no longer be viewed within Elsa pro, in this case please refer to the instructions within TPI 2053177/- regarding the DTC description and actions which should be conducted (if any).

2051519/12

Service Bulletin/Repair Instructions

HVAC distribution/operational issues - HVAC Motor defect DTCs logged. Customer statement / workshop findings: - HVAC distribution/operational issues - HVAC motor defect (DTCs) evident within address 08 - Climatronic control unit, the DTCs can be static or Intermittent, NOTE: Before removing any of the following components to gain access to faulty motor(s) the operative MUST raise a technical DISS query to gain permission Hint: A current ODIS log must be attached to the technical DISS query - Dashboard assembly - Head up display unit - HVAC unit.

2064648/3

Service Bulletin/Repair Instructions

ACC Unavailable-Traffic Assist Failure-Safeguard Failure-Radar Malfunction Warning DIP - Numerous DTC's within 0013. Customer statement / workshop findings: One or numerous of the following issues are evident: - ACC Failure - Traffic Assist Failure - Safeguard Failure - Radar Malfunction Workshop findings: One or a combination of the following DTCs and symptom codes are evident within address 0013 - B200FF0 with Symptom code(s) 1367 and/or 1313 and/or 1334 - Internal Malfunction.

2070344/2

Service Bulletin/Repair Instructions

Headlamp control unit replacement - Bentayga and New Flying Spur. Customer statement / workshop findings: Headlamp is not working or the headlamp is flickering Workshop findings Headlamp assembly diagnosed as faulty. Technical background: It is not possible to determine between internal lamp defects and control unit failures therefore this TPI is to advise the replacement of the control unit in the first instance The complete headlamp assembly should only be replaced if control unit replacement was not successful.

2069806/4

Service Bulletin/Repair Instructions

HVAC refrigerant leakage suspected or reports of a damp/musty smell within the cabin - Diagnosis guidelines. Condition HVAC not cooling / HVAC cooling less than expected / HVAC refrigerant leakage confirmed Or The customer reports a damp/musty smell within the cabin. - Should no HVAC leak be evident and a damp/musty smell has been reported/identified the operative should first confirm that water is not leaking into the cabin please refer to all VIN applicable TPIs particularly TPI 2062622/- - Should there be no water leaks evident, the operative should check the HVAC and body drains for blockages, in the event the drains are blocked the drains must be unblocked, once this has been completed the operative should confirm if the damp/musty smell is still evident.

2051893/5

Service Bulletin/Repair Instructions

Overheat condition-DTC logged for air in the system or DTC P218100-Cooling System Performance with symptom code 8113. Customer statement / workshop findings One or a combination of the following symptoms are evident: - Engine coolant overheat condition - Coolant loss - Diagnostic trouble codes (DTCs) logged within the Engine control module/s relating to Air in the coolant system - Engine overheating issues and/or DTC P218100: Cooling System Performance symptom code 8113 is evident - Warning light within the Drivers Information Panel (DIP). Measure 1) Fully drain the cooling system - Refer to Elsa Pro Rep.Gr 19 Cooling system - To drain and fill 2) Replace the Thermostat housing (includes thermostat) - Refer to Elsa Pro Rep.Gr 19 Cooling system - Thermostat - To replace

2071238/1

Service Bulletin/Repair Instructions

Coolant pump leaking (part number 07P 121 008B) - Low coolant warning - Engine overheating - DTCs evident. Customer statement / workshop findings: One or a combination of the following is evident: - Coolant leaking from the mechanical coolant pump - Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump - Low coolant level warning displayed within the DIP Or - Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113 or air in the coolant DTCs (various) is evident in this scenario the operative should refer to TPI 2051893.

2071239/1

Service Bulletin/Repair Instructions

Coolant pump leaking (part number 07P 121 008C) - Low coolant warning - Engine overheating - DTC's evident. Customer statement / workshop findings One or a combination of the following is evident: - Coolant leaking from the mechanical coolant pump - Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump - Low coolant level warning displayed within the DIP Or - Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113 or air in the coolant DTCs (various) is evident, in this scenario the operative should also refer to TPI 2051893

2069551/2

Service Bulletin/Repair Instructions

Touch Screen Remote (TSR) has no visible display or does not function. Customer statement / workshop findings: The Touch Screen Remote (TSR) has no visible display or does not function, see the example shown in Figure 1. Technical background In the event that one or a combination of the described symptoms is evident, please follow the instructions within the Measure section depending on the symptom.

2071166/1

Service Bulletin/Repair Instructions

DTC C10BCF6 and/or DTC C12E2F2 stored in address 0003 - Parking brake warning in DIP. Customer statement / workshop findings: Parking brake warning light evident within the DIP (See example shown in Figure 1). Measure: Raise a technical DISS query ensuring a current ODIS log is attached

2069806/3

Service Bulletin/Repair Instructions

2060223/6

Service Bulletin/Repair Instructions

During PDI - Steering wheel vibration and/or steering wheel is out of alignment. Customer statement / workshop findings: VERY IMPORTANT: This TPI is only applicable to vehicles which have one or a combination of the following issues evident during the Pre Delivery Inspection (PDI) - Vehicle is pulling to the left or right And/or - Steering wheel vibration and/or - Other steering geometry/alignment concerns. Technical background: Should one or a combination of the afore mentioned symptoms be evident, please refer to the instructions within the Measure section ensuring all steps are conducted.

2068455/2

Service Bulletin/Repair Instructions

Grease evident at the front lower ball joint bellows. Customer statement / workshop findings: Grease evident on or around the front axle lower ball joint bellows In the event the symptom is as described, the operative should carry out the instructions within the Measure section Technical background: During service work and/or other repairs, a loss of grease can be detected from the front axle lower ball joint on one or both lower ball joint bellows. Measure: Findings performed on supposedly damaged components have shown that they were of good quality, no damage was found to the ball joint bellows which could of resulted in the leak Grease may leak during the initial assembly of the front lower levers. This due to a maximum deflection of the conical spigot before the lower lever is assembled into the wheel carrier. Over the service life, additional foreign bodies can collect in the corresponding area and stick to the excess grease, which can then be distributed over a larger area If there is no customer complaint about noises (rattling, pinching, creaking) from the area of the front axle and the lower levers have clearance, the operative must remove any excess grease and check the ball joint and bellows for damage If the ball joint/bellows is not damaged, the lower lever does not need to be replaced The level of grease on or around the lower ball joint boot/wheel bearing housing (Figures 1,2 and 3) is deemed as a normal characteristic.

2069806/2

Service Bulletin/Repair Instructions

HVAC refrigerant leakage suspected Or reports of a damp/musty smell within the cabin - Diagnosis guidelines. Customer statement / workshop findings: HVAC not cooling / HVAC cooling less than expected / HVAC refrigerant leakage confirmed Or The customer reports a damp/musty smell within the cabin Note: For this scenario please see the pre requisites below - Should no HVAC leak be evident and a damp/musty smell has been reported/identified the operative should first confirm that water is not leaking into the cabin please refer to all VIN applicable TPIs particularly TPI 2062622/- - Should there be no water leaks evident, the operative should check the HVAC and body drains for blockages, in the event the drains are blocked the drains must be unblocked, once this has been completed the operative should confirm if the damp/musty smell is still evident. In the event that HVAC cleaning products are required, these MUST be sourced locally. Before using the cleaner the operative must inform the customer of the product which will be used, a neutral fragrance cleaner should be used as the customer may not like the smell of the cleaner should a fragranced product be used Please ensure all supporting information is included within the DISS query when requesting permission to clean the HVAC system including clear photographs and/or videos showing the reported issue, should the required information not be supplied the warranty claim could be cancelled.

2070344/1

Service Bulletin/Repair Instructions

Headlamp control unit replacement - Bentayga and New Flying Spur. Customer statement: Headlamp is not working or the headlamp is flickering Workshop findings Headlamp assembly diagnosed as faulty. Technical background: It is not possible to determine between internal lamp defects and control unit failures therefore this TPI is to advise the replacement of the control unit in the first instance The complete headlamp assembly should only be replaced if control unit replacement was not successful.

2071131/1

Service Bulletin/Repair Instructions

Measured values - Cycle recording instructions. Customer statement / workshop findings: In some cases Measured value traces may be requested in XML format for analysis by Product Support Technical background: The instructions within the Measure section of this TPI have been generated to guide operatives through the process for recording Measured values in cycles by using self diagnosis, the Instructions also detail how to locate corresponding files which are required for analysis Product Support will advise regarding the Measured values and cycle time required.

2071006/1

Service Bulletin/Repair Instructions

Rear seatbelt - Incorrect buckle status within the DIP - New Continental GT/C and New Flying Spur. Customer statement: Incorrect rear seatbelt buckle status shown within the DIP Workshop findings Although there is no occupant evident within the rear seats (2nd row) the rear seat is shown as occupied (Figure 1). Technical background: There is no specific DTC evident for the scenario described. The issue described is evident as the rear seat belt buckles are not resistor coded The system uses a non-resistor coded buckle strategy (zero-infinity or open-closed buckle) for the rear seats. In correct operation, a fastened seatbelt is open circuit and an un-fastened seatbelt is closed circuit If harness damage is present or an electrical connector joint is not properly engaged, an unintended open circuit occurs. This will give an incorrect buckle status reading within the DIP The advice within this TPI should be referred to first before conducting any further diagnosis or disassembly of the vehicles interior Previous assembly/disassembly may have caused an unintentional open circuit when operatives have been working on or around the rear seat belt assemblies.

2068946/3

Service Bulletin/Repair Instructions

Bentley dynamic ride system warning displayed - DTC P0B2500: Hybrid/EV Battery "A" Voltage low' stored (48 volt system). Customer statement: Bentley dynamic ride system: fault displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500: Hybrid/EV Battery "A" Voltage low' stored within address 21-Battery Energy Control Module 2 Technical background: Possible internal fault with super capacitor - In the event that DTC P0B2500 is evident the operative must follow the steps within the Measure section to completion

2051045/8

Service Bulletin/Repair Instructions

Night vision camera washer jet nozzle leaking. Customer statement / workshop findings: Washer fluid dripping/leaking from the night vision camera jet nozzle. Technical background: Please note: The photographs shown within this TPI are not based on a specific vehicle type, the procedure to replace the night vision non return valve is the same regardless of vehicle type In the event the afore mentioned symptom is evident the operative should refer to the Measure section of this TPI to replace the non return valve.

2051187/9

Service Bulletin/Repair Instructions

Poor Engine Running Complaints (Misfires) Petrol Engines Only. Customer statement / workshop findings: - Poor engine running - Reduced power - Engine warning lamp illuminated - Symptom related DTCs evident within the applicable engine control unit(s) Technical background: Technical Product Information (TPI) to assist retailers when diagnosing poor engine running or misfires.

2070682/1

Service Bulletin/Repair Instructions

Loud ticking/clatter noise from the air conditioning compressor (HVAC). Customer statement Loud ticking/clatter noise can be heard from the front of the engine Workshop findings The noise is from the air conditioning compressor Technical background The operative should confirm the noise is from the compressor as detailed within the Measure section.

2070768/1

Service Bulletin/Repair Instructions

New Continental GT/C & New Flying Spur - Air suspension warning light in the DIP. Customer statement: Air suspension warning light within the DIP Workshop findings: Various suspension DTCs are evident within address 74 relating to the following: - Level control valve mechanical malfunction Or - Solenoid for the level control system (Open circuit). Technical background: NOTE: An electrical integrity check must be conducted before replacing any parts The solenoid valve block and/or control unit must be replaced first (symptom dependent) before replacing the air supply unit, in the event the issue is still evident and the air supply unit assembly is suspected as being at fault, the operative must request permission via DISS before replacing the air supply control unit assembly.

2063729/3

Service Bulletin/Repair Instructions

Fitment of control modules from donor vehicles for test purposes. Technical background: If an issue is suspected for one of the control modules listed below: - Onboard supply control unit (J519) - Convenience system central control unit (J393) - Data bus diagnostics interface (J533) - Control unit 1 for Information Electronics (J794) - Control unit in dash panel insert (J285) - Emergency call module control unit (J949) The fitment of donor parts from another vehicle is not advisable and only possible if approved from Product Support via an open DISS query. The donor of parts should only be used as a temporary test VERY IMPORTANT: The ODIS replace routine MUST NOT be carried out under any circumstances.

2070638/1

Service Bulletin/Repair Instructions

Water ingress into the front cabin footwell/bulkhead - Glass misting on the inside - Front carpets/mats wet. Customer statement: - Water ingress into the left and/or right hand foot well - Front carpets and/or foot mats are wet - The windows are misty due to water ingress Workshop findings - After conducting TPI 2062622/- water ingress was found at the location shown in Figure1 (Left hand A - Pillar seam). The cause of the ingress can be caused by missing sealant on the A - post pillar seam.

2070030.1

Service Bulletin/Repair Instructions

Knocking noise from rear the rear air springs - Up to approximately 30 kmh/18mph Customer Statement: -During light acceleration up to 30kmh/18mph a noise may be heard from the rear air springs

2055254.4

Service Bulletin/Repair Instructions

Top view/Rear view camera - guidelines not visible Customer Statement: -Guidelines not showing on display screen when reverse gear selected.

2070675.1

Service Bulletin/Repair Instructions

DTC's stored for the 3rd row rear seat belts although the vehicle does not have a 3rd row Customer Statement: -One or a combination of the following DTCÃ¢ÂÂs are evident within the airbag control unit J234

2062095.3

Service Bulletin/Repair Instructions

DTC's B14BF01 and /or B14A854 evident in address 0009 - Steering column will not adjust Customer Statement: -Steering column will not adjust in any direction

2070519.1

Service Bulletin/Repair Instructions

Window lift switch is loose within the switch carrier and/or a rattle noise can be heard from the switch Customer Statement: -Window lift switch is loose within the door aperture -Or The window lift switch rattles when the door is closed

2051937.8

Service Bulletin/Repair Instructions

Front centre console lid (cup holder assembly) fails to latch/unlatch -Technical Background: -Application of grease to both of the centre console storage box frame ribs (Figure 1) as described within the Measure section is required

2060446.7

Service Bulletin/Repair Instructions

Clicking noise from the front wheels when conducting a static lock to lock steering manoeuvre -Technical Background: -Verify the customer complaint matches the video within the Bentley Hub - Reference TPI Transaction number 2060446/-

2065919.8

Service Bulletin/Repair Instructions

Coolant leaking from the mechanical coolant pump - Low coolant level warning - Engine overheating - DTC's evident Customer Statement: -Coolant leaking from the mechanical coolant pump -Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed within the DIP -Engine overheating issues and/or DTC P218100: Cooling System Performance with symptom code 8113

2070531.1

Service Bulletin/Repair Instructions

Bring Your Own Content - Over The Air (OTA) Update to software version R11.2.6 Customer Statement: -An Over The Air Update (OTA) could be required for both of the Bring Your Own Content (BYOC) screens

2068946/2

Service Bulletin/Repair Instructions

Bentley dynamic ride system warning displayed - DTC P0B2500: Hybrid/EV Battery "A" Voltage low' stored (48 volt system). Customer statement / workshop findings: Bentley dynamic ride system: fault displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500: Hybrid/EV Battery "A" Voltage low' stored within address 21-Battery Energy Control Module 2 Technical background: Possible internal fault with super capacitor, refer to the Measure section of this TPI

2060432/6

Service Bulletin/Repair Instructions

New Continental GT / GTC and New Flying Spur - Exhaust Flap - Diagnostic Trouble Code. Customer statement / workshop findings: Warning lamp illuminated within the Driver Instrument Panel (DIP) -Drive system fault. Contact your Bentley dealer- Technical background: The root cause of Exhaust Flap Control Unit malfunction is electrical shorting of the commutator segments, this is caused by an accumulation of Sludge within the exhaust flap control unit DTCs are stored when the respective Control Unit does not move through its full range of motion.

2069484/3

Service Bulletin/Repair Instructions

Exhaust Flap - DTCs evident - P048D - P048B - P04A8 - P04A0 evident - V8 Kovomo. Customer statement - Engine warning lamp is illuminated within the Driver Instrument Panel (DIP) Workshop findings One or more of the following Diagnostic Trouble Codes (DTCs) are stored within Engine Control Module

2051937.7

Service Bulletin/Repair Instructions

Front Centre Console Lid (Cup Holder Assembly) Fails To Latch Technical Background: -Replacement of the lid mechanism pawl is required

2053492.10

Service Bulletin/Repair Instructions

Air Spring Fault Finding Guidelines Customer Statement: -The front and/or rear suspension appears to have dropped

2063855.8

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - Evident Within Address 0019 and/or DTC U112300 Evident in 00A5 Customer Statement: -Lane Assist and/or Traffic Assist Are Not Functional

2069611.2

Service Bulletin/Repair Instructions

Flying B Mascot Clear Wings Replacement Procedure Customer Statement: -One or both of the flying B mascot clear wings are missing

2063954.4

Service Bulletin/Repair Instructions

Engine Warning Light Illuminated Within The DIP During Acceleration - DTC P029900 Evident - W12 TSI Only Customer Statement: -Engine warning light and (max engine speed 4000 rpm) warning evident within the DIP during acceleration - Warning on DIP first appears when accelerating (during boost)

2069611.1

Service Bulletin/Repair Instructions

Flying B Mascot Clear Wings Replacement Procedure Customer Statement: -One or both of the Flying B mascot clear wings are missing

2060205.6

Service Bulletin/Repair Instructions

Engine Colling System Over Cooling - DTC P218100 - V8 Kovomo Customer Statement: -Emission Control lamp illuminated on the Driver Instrument Panel -The time to reach the correct engine coolant operating temperature has increased

2060205.5

Service Bulletin/Repair Instructions

Engine Colling System Over Cooling - DTC P218100 - V8 Kovomo Customer Statement: -Emission Control Lamp illuminated on the Driver Instrument Panel -The time to reach the correct engine coolant operating temperature has increased

2069806.1

Service Bulletin/Repair Instructions

HVAC Refrigerent Leakage - Diagnosis Guidelines Customer Statement: -HVAC not cooling or HVAC cooling less than expected

2064582.5

Service Bulletin/Repair Instructions

Vehicle Sitting Low or High On One or More Corners when Static With No Relevant DTCs stored Customer Statement: -Vehicle sitting low on one or more corners when static -No relevant DTCs are evident

2070041.1

Service Bulletin/Repair Instructions

Coolant Warning Lamp within the DIP - One or a combination of DTCs is evident P218100 - P017B00 - P017C00 - P017E00 Customer Statement: -Customer reports a red engine coolant overheat warning within the DIP

2069912.1

Service Bulletin/Repair Instructions

My Bentley Connected APP - Pairing Code Is Not Functional Customer Statement: - The My Bentley connected in car services personalisation feature does no longer function. The in car services personalisation function can be found by navigating through the screen menu.

2067955.2

Service Bulletin/Repair Instructions

Rotating display/screen - Fault diagnosis - Mechanical Malfunction DTC B140107 is evident within 005F Customer Statement: -Bentley rotational display (BRD) operational issues -Mechanical malfunction DTC B140107 evident within 005F

2069484.2

Service Bulletin/Repair Instructions

Exhaust Flap DTCs Evident - P048D - P048B - P04A8 - P04A0 - V8 Kovomo Customer Statement: -Engine warning lamp is illuminated within the Driver Instrument Panel (DIP)

2069824.2

Service Bulletin/Repair Instructions

Exhaust Flap Control unit - Left and Right hand - Serial number check (SC23/09) - The exhaust flap control unit 2 -J945- is located on the LEFT hand exhaust silencer tail pipe - The exhaust flap control unit -J883- is located on the RIGHT hand exhaust silencer tail pipe The left and right hand exhaust control units must be removed from the rear silencers to allow the serial numbers of each control unit to be identified Once identified the serial numbers must be cross referenced with the attached spreadsheet to confirm if the control units require replacement or not

2069910.1

Service Bulletin/Repair Instructions

Squeaking Noise From The Lower Steering Column Customer Statement: -When turning the wheel from left to right a squeaking noise from the bulkhead steering shaft seal is evident

2066480.5

Service Bulletin/Repair Instructions

Headlamp Switch Not Working/Not Illuminated - Numerous DTCs within 0009- Central Electrics (BCM1) Customer Statement: -Headlamp switch not working/not illuminated when the ignition is switched on (following and ignition switch off) and/or -Yellow warning light/message within DIP (Adaptive Lighting Fault) and/or -Loss of rear fog light activation and/or -Loss of all-weather lighting mode activation and/or -Headlamps will default to dipped beam

2061743.4

Service Bulletin/Repair Instructions

Rear Shock Absorber Leaking (Left or Right) Customer Statement: -Oil leak evident from the rear shock absorbers (Left and/or Right)

2065919.7

Service Bulletin/Repair Instructions

Coolant Leaking From The Mechanical Coolant Pump -Low Coolant Level Warning - Engine Overheating - DTCs Evident Customer Statement: -Coolant leaking from the mechanical coolant pump -Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed within the DIP -Engine overheating issues and.or DTC 0218100: Cooling System Performance with symptom code 8113

2069824.1

Service Bulletin/Repair Instructions

Exhaust Flap Control Unit - Left and Right Hand - Serial Number Check (SC23/09) -The exhaust flap control unit 2 -J945- is located on the LEFT hand exhaust silencer tail pipe -The exhaust flap control unit -J883- is located on the RIGHT hand exhaust silencer tail pipe

2053492.9

Service Bulletin/Repair Instructions

Air Spring Fault Finding Customer Statement: -The front and/or rear suspension appears to have dropped.

2069551.1

Service Bulletin/Repair Instructions

Touch Screen Remote (TSR) is Not Operating (No Display or Functionality) Customer Statement: -Referring to Figure 1 - The Touch Screen Remote (TSR) is not operating (No Display or Functionality)

2051045.7

Service Bulletin/Repair Instructions

Night vision camera - Washer jet leaking. Customer statement / workshop findings: Washer fluid dripping/leaking from the night vision camera washer jet Technical background: Please note: The photographs shown within this TPI are based on a New Continental GT/C vehicle however the process is similar regardless of vehicle type Referring to Figure 1 - In the event the afore mentioned symptom is evident the operative should refer to the Measure section of this TPI to replace the night vision washer jet (short link hose -Circled) which connects the night vision camera washer jet (A) to the washer jet supply hose connector (B) Figure 1

2069484.1

Service Bulletin/Repair Instructions

Exhaust Flap - DTCs evident - P048D - P048B - P04A8 - P04A0 evident - V8 Kovomo. Customer statement: - Engine warning lamp illuminated within the Driver Instrument Panel (DIP) Workshop findings One or more of the following Diagnostic Trouble Codes (DTCs) are stored within Engine Control Module

2063855.6

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - evident within address 0019 and/or DTC U112300 evident in 00A5 Customer Statement: -Lane Assist and/or Traffic Assist are not functional.

2067403.4

Service Bulletin/Repair Instructions

Knocking Noise From The Front (Driving over an uneven surface) - Front Trailing Arm Hydraulic Mount Damaged/Leaking Customer Statement: -Knocking noise from the underside of the vehicle (front) when driving on uneven road surfaces.

2066480/4

Service Bulletin/Repair Instructions

Headlamp Switch Not Working/Illuminated - Numerous DTCs Within 0009 - Central Electrics (BCM1) Customer Statement: -Headlamp switch not working/not illuminated when the ignition is switched on (following an ignition switch off) and/or -Yellow warning light/message within DIP (Adaptive lighting fault) and/or -Loss of rear fog light activation and/or -Loss of all-weather lightin mode activation and/or -Headlamps will default to dipped beam (however, high beam activation will still be possible manually

2069414.1

Service Bulletin/Repair Instructions

Rear Seat Entertainment - Crosslink Feature Unavailable Customer Statement: -The (crosslink) function and icon within the Rear Seat Entertainment screens (RSE) is no longer available.

2051511.9

Service Bulletin/Repair Instructions

Mood Lighting Operational Issues Customer Statement: -One or a combination of the following is evident: -Mood lighting strip is faulty/incorrect illumination due to the strip being cracked and/or irregularities in the strip -Mood lighting strip has incorrect color synchronization and/or sticks to one color -Mood lighting strip has partial illumination and does not light at all

2069267.1

Service Bulletin/Repair Instructions

Bring Your Own Content (BYOC) tablet does not electrically connect and/or loose and/or out of position Customer Statement: -One or a combination of the following are evident with the Bring Your Own Content Table (BYOC) -The tablet will not electrically connect or operate -The tablet will connect and operate

2067403.3

Service Bulletin/Repair Instructions

Knocking Noise From The Front (Driving over an uneven road surface) - Front Trailing Arm Hydraulic Mount Damaged/Leaking Customer Statement: -Knocking noise from the underside of the vehicle (front) when driving on uneven road surfaces

2065919.6

Service Bulletin/Repair Instructions

Coolant leaking from the mechanical coolant pump - Low coolant level warning - Engine overheating - DTC(s) evident Customer Statement: -Coolant leaking from the mechanical coolant pump -Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed within the DIP -Engine overheating issues and/or DTC P218100: Cooling system performance with symptom code 8113

2069201.1

Service Bulletin/Repair Instructions

New Continental GT/C and New Flying Spur W12 - Primary Catalyic Converter Replacement - Warranty Time Confirmation Workshop Findings: -The following DTC are evident: -P042000: Catalyst System, Bank1 Efficiency Below Threshold -P043000: Catalyst System, Bank2 Efficiency Below Threshold

2069252.1

Service Bulletin/Repair Instructions

Warnings Within the DIP for the Rear Steering System - DTC B200096 and/or P060700 Evident Within Diagnostic Address 00CB Customer Statement: -Rear steering fault warning present within the DIP

2061369.5

Service Bulletin/Repair Instructions

Engine Overheating - Warning on the DIP - V8 Kovomo Customer Statement: -Customer reports an engine overheat warning within the DIP -Engine overheating -Unusual cooling fan operation at high temperatures -There are no obvious signs of coolant leaks both internally or externally Workshop Findings: -P19F700: Low engine coolant temperature indicator lamp coolant too warm -Signs of coolant in the vacuum hoses

2036678.5

Service Bulletin/Repair Instructions

Speaker Replacement - Diagnostic Checks Technical Background: -There have been instances where door speakers have been changed under warranty for the complaint of sound distortion, yet when tested by ourselves and the supplier, no fault could be found with the returned unit.

2060432.5

Service Bulletin/Repair Instructions

New Continental GT/GTC and New Flying Spur - Exhaust Flap - Diagnostic Trouble Code Customer Statement: -Warning lamp illuminated within the Driver Instrument Panel (DIP) -"Drive System Fault. Contact your Bentley Dealer"

2062622.2

Service Bulletin/Repair Instructions

Water Leak/Wind Noise Diagnosis Customer Statement: -Water leak/wind noise evident -The instructions within this TPI should be followed to assist in the diagnosis of water leaks or wind noise.

2051893.4

Service Bulletin/Repair Instructions

Overheat Condition - DTC logged for air in the system or DTC P218100 - Cooling System Performance with Symptom code 8113 Customer Statement: -Engine coolant overheat condition

2053348.10

Service Bulletin/Repair Instructions

W12 Engine Management Light On- Turbocharger Speed Sensor DTCs Stored Workshop Findings: -One or a combination of the following DTCs may be evident (with no specific symptom codes) -P259500: Turbocharger Speed Sensor (B) - Circuit low -P259600: Turbocharger Speed Sensor (B) - Circuit high -P257900: Turbocharger Speed Sensor (A) - Circuit range/performance

2060205.4

Service Bulletin/Repair Instructions

Engine Cooling System Over Cooling - DTC P218100 - V8 Kovomo Customer Statement: -Emission control lamp illuminated on the Driver Instrument Panel (DIP) -The time to reach the correct engine coolant operating temperature has increased

2061369.4

Service Bulletin/Repair Instructions

Engine Overheating - Warning on the DIP - V8 Kovomo Customer Statement: -Customer reports an engine overheat warning within the DIP -Engine overheating -Unusual cooling farm operation at high temperatures -There are no obvious signs of coolant leaks both internally and externally

2063855.5

Service Bulletin/Repair Instructions

DTC B17B801 and/or B17B804 - Evident within address 0019 and/or DTC U112300 evident in 00A5 Customer Statement: -Lane Assist and/or Traffic Assist are not functional

2064679.4

Service Bulletin/Repair Instructions

Oil Leaking from Tell Tale Hole - CDA Actuator Fixings or Fuel Rail Fixings or Vacuum Assembly Fixings - V8 Kovomo Customer Statement: -CDA activation/deactivation solenoid fixings -Fuel rail fixings

2065919.5

Service Bulletin/Repair Instructions

Coolant Leaking from the Mechanical Coolant Pump - Low Coolant Level Warning - Engine Overheating - DTC's Evident Customer Statement: -Coolant leaking from the mechanical coolant pump -Coolant witness marks on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed within the DIP -Engine Overheating issues and/or DTC P218100: Cooling System Performance with Symptom Code 8113

2067418.2

Service Bulletin/Repair Instructions

Bentley Brand Name Lettering is no Longer Applied to the Rear Callipers (vehicles specified with iron brakes) Customer Statement: -The rear brake callipers do not have the brand name lettering (Bentley) applied to the rear brake callipers however -The front brake callipers do have the brand name lettering (Bentley) applied to the front brake callipers

2068320.3

Service Bulletin/Repair Instructions

Driver/Passenger Door Creak on Close - 22 Model Year Onwards Customer Statement: -Driver and/or passenger door creak during the (Power Close) function

2068455.1

Service Bulletin/Repair Instructions

Grease Evident at the Front Lower Ball Joint Bellows Technical Background: -During service work and/or other repairs, a loss of grease can be detected from the front axle lower ball joint on one or both lower ball join bellows

2068609.1

Service Bulletin/Repair Instructions

Rear Lamp Gap/Profile and Alignment Customer Statement: -Rear lamp gap/profile appears to be out of specification Technical Background: -Due to the design and fitment of the rear lights in relation to the surrounding components the operative must refer to the applicable Rep. Gr to confirm if the gap/profile of the rear lamps is to specification before conducting any adjustments or before raising a technical DISS query.

2068609.2

Service Bulletin/Repair Instructions

Rear Lamp Gap/Profile and Alignment Customer Statement: -Rear lamp gap/profile appears to be out of specification -Raise a technical DISS query

2068648.1

Service Bulletin/Repair Instructions

Front Seatbelt - DTCs - B130474 and/or B130574 Customer Statement: -Diagnostic Trouble Codes (DTCs) evident in Address: 0015 System name: 15 - Airbag Control Module -B130474: Left front seat belt tensioner control module actuator deviated -B130574: Right front seat belt tensioner control module actuator deviated -The DTCs can be evident if the occupant uses a dummy seat belt buckle, the occupant may use the dummy seat belt buckle to prevent a warning light or audible warnings

2068767.1

Service Bulletin/Repair Instructions

Upper Engine Mount Fixings - Incorrect Torque May Have Been Applied During Manufacture (SC 22/37) Technical Background: -Upper engine mount fixings must be replaced as detailed within the work section

2068946.1

Service Bulletin/Repair Instructions

Bentley Dynamic Ride System Warning Deployed - DTC P0B2500: Hybrid/EV Battery (A) Voltage Low Stored Customer Statement: -Bentley Dynamic Ride System: fault displayed within the Drivers Instrument Panel (DIP) Technical Background: -Possible internal fault with super capacitor. refer to the measure section of this TPI

2068364.1

Service Bulletin/Repair Instructions

New Flying Spur Hybrid- engine control module update - generic scan tool communication error (SC22/34) Technical Background: -A software update to the engine control module is required.

2060223.5

Service Bulletin/Repair Instructions

During PDI - Steering wheel vibration and/or steering wheel out of alignment is evident Customer Statement: -Vehicle is pulling to the left or right -Steering wheel vibration -General vehicle geometry concerns

2065698.2

Service Bulletin/Repair Instructions

V8 Kovomo - Emission Control Warning Illuminated within the DIP - Exhaust Gas Temperature Sensor DTCs evident Workshop Findings: -U061F00: Lost communication with exhaust gas temperature sensor bank 1 sensor 1 -U062100: Lost communication with exhaust gas temperature sensor bank 1 sensor 1

2049586.11

Service Bulletin/Repair Instructions

Misfiring, W12 TSI - Excessive carbon build up cylinder leakage Customer Statement: -Emission control warning signal displayed, engine misfire Workshop Findings: -Event entries in engine control unit relating to cylinder misfires- excessive carbon build up to leading to cylinder leakage and spark plug foul

2051219.9

Service Bulletin/Repair Instructions

W12 TSI Camshaft Phaser Position Related DTC Customer Statement: -Customer reporting (Emission Control Warning Indicator) displayed. Engine running rough.

2053348.9

Service Bulletin/Repair Instructions

W12 Engine Management Light On - Turbocharger speed sensor DTCs stored Customer Statement: -Engine management light is evident within the DIP

2053350.4

Service Bulletin/Repair Instructions

W12 - Oil leak from engine Technical background: -The breather return line and the oil dipstick tube O- rings can split causing an external oil leak. -This can be diagnosed as the engine sump leaking

2062016.4

Service Bulletin/Repair Instructions

DTCs P014800 and/or P008A00 - Rough Running and Potentially Poor Start Up Performance - MIL Light on -Possible Misfires Customer Statement: -The engine management light is on -Rough running and potentially poor start up performance and/or -Engine misfires

2028808.6

Service Bulletin/Repair Instructions

All 12MY Engine Oil- Service Info: Engine Oil - Specific oil type and oil consumption reference, Technical Background: -The use of the correct oil for each engine type is critical for its continued performance, reliability and ultimately warranty. -The workshop manual should always be the first point of reference, ensuring the correct lubricant is used for each specific model year and engine type -Should oil be required the parts catalogue must be referred to ensuring the correct VIN is always used when ordering.

2050542.6

Service Bulletin/Repair Instructions

Body/Equipment: Front exterior lighting steamed up/leaks Customer Statement: -The lenses of the headlights/front fog lamps are steamed up/damp from the inside with minor drips

2051187.8

Service Bulletin/Repair Instructions

Poor Engine Running Complaints (Misfires) Petrol Engines Only Customer Statement: -Poor engine running, reduced power, engine warning lamp illuminated.

2052431.8

Service Bulletin/Repair Instructions

New Continental GT and GTC - Rattle/Buzzing Noise - Head-Up Display Technical Background: -Several known conditions may cause rattle/buzzing noise from dashboard upper trim panels -Relative movement between control unit for Head-Up Display and associated trimring -Contact between the dashboard and the dashboard upper trim panel -Head-up display internal fault

2053177.18

Service Bulletin/Repair Instructions

All Vehicle Variants - Spurious DTC List Customer Statement: -Customers will not be aware of any fault codes -Workshop may discover spurious fault codes whilst running a Diagnostic Trouble Code (DTC) log as part of other investigations on the vehicle.

2058354.5

Service Bulletin/Repair Instructions

New Flying Spur - Flying (B) Mascot Customer Statement: -The Technical Product Information (TPI) Document is designed to give repair guidance and standardized fault reporting for Flying (B) functionality, poor finish and damage concerns.

2058423.9

Service Bulletin/Repair Instructions

New Continental GT/GTC, New Flying Spur and Bentayga - Low Oil Pressure Warning During Early Vehicle Life - W12 Only Customer Statement: -Warning on the Driver Instrument Panel (DIP) - Oil pressure too low -DTCs relating to oil pressure may also be stored within the master ECU -Diagnostic Trouble Codes (DTC) P052400: Engine Oil Pressure Too Low and/or P15AA00: Engine oil pressure - Lower limit not reached stored in the Master Engine Control Unit (ECU)

2059068.5

Service Bulletin/Repair Instructions

Transmission Communication DTCs (Numerous) - W12 Engine Technical Background: -Loose pins within the transmission link harness to the Mechatronic unit for dual clutch gearbox - J743 - connections can lead to various transmission communication and hardware based DTCs

2060645.4

Service Bulletin/Repair Instructions

New Flying Spur -Boot Open/Close Function Inoperative Customer Statement: -The boot does not open or close as expected

2061195.2

Service Bulletin/Repair Instructions

Telephone Functionality Complaint- Minimum Standards Required For Analysis of Concerns Customer Statement: -The feedback method within this TPI is required should a complaint of telephone functionality and/or quality be reported.

2061288.5

Service Bulletin/Repair Instructions

Various and/or Numerous Transmission control module DTCs logged - V8 Kovomo Technical Background: -Loose pins within the transmission link harness to the mechatronic unit for dual clutch gearbox - J743 connections can lead to various and/or numerous transmission control module DTCs being logged

2063651.2

Service Bulletin/Repair Instructions

Tyre tread/sidewall crack(s) Customer Statement: -Cracks evident in the sidewall and/or tread pattern Technical Background: -The issue is mainly evident on vehicles with very low usage This is a result of the tyre compound hardening due to the following: -Tyre age -Tyre pressure not adjusted to specification -Low mileage/vehicle usage -Vehicle storage conditions

2065919.4

Service Bulletin/Repair Instructions

Water Leaking from the mechanical water pump- Low coolant level warning displayed - W12 TSI Customer Statement/Workshop Findings: -Coolant leaking from the mechanical coolant pump -Coolant witness mark on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed

2066480.3

Service Bulletin/Repair Instructions

Headlamp Switch not working/illuminated - Numerous DTCs within 0009 - Central Electrics (BCM1) Customer Statement: -Headlamp switch not working/not illuminated when the ignition is switched on (following an ignition switch off) and/or -Yellow warning light/message within DIP (Adaptive lighting fault) and/or -Loss of rear fog light activation and/or -Loss of all-weather lighting mode activation and/or -Headlamps will default to dipped beam (however, high beam activation will still be possible manually)

2066669.2

Service Bulletin/Repair Instructions

Engine Coolant - Overheat Condition- Warning Evident within the DIP - DTCs P2B6500 and P2B8600 are evident Customer Statement: -Engine cooling system overheating and/or -Coolant loss and/or -Warning light in Driver Information Panel(DIP)

2068273.2

Service Bulletin/Repair Instructions

Multiple Random Misfires Evident During PDI Customer Statement: -Multiple random cylinder misfire DTCs detected during PDI -DTC P030000: Random/Multiple Cylinder Misfire Detected (misfires on multiple cylinders) within the following control units: -V8-ECM1 - V8 (Address 01) ECM control unit -W12 - ECM1 - (Address 01) and/or ECM 2 (Address 11)

2059333.4

Service Bulletin/Repair Instructions

Unable to open, or delay in opening the Drivers or Front passenger door from outside using the door handle (keyless) Technical Background: -In the event there is a customer complaint regarding the opening of the door from the outside of the vehicle when using the door handle (keyless entry) please refer to the measure section of this TPI

2060432.4

Service Bulletin/Repair Instructions

New Continental GT/GTC and New Flying Spur - Exhaust Flap - Diagnostic Trouble Code Customer Statement: -Warning lamp illuminated on Driver Instrument Panel (DIP) -(Drive system fault. Contact your Bentley Dealer) displayed on DIP

2060446.6

Service Bulletin/Repair Instructions

Clicking noise from the front wheels when conduction a static lock to lock steering maneuver

2061064.2

Service Bulletin/Repair Instructions

Secondary Air Injection - Missing ODIS data Technical Background: -Data is only available for four of the eight secondary air monitors on each cylinder bank therefore some test plans and related tasks are not currently available.

2061171.8

Service Bulletin/Repair Instructions

New Continental GT/GTC and New Flying Spur - V8 Kovomo - Fuel Pressure Regulation - Numerous DTCs Customer Statement: -Check engine lamp illuminated within the Driver Instrument Panel (DIP) with one of multiple DTCs as detailed below: -P310B00 Low Fuel Pressure Regulation with symptom code 2636 -P014800 Fuel Deliver Error -P0191100 Fuel Rail Pressure Sensor A Circuit Range/Performance -P018B00 Fuel Pressure Sensor B Circuit Range/Performance with symptom code 17871 -Misfire DTCs

2061362.3

Service Bulletin/Repair Instructions

Engine intermittently fails to start/Kombi pop up (Engine Start System:fault) Customer Statement: -Customer unable to intermittently start the engine with the start button or -Engine starts but customer gets a pop up error on the kombi

2061536.6

Service Bulletin/Repair Instructions

Infotainment screen stalls at initializing Customer Statement: -Upon start-up of the infotainment system, the home screen appears to be stuck in the (initializing) stage, when this scenario is evident a spinning wheel is visible

2061537.5

Service Bulletin/Repair Instructions

Infotainment home screen-Loading messages visible on start up in multiple tiles Customer Statement: -Upon start-up of the (home) screen, loading messages can be seen in some or all of the titles

2061857.5

Service Bulletin/Repair Instructions

Headlamp switch - Inoperative/Not illuminated - DTC U110B00 within 09-Central Electrics (BCM1) Customer Statement: -Headlamp switch -Inoperative/Not Illuminated Workshop findings: -DTC U110B00 within 09-Central Electrics (BCM1) as shown in figure 1

2062184.7

Service Bulletin/Repair Instructions

Electronic Parking Brake (EPB) functionality issues Customer Statement: -The following issues could be evident during PDI or found whilst in service -Electronic Parking Brake (EPB) found not operating to specification -EPB may not hold the car effectively -Parking brake components showing signs of wear -Parking brake warning light may also be evident within the DIP

2062257.4

Service Bulletin/Repair Instructions

Keyless door entry does not work- Front outside door handles - touch sensor DTC B147613 present Customer statement: -Keyless door entry does not work

2063029.3

Service Bulletin/Repair Instructions

EPB Fault Warning within the DIP - DTCs stored in address 03 - C100C01 and C1246F9 Customer Statement: -Electro-mechanical parking brake button electrical error and/or -Electro-mechanical parking brake button interruption

2064477.4

Service Bulletin/Repair Instructions

Knock/Clunk noise from the rear of the vehicle (Rear axle) Customer Statement: -Knock/clunking noise heard from the rear of the vehicle when changing direction at low speed

2064582.4

Service Bulletin/Repair Instructions

Vehicle sitting low on one or more corners when static with no relevant DTCs stored. Technical background: -Additional steps added within the Measure section relating to air spring damper checks

2064679.2

Service Bulletin/Repair Instructions

Oil leaking from the tell tale hole - CDA actuator fixings or Fuel rail fixings or vacuum assembly fixings - V8 Kovomo

2064776.4

Service Bulletin/Repair Instructions

V8 Kovomo- Engine Misfires- Engine Management Light Illuminated within the DIP Customer Statement: -Engine misfiring -Engine running rough (not refined) -Engine misfire DTCs evident -Engine management light illuminated within the DIP -Knocking noise from the cylinder head

2064791.2

Service Bulletin/Repair Instructions

Knocking noise from the front and/or rear (driving over an uneven road surface) Technical Background: -The noise present in the sound file can be caused by worn anti-roll bar bushes, the noise can appear when driving over a uneven road surface or during a large suspension input for example: speed humps or potholes

2065085.2

Service Bulletin/Repair Instructions

Knocking noise from the front and/or rear - DTC C1298F1 evident within D4 and/or D5 Customer Statement: -Knocking noise from the underside of the vehicle (front and/or rear) when driving on uneven road surfaces -DTC C1298F1 (Suspension stabilization actuator regulation not possible) evident within diagnostic address D4 and/or D5 -Bentley dynamic ride fault evident within the DIP

2065498.2

Service Bulletin/Repair Instructions

Rear Seat Entertainment - Unavailable Features Customer Statement: -The (crosslink) and (audio to car) functions of the Rear Seat Entertainment screens are not working to specification (icons greyed out) a message is also displayed advising the feature(s) are not available when the icons are pressed.

2065922.2

Service Bulletin/Repair Instructions

Bentley Dynamic Ride System Warning Displayed - DTC P0B2600 with symptom code 28672 Customer Statement: -Bentley Dynamic Ride system fault warning displayed within the DIP

2066852.3

Service Bulletin/Repair Instructions

Shaker Speaker - Diagnostic Checks Technical Background: -There have been instances where shaker speakers have been changed under warranty for the complaint of sound distortion, yet when tested by Bentley motors and the supplier, no fault could be found with the returned unit.

2067403.2

Service Bulletin/Repair Instructions

Knocking noise from the front (Driving over an uneven road surface) Front trailing arm bush found damaged/leaking Workshop Findings: -Front trailing arm bush found damaged/leaking as shown in figures 1 and 2

2067483.3

Service Bulletin/Repair Instructions

(Drive System Fault) warning present within the DIP - Under full throttle conditions Workshop Findings: -If the symptom present is evident during vehicle start up or similar conditions please refer to TPI 2061171.

2067579.2

Service Bulletin/Repair Instructions

Repeated traction control interventions experience upon reaching 30km/h Technical Background: -In the event the issue is as exactly as described refer to the instructions within the measure section

2067831.2

Service Bulletin/Repair Instructions

Connected car user list - Error message shown within the MMI Customer Statement: -The user list is not populated when selected on the MMI, the following message is evident: (Connected Car User List Could Not Be Obtained Due to Communication Problem)

2051511.8

Service Bulletin/Repair Instructions

Mood Lighting Customer Statement: -Mood lighting strip fixed on one colour regardless of which colour scheme is selected or not illuminated at all.

2051519.11

Service Bulletin/Repair Instructions

HVAC Operation Issues/HVAC Motor defect DTCs logged Customer Statement: -HVAC operation issues and HVAC motor defect (DTCs) evident within address 08 - Climatronic control unit, the DTCs can be static or sporadic (intermittent)

2064648.2

Service Bulletin/Repair Instructions

ACC Unavailable- Traffic assist failure - Safeguard Failure- Radar Malfunction Warning DIP - Numerous DTCs within 0013 Customer Statement: -ACC failure -Traffic Assist Failure -Safeguard Failure -Radar Malfunction

2065895.2

Service Bulletin/Repair Instructions

Rotating display/screen noise - Diagnosis for complaints relating to noise during operation and/or dur a drive cycle. Customer Statement: -Various rotating display/screen noises during operation. Grinding, rattling, squeaking, creaking, and rattling.

2065896.2

Service Bulletin/Repair Instructions

Rotating screen alignment- Minimum standards could not be achieved. Customer Statement: -The chrome brightware strip on the (veneer face) fascia panel of the Bentley Rotating Display (BRD) may appear to be misaligned with the passenger and/or drivers side fascia panel chrome strips

2066236.2

Service Bulletin/Repair Instructions

Unintended sounding of the alarm siren - Following activation of the ignition or whilst the vehicle is left standing Customer Statement: -The following DTCs could also be evident within the diagnostic address 0046 and/or 00BB and/or 00BC -B131DF5: alarm system siren supply voltage lower limit value less than -B131D29: sirens/alarm horn for anti-theft warning system range/performance -B131D29: anti-theft alarm system siren/alarm horn signal, not valid

2067955.1

Service Bulletin/Repair Instructions

Rotating display/screen - fault diagnosis - mechanical malfunction DTC B140107 is evident within Customer Statement: -Bentley rotational display (BRD) operational issues -Mechanical malfunction DTC B140107 evident within 005F

2051046.6

Service Bulletin/Repair Instructions

Night vision camera- Washer Jet Leaking Customer Statement: -Washer fluid dripping/leaking from the night vision camera washer jet

2051776.4

Service Bulletin/Repair Instructions

New Continental GT - Key blade can be difficult to remove from key fob Technical Background: -Deviations in the key blade and key fob assembly could make it difficult to remove the key blade.

2052349.10

Service Bulletin/Repair Instructions

Front seatbelt - DTCs-B130474 and/or B130574 Customer Statement: -The DTCs can be evident if the occupant uses a dummy seat belt buckle, the occupant may use the dummy seat belt buckle to prevent a warning light or audible warnings

2053351.8

Service Bulletin/Repair Instructions

Buzzing noise from engine area Customer Statement: -Buzzing noise heard at idle from the sump area when the vehicle is elevated on a workshop ramp. -The noise cannot be heard from inside the cabin or outside of the vehicle in normal circumstances.

2053429.5

Service Bulletin/Repair Instructions

Emission Control System Lamp Illuminated DTC P044100 Evident Customer Statement: -Emission control system warning lamp illuminated within the Driver Information Panel (DIP) in conjunction with DTC - P044100: EVAP Emission Contr.Sys.Incorrect Purge Flow - logged within on or both engine control modules

2055036.6

Service Bulletin/Repair Instructions

My Bentley - Connected Services Technical Background: -Most queries and complaints regarding My Bentley connected services can be resolved by contacting My Bentley Support rather than raising a DISS technical query. My Bentley support have access to additional admin tools and systems to help resolve any queries; and also have ability to raise DISS technical queries if required.

2055772.5

Service Bulletin/Repair Instructions

Battery Conditioner Inoperative Technical Background: -Corrosion on the contact surfaces of the charger socket and charger lead. If the charging socket or charger lead are wet when the charger is connected this can cause corrosion on the contacts.

2055846.7

Service Bulletin/Repair Instructions

Infotainment screen turns red sporadically Customer Statement: -Infotainment screen (goes red fully or partially) within the MMI screen

2056105.4

Service Bulletin/Repair Instructions

Emergency Call Function Test at PDI Technical Background: -The instruction to test the emergency call function at PDI will be integrated within the PDI procedure. -All Emergency call function operating instructions can be found within the Owners handbook (Making an emergency call)

2056407.4

Service Bulletin/Repair Instructions

Running Gear - Noise Identification Customer Statement: -Noise complaint from the suspension and/or steering

2057978.6

Service Bulletin/Repair Instructions

Engine Lubricating Oil - Replenishment Customer Statement: -Engine lubricating oil lamp illuminated on drivers instrument panel -Engine Lubricating oil requires "topping up" between services

2058837.4

Service Bulletin/Repair Instructions

DTCs C135DF0 and/or C12F000 evident within the steering rack and power steering control unit (J500) Technical Background: -Refer to the measure section of this TPI

2061566.4

Service Bulletin/Repair Instructions

During PDI - Unable to complete the set-up of connected services Customer Statement: -Unable to complete set-up of Connected Services at PDI and/or The SOS LED in roof console is either lit red or flashing red and/or the test call is unable to complete.

2063017.2

Service Bulletin/Repair Instructions

Road Wheel Inspection Procedure: Customer Statement: In the event of a complaint is received regarding road wheel/s condition for example: -scratches -corrosion -damage -blemishes -chipping

2063410.4

Service Bulletin/Repair Instructions

Infotainment Main Unit (5F/J794) fault finding/diagnosis procedure Customer Statement: Issue suspected with the Infotainment Main unit (5F/J794) -MMI screen image flickers or goes blank -No Response to selection -Audio cuts-out

2064337.2

Service Bulletin/Repair Instructions

Usage of E10 Fuel Customer Statement: -In the event a customer asks if E10 fuel can be used, the operative must refer to the Technical background section of this TPI

2051187.7

Service Bulletin/Repair Instructions

Poor Engine Running Complaints (Misfires) Petrol Engines Only Customer Statement: -Poor engine running, reduced power, engine warning lamp illuminated.

2068273.1

Service Bulletin/Repair Instructions

Multiple Random Misfires Evident During PDI Customer Statement: -Multiple random cylinder misfire DTC's detected during PDI-DTC P030000: Random/Multiple cylinder misfire detected with the following control units: -V8-ECM1-V*(Address01)ECM control unit -W12-ECM 1 - (Address 01) and/or ECM 2 (Address 11)

2065919.3

Service Bulletin/Repair Instructions

Water Leaking from the mechanical water pump- Low coolant level warning displayed Customer Statement: -Coolant leaking from the mechanical coolant pump -Coolant witness mark on the mechanical coolant pump although coolant is not leaking/dripping from the pump -Low coolant level warning displayed

2066852.2

Service Bulletin/Repair Instructions

Shaker Speaker-Diagnostic Checks Customer Statement: -Customer complains of poor quality music output from the shaker speaker due to rattling noise/sound distortion. Technical Background: -There have been instances where shaker speakers have been changed under warranty for the complaint of sound distortion, yet when tested by Bentley Motors and the supplier, no fault could be found with the returned unit.

2051562.9

Service Bulletin/Repair Instructions

12 Volt- Battery Condition Checks. Technical background For all 12 volt battery issues relating to warranty or a parts warranty claim, a DISS query MUST be raised prior to battery replacement, refer to the instructions within the Measure section of this TPI.

2066480/2

Service Bulletin/Repair Instructions

Headlamp Switch Not Working/Not Illuminated - Numerous DTCs within 0009 - Central Electrics (BCM1) Technical Background: -The condition will not occur when the ignition is on or whilst the vehicle is being driven -The condition only occurs as the headlamp switch goes into a "Sleep" state after the ignition is switched off -The condition is evident to the driver when the ignition is next switched on

2054635/7

Service Bulletin/Repair Instructions

Fluid Leak From Front Air Spring Customer Statement: -Fluid leak from the base and/or the top of the front air springs Technical Background: -The fluid shown in figures 1 and 2 is assembly fluid residue. The fluid is applied to various internal components of the air spring during manufacture.

2061362/2

Service Bulletin/Repair Instructions

Engine Intermittently Fails to Start/Kombi Pop Up 'Engine start system:fault' Customer Statement: -Customer unable to intermittently start the engine with the start button or engine starts but customer gets a pop up error on the Kombi Technical Background: -The Access/Start authorization button requires a certain amount of force applying to activate the internal switches -If all 3 switches within the Access/Start authorization button are not engage multiple times in a row the above DTC will store and the customer will get a pop up on the Kombi. The engine however will still start up.

2067489/1

Service Bulletin/Repair Instructions

Window side glass - Identification - Standard (STD) or Privacy (PRV) Customer Statement: - Incorrect side glass fitted - Standard (STD) not Privacy (PRV) or visa versa and/or Defects are evident within the glass Technical Background: -The instructions within the Measure section MUST only be followed if the glass is to be replaced

2053177/17

Service Bulletin/Repair Instructions

All Vehicle Variants - Spurious DTC List. Customer statement / workshop findings: -Customers will not be aware of any fault codes -Workshop may discover spurious fault codes whilst running a Diagnostic Trouble Code (DTC) log as part of other investigations on the vehicle Technical background: -The operative should refer to the Bentley Hub referencing TPI 2053177/- The document (loaded onto the Hub) contains all of the current known Spurious DTCs for all vehicle variants -Should a particular TPI be listed as Archived, the TPI can no longer be viewed within Elsa pro, in this case please refer to the instructions within TPI 2053177/- regarding the DTC description and actions which should be conducted (if any).

2051965/3

Service Bulletin/Repair Instructions

Bentley dynamic ride system warning displayed- DTC P0B2500: Hybrid/EV Battery A Voltage low stored. Customer statement / workshop findings: Bentley dynamic ride system: fault displayed within the Drivers Instrument Panel (DIP) Workshop findings: DTC P0B2500: Hybrid/EV Battery A Voltage low stored within address 21-Battery Energy Control Module 2 Technical background: Possible internal fault with super capacitor, refer to the Measure section of this TPI

2067488/1

Service Bulletin/Repair Instructions

Veneer/trim mismatch - DISS query requirements. Customer statement / workshop findings: In the event that a trim mismatch is detected for example: - Piano black veneer is supplied although the customer ordered walnut veneer Or - The interior trim colour is incorrect for example: Cricket ball interior trim is supplied although the customer ordered Hotspur The operative should refer to the Technical background section

2067418/1

Service Bulletin/Repair Instructions

Bentley brand name lettering is no longer applied to the rear calipers (vehicles specified with iron brakes). Customer statement / workshop findings: The rear brake calipers do not have the brand name lettering Bentley applied to the rear brake calipers However The front brake calipers do have the brand name lettering Bentley applied to the front brake calipers Technical background: Refer to the production change section Production change: All vehicles which have been produced post 31.05.2022 onwards do not have the brand name lettering Bentley lettering applied to the rear brake calipers as shown in Figure 1

2058423/8

Service Bulletin/Repair Instructions

New Continental GT/GTC, New Flying Spur and Bentayga - Low Oil Pressure Warning During Early Vehicle Life. Customer statement / workshop findings: Warning on the Driver Instrument Panel (DIP) - Oil pressure too low DTCs relating to oil pressure may also be stored within the Master ECU. Diagnostic Trouble Codes (DTC) P052400: Engine Oil Pressure Too Low and/or P15AA00: Engine oil pressure - Lower limit not reached stored in the Master Engine Control Unit (ECU). Measure: VERY IMPORTANT: Prior to conducting the onward instructions, the following symptoms MUST be evident - Warning on Driver Instrument Panel (DIP) Oil pressure too low And/or - Diagnostic Trouble Codes (DTC) P052400: Engine Oil Pressure Too Low and/or P15AA00: Engine oil pressure - Lower limit not reached stored in the Master Engine Control Unit (ECU) Should any of the afore mentioned not be evident and the symptoms cannot be reproduced No further action should be taken unless the issue can be reproduced or demonstrated by the customer In the event the symptom/s are evident please conduct the onward Diagnosis Instructions

2066852/1

Service Bulletin/Repair Instructions

Shaker speaker - Diagnostic checks. Customer statement / workshop findings: Customer complains of poor quality music output from the shaker speaker due to a rattling noise/sound distortion. Technical background: There have been instances where shaker speakers have been changed under warranty for the complaint of sound distortion, yet when tested by Bentley motors and the supplier, no fault could be found with the returned unit. Measure: To ascertain the difference between distortion or a rattle emanating from a loose/surrounding component Or The shaker speaker itself is incorrectly secured and/or at fault please conduct the following steps before replacing any components

2066669/1

Service Bulletin/Repair Instructions

Engine coolant - Overheat condition - Warning evident within the DIP - DTC's P2B6500 and P2B8600 are evident. Customer statement / workshop findings: - Engine cooling system overheating And/or - Coolant loss And/or - Warning light in Drivers Information Panel (DIP) The following DTCs may also be evident within 0001 and/or 0011 - P2B6500 and/or P2B8600.

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.