Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B012016
The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.
B510819
The basic conditions for initializing the power windows are not met.
B611305
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
SB23-01
Spl Parts, Inc. communications index accompanying MCP uploads 23mc40464 & 23mc40471
sb23-01TMS
This is the companion to SPL Parts, Inc.'s SB 23-01 mailed by private label independent distributor Turner Motorsports.
SB 23-01
SPL Parts, Inc. manufacturers and distributes aftermarket lower control arms for dedicated competition vehicles and "track day" cars some of which may be used on both track and highway. SB 23-01 adresses proper installation torque of cap bolt fasteners attaching SPL's aftermarket lower control arms, recurring inspection and confirmation of torque setting and removal and replacement of damaged or under torqued fasteners to reduce risk of premature failure and accident. SB-23-01 was mailed, emailed and posted on SPL website to known resellers, race teams and users of the affected parts and is being submitted here as required by part 579.5. Vehicle Applications include: BMW series 1,2,3,& 4, 2008-2023; Chevrolet Camaro 26-2023, Cadillac ATS, CTS 2016-2019; Ford Mustang 2015-2023; Toyota Supra 2020-2023.
B540907
RETRACTABLE HARDTOP STATUS REQUEST SUPPLEMENT
SIB-16-16-14
BMW: SELECTIVE CATALYST REDUCTION MODULE (SCR) HAS A STORED FAULT, PRESSURE BUILD UP IS LOW, CAUSING SERVICE ENGINE SOON LIGHT TO ILLUMINATE. *
SIB-12-14-12
BMW: EXPERIENCING LOSS OF ENGINE POWER, SERVICE ENGINE SOON LAMP IS ILLUMINATED, A NOISE, LIKE RATTLING, COMING FROM ENGINE COMPARTMENT. *PE UPDATED 10/31/12. *PE MODELS 2010 E70, 71, 82, 88, 90, 92, 93, F07, 10, 12, 13, 25. UPDATED 1/18/13. *PE UPDATED 4/18/2013. *KB UPDATED 05/13/2013 *JS UPDATED 5/19/15. *PE
SIB-12-21-10
BMW: SERVICE ENGINE SOON LIGHT IS ON. THE VEHICLE LOST POWER AND THE ENGINE CRANKS WITH NO START. *RM UPDATED 5/19/15. *PE
SIB-63-11-14
BMW: ON SOME VEHICLES, WHEN STARTING, LOW BEAM, WITH 0552 OPTION, WOULD BRIEFLY FLASHES, DUE TO A FAULTY LED MAIN LIGHT MODULE THAT NEEDS REPLACING. MODEL 2008-14 F01, F02, F06, F07, F10, F12, F13, F25. *PE
SIB-84-03-14
BMW: WHEN USING IPHONE, VARIOUS CONNECTIVITY FAILURES OCCUR, SUCH AS DISCONNECTION OF CALL, LIST OF CONTACTS INCOMPLETE, DUE TO THE VARIANTS AND SOFTWARE USED. MODEL 2008-2014.
SIB-12-15-13
BMW: SERVICE ENGINE AND ENGINE MALFUNCTION LIGHT ILLUMINATES. VEHICLE MAY HAVE REDUCED POWER OUTPUT. FAULT CODE MAY NOT CLEAR FROM DME FAULT MEMORY. *KB UPDATED ON 11/8/2013. *KB UPDATED 2/21/2014 *JS UPDATED 3/11/14. *PE
SIB-34-06-12
BMW: WARNING LAMPS ARE ILLUMINATED FOR THE DSC, ABS AND BRAKE AND A POSSIBLE WARNING IN CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. MODELS 2012 F25, 30, 01, 02, 07, 10, 12, 13, E70, 71, 84. *PE
SIB-11-03-08
BMW: CRANKCASE PRESSURE DIAGNOSIS AND INFORMATION FOR ALL VEHICLES. *RM UPDATED ON 4/24/2013. *KB
SIB-12-16-11
BMW: SERVICE ENGINE SOON LIGHT IS ON AND THE ENGINE HAS REDUCED POWER WITH TROUBLE CODES STORED. *RM UPDATED ON 4/24/2013. *KB
SIB-18-02-12
BMW: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE REPLACING AND/OR CHECKING OF EMISSIONS MONITORING COMPONENTS TO INCREASE EMISSIONS STABILITY, HIGH PRESSURE (HP) EGR VALVE RESTRICTION OF EXCESSIVE SOOT AND IMPROVED DIESEL EXHAUST FLUID (DEF) MIXTURE INTRODUCED IN EXHAUST SYSTEM FROM SCR MIXER. MODEL 2008-2009 E70, E90. *PE UPDATED 5/10/13. *PE
SIB-61-13-05
BMW: BATTERY HAS AN INCREASED DEMAND DUE TO DEVELOPEMENTAL PROCESS OF THE ELECTRICAL SYSTEM. THIS IS CAUSING THE BATTER TO NEED TO UNDERGO AN ENERGY DIAGNOSIS. *KB
SIB-61-37-12
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS
SIB122512
BMW: VEHICLE DOES NOT START: LOOSE GROUND Z6000 *4B. COVERED UNDER THE TERMS OF THE BMW NEW VEHICLE/SAV LIMITED WARRANTY. *JS
SIB270212
BMW: DSC WARNING LIGHT IS ON. THE WARNING LAMPS FOR DSC, ABS AND BRAKE WARNING ILLUMINATED. THERE MAY ALSO BE A WARNING IN THE CONTROL DISPLAY FOR CHASSIS CONTROL SYSTEM FAILURE. *JS
SIB-11-02-08
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. IF THE IGNITION IS CYCLED, THE ENGINE THEN USUALLY PERFORMS NORMALLY. *PE UPDATED 2/7/11. *PE UPDATED ON 06/09/2011. *KB UPDATED 8/10/11. *PE UPDATED 1/11/13. *PE
SIB-16-03-12
BMW: THE EVAPORATIVE SYSTEM LEAKAGE IS FOUND, WHEN USING THE NVLD TANK LEAKAGE TEST PLAN. *PE UPDATED 1/18/13. *PE
SIB-61-02-12
BMW: ELECTRONIC MALFUNCTION AND VARIOUS CHECK CONTROL MESSAGES ARE DISPLAYED IN CID (CENTRAL INFORMATION DISPLAY) AND INSTRUMENT CLUSTER. *PE MODELS 2009-2012 E70, E71, E72, E82, E88, E90, E91, E92, E93, F01, F02, F04, F07, F10, F12, F13, F25. UPDATED 11/2/12. *PE
SIB-01-02-12
BMW: A FAILURE OF THE TURBOCHARGER WASTEGATES, CAUSED BY A DEFECT, HAS AN EMISSIONS EXTENDED WARRANTY, 8 YEARS OR 82,000 MILES, WHICHEVER COMES FIRST, NOT OTHERWISE FALLING WITHIN COVERAGE EXCLUSION. *PE
SIB-11-13-07
BMW: THERE IS A CLANKING NOISE FROM THE ENGINE OR EXHAUST AREA. WASTEGATE VALVE IS NOT COMPLETELY CLOSING AND CLANKING. *RM UPDATED 7/17/12. *PE
B63-03-12
BMW: THE LEFT OR RIGHT REAR LIGHT IN THE SIDE PANEL HAS CONDENSATION CONCERNING VEHICLES PRODUCED UP TO FEBRUARY 27,2012. *JS
SIB-12-01-11
BMW: THE SERVICE ENGINE SOON LIGHT IS ON WHILE DRIVING. THIS IS A PROGRAMMING ISSUE. *RM UPDATED 1/4/12. *PE UPDATED 4/24/12. *PE
SIB-16-04-10
BMW VEHICLE: TEILECLEARING FOR DIAGNOSTIC MODULE TANK LEAKAGE (DMTL) SYSTEM. TEILECLEARING PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF CUSTOMER COMPLAINTS RELATING TO THE DMTL SYSTEM (E.G., EVAPORATIVE SYSTEM LEAKS, CHECK FILLER CAP MESSAGE, ETC.). THIS PROCESS CAN HELP EXPEDITE THE DEFECT ERADICATION PROCESS, ONCE THE ROOT CAUSE BEEN DETERMINED. NO MODEL YEARS LISTED. *PE UPDATED 8/3/11. *PE UPDATED 8/10/11. *PE UPDATED 4/24/12. *PE
SIB-13-13-10
BMW: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP HAS AN INTERNAL COMPONENT THAT MAY FAIL AND CAUSING DRIVABILITY SYMPTOMS SUCH AS ERRATIC ENGINE OPERATION AND LONGER STARTING TIMES. *PE
SIB-61-06-11
BMW: ON CERTAIN VEHICLES, THE JBE (JUNCTION BOX ELECTRONICS) MODULE FAILS PROGRAMMING DURING A SOFTWARE UPDATE OF THE VEHICLE. *PE
SIB-24-03-08
BMW: COMPLAINT OF A DELAYED ENGAGEMENT AND A HARSH JOLT WHEN ACCELERATING FROM A STOP. THE SITUATION OCCURS ONLY DURING THE ENGINE WARM UP PHASE (COLD ENGINE), AND CANNOT BE REPRODUCED IN THE SPORT MODE. EGS SOFTWARE-UNFAVORABLE NIC CALIBRATION. *PE UPDATED 9/28/11. *PE
SIB-63-03-11
BMW: WIRING ON THE HEADLIGHTS MAY HAVE DETERIORATED DUE TO ENVIRONMENTAL CONDITIONS AND THE COVER NOT BEING SECURED PROPERLY. E60/E92. *RM UPDATED 9/30/11. *PE
SIB-72-01-11
BMW: E92. THE SEAT BELT EXTENDER ON THE FRONT DRIVER¿S OR PASSENGER SIDE FAILED TO DELIVER THE BELT. THE SAFETY BELT EXTENDER EXTENDS BUT THE BELT SLIPS OFF. THE ¿HAND¿ ON THE EXTENDER FAILS. THE SAFETY BELT IS TWISTED. THE EXTENDER WILL NOT OPERATE AND MAKES NOISE WHILE EXTENDING. *RM
SIB-12-15-11
BMW: THE SERVICE ENGINE SOON LIGHT IS ON. THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM
SIB-33-01-02
BMW: A GRINDING NOISE IS COMING FROM THE DIFFERENTIAL DURING SLOW CORNERING. WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. *RM
SIB-61-01-11
BMW: VARIOUS FUNCTIONS IN THE VEHICLE ARE NOT WORKING INCLUDING: INSTRUMENTS, DOOR LOCKS, WIPERS, AND OTHER ELECTRICAL FUNCTIONS. THERE MAY ALSO BE WARNING LIGHTS ON. K-CAN WIRING IN THE VEHICLE SHORTED. *RM UPDATED 10/5/11. *PE
SIB-61-08-11
BMW: THE VEHICLE ELECTRICAL SYSTEM FAILS AND THE VEHICLE FAILS TO START. THE CENTRAL LOCKING SYSTEM FAILS TO OPERATE WITH THE REMOTE KEY. THE KEY CANNOT BE INSERTED INTO THE KEY SLOT. COMMUNICATION TO THE VEHICLE IS NOT POSSIBLE. THE POSITIVE BATTERY CABLE CONNECTION AT THE FRONT POWER DISTRIBUTION BOX LOSES CONNECTION. *RM
SIB-28-01-10
BMW: THERE IS A SOFTWARE PROBLEM WITH THE DUAL CLUTCH TRANSMISSION MODULE. DATA CAN'T BE READ FROM THE MODULE'S MEMORY. *RM UPDATED 8/10/11. *PE
SIB-17-05-10
BMW: THE SERVICE ENGINE LIGHT IS ON WITH STORED FAULT CODES. THERE IS A WIRING/CONNECTION PROBLEM OR A FAULTY SENSOR. *RM
SIB-51-18-06
BMW: THE PAINTED SURFACE ON THE INTERIOR DOOR HANDLE MAY PEEL DUE TO EXPOSURE TO HAND CREAMS AND SUN-TANNING LOTIONS. *RM
SIB-23-01-08
BMW: A NEW TECHNICAL SUPPORT PROCESS HAS BEEN CREATED REGARDING TRANSMISSION CONCERNS. *RM
SIB-63-04-11
BMW: THE SEAL ON THE REAR LAMPS IN THE SIDE PANEL EMITS A GAS AND CAUSES DAMAGE TO THE ELECTRICAL CONNECTORS ON THE LEDS INSIDE THE LAMP. E91. *RM
SIB-12-16-07
BMW: A SOFTWARE ERROR IS CAUSING THE THE SERVICE ENGINE SOON LIGHT TO COME ON. THERE WILL BE STORED TROUBLE CODES. *RM
SIB-51-09-11
BMW: POOR ELECTRICAL CONNECTIONS ARE CAUSING THE INSTRUMENT CLUSTER TO SHOW THE DOORS ARE OPEN WHILE DRIVING EVEN THOUGH THEY ARE CLOSED. *RM
SI B12 02 11
BMW: ON LOW MILEAGE VEHICLES THE ENGINE RUNS ROUGH, MIFIRES, OR FAILS TO CRANK. THIS IS CAUSED BY MULTIPLE SHORT START-UPS WITHOUT THE ENGINE PROPERLY GOING THROUGH A WARM-UP PHASE. *RM
SI B12 11 10
BMW: THERE ARE HIGH FUEL PRESSURE FAULTS STORED DUE TO A SOFTWARE ERROR. *RM
SI B12 55 06
BMW: THERE MAY BE EXCESSIVE CRANKING BEFORE THE VEHICLE STARTS. THE SERVICE ENGINE SOON LIGHT MAY ALSO BE ON WITH A LACK OF ENGINE POWER. *RM
CN-10E-A02
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE MAY BE A PROBLEM WITH THE FUEL PUMP WHICH COULD NOT MEET EMISSIONS REQUIREMENTS. THERE MAY BE A LONG CRANK AND A SERVICE ENGINE SOON LIGHT. *RM
SIB-52-12-10
BMW: THE FRONT SEAT HEATER ACTIVATES ON ITS OWN BECAUSE OF DEFECTIVE WIRING CONTACTS. *RM
SIB-12-24-05
BMW: THE SERVICE ENGINE SOON LIGHT MAY BE ON WITH THE VEHICLE RUNNING ROUGH AND INTERNAL MISFIRE CODES. THIS IS AN IGNITION COIL PROBLEM. *RM
SIB-32-01-09
BMW: IMMEDIATELY AFTER A COLD START IF ELECTRONIC COMPONENTS ARE TURNED ON SUCH AS HEATED SEATS IT MAY SWITCH OFF AFTER 5-10 SECONDS BECAUSE OF A VOLTAGE LEVEL DIP. *RM
SIB-51-46-10
BMW: THE DOOR CANNOT BE LOCKED OR UNLOCKED WHEN USING THE KEY OR KEY REMOTE. LUBRICATION OF THE DOOR CAN CAUSE DEFECTS. *RM
SIB-72-03-10
BMW: ON SOME E92 MODELS THE SAFETY BELT EXTENDER IS NOT EXTENDING THE BELT OR IS NOISY. THIS CAN BE A FAULT OF THE EXTENDER OR THE BELT IS CONTORTED. *RM
SI-B12-22-10
BMW VEHICLE: PROGRAM CONTROL UNITS. SERVICE ENGINE SOON (MIL) LAMP MAY COME ON DUE TO A DIAGNOSTIC ERROR. TO DETERMINE WHETHER A SPECIFIC VEHICLE HAS HAD THIS SERVICE COMPLETED OR IS AFFECTED BY THIS SERVICE, FIRST CHECK THE B PILLAR LAB EL FOR CODE NUMBER 577. IF CODE NUMBER BEEN PUNCHED OUT, WAS ALREADY PERFORMED. IF NOT PUNCHED OUT, ITS NECESSARY TO UTILIZE KEY READER. PROGRAM THE VEHICLE USING ISTA/P 2.39.2 OR LATER. *PE
SIB-24-01-08
BMW VEHICLE: TRANSMISSION WARNING LIGHT IS ILLUMINATED AND THE TRANSMISSION ENTERS FAILSAFE MODE. FAULT CODE 4F81 (RATIO MONITORING, CLUTCH A), IN SOME CASES COMBINED WITH THE SUBSEQUENT FAULTS 507B/507C (PARKING GEAR SENSOR IMPLAUSIBLE SIGNAL) OR 507D (PARKING GEAR INCORRECTLY DISENGAGED), ARE STORED IN THE EGS CONTROL MODULE. E60, E51, E65, E66, E70, E90, E91, E92, E93. NO MODEL YEARS LISTED. *PE
SIB-63-02-08
BMW VEHICLE: REAR BULB FAILURE. THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. DIAGNOSIS SHOWS A FAULT FOR THE REAR LAMP. THE BULB OUT CAN BE DISPLAYED FOR 2 POSSIBLE CAUSES: POOR FIT BETWEEN THE BULB AND BULB HOLDER; BULB FAILURE CAUSED BY VIBRATION. *PE
SIB-72-01-10
BMW VEHICLE: FRONT SAFETY BELT DOES NOT RETRACT SMOOTHLY OR JAMS. THE UPPER PART OF THE DRIVER'S OR PASSENGER'S FRONT SAFETY BELT DOES NOT ROLL UP FULLY OR ROLLS UP SLOWLY. THE ADJUSTMENT OF THE INERTIA REEL IS INCORRECT AT THE FASTENING POINT. THE BELT IS TOUCHING THE GUIDE FUNNEL. MODELS E90, E91 AND E92. NO MODEL YEARS LISTED. *PE
SIB-16-01-09
BMW: THERE IS AN EXTRACTION AND REFILLING PROCESS FOR THE DESIEL EXHAUST FLUID. E70 AND E90 MODELS. *RM
SIB-22-01-10
BMW: THERE CAN BE VIBRATION IN THE ENGINE WHILE DRIVING AT VARIOUS SPEEDS DUE TO ENGINE MOUNT BRACKET BOLTS. *RM
SIB-41-03-10
BMW: ON E91 MODELS THE INSTRUCTIONS FOR REPAIRING/REMOVING THE TAILGATE HINGE HAS BEEN REVISED. *RM
SIB-51-20-09
BMW: THE TAILGATE OPENS SLOWER IN LOW TEMPERATURES AND DOESNT FULLY OPEN. *RM
SIB-65-36-09
BMW: THE AIRBAG WARNING LAMP IS ILLUMINATED DUE TO A SOFTWARE ERROR. *RM
SI-B-63-06-10
BMW: LEDS IN REAR LAMP INOPERATIVE. THE LEDS (LIGHT EMITTING DIODES) IN THE OUTER LEFT OR OUTER RIGHT REAR LAMP ARE INOPERATIVE. AFFECTED ARE THE LEDS FOR THE PARKING LAMP/TAIL LAMP OR THE TURN SIGNALS. NO CHECK CONTROL MESSAGE IS DISPLAYED. CORROSION OF AN INTERNAL CONNECTION WITH THE TAIL LAMP IS CAUSED. *PE UPDATED 9/26/11. *PE
SIB-12-18-10
BMW: BMW: THERE IS A SOFTWARE ERROR THAT IS CAUSING THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE WITHOUT A FAULT CODE. *RM
SIB-63-02-01
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
SIB-63-05-10
BMW: THE REAR LED LIGHTS ARE INOPERATIVE. THERE IS CONNECTION CORROSION IN THE TAIL LAMP. *RM
SIB-65-24-03
BMW: OPERATING DESCRIPTION OF THE PASSENGER AIRBAG STATUS LIGHT. *RM
TS-12-19-10
BMW: SERVICE ENGINE SOON LIGHT IS ON WITH A FAULT CODE STORED. INTERNAL DMTL PUMP FAILURE.*RM
SIB-11-08-03
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM
SIB-11-02-10
BMW: SERVICE ENGINE SOON LIGHT IS ON WITH DIESEL ENGINES. *RM
SIB-13-02-10
BMW: IT IS NOW POSSIBLE TO PERFORM A FUEL QUALITY DETECTION TEST ON VEHICLES WITH AN N54 ENGINE. *RM
SIB-13-06-10
BMW: A SERVICE ENGINE SOON LIGHT COMES ON. THE ENGINE WILL ONLY OPERATE TO 1500 RPMS AND LACKS POWER. THERE IS A SOFTWARE APPLICATION ERROR. *RM
SIB-13-07-10
BMW: THERE IS A ROUGH ENGINE IDLE AND "SERVICE ENGINE SOON LIGHT" WHEN DRIVING DOWNHILL IN HIGH ALTITUDES DURING COLD WEATHER. THERE MAY BE SIX DIFFERENT FAULT CODES. *RM
SIB-16-03-10
BMW: WARNING MESSAGE ON ABOUT LOW DIESEL EXHAUST FUEL LEVEL AND THAT THE ENGINE WILL NOT RESTART WITHIN 999 MILES. THE LIGHT COMES ON A FEW THOUSAND MILES EARLIER THAN A RECOMMENDED OIL CHANGE. *RM
SIB-27-01-07
BMW: A FAULT FOR OIL WEAR IS STORED IN THE MEMORY, BUT IT DOES NOT ILLUMINATE THE WARNING LAMP. *RM
SIB-28-02-08
BMW: A NEW TECHNICAL PROCESS IS BEING USED ON MANY MODELS TO DETERMINE THE ROOT CAUSE OF DOUBLE-CLUTCH TRANSMISSION PROBLEMS. *RM
SIB-32-04-07
BMW: A NEW TECHNICAL PROCESS HAS BEEN CREATED FOR BMW TO IDENTIFY CAUSES OF STEERING COMPLAINTS WITH A WIDE RANGE OF MODELS. *RM
SI-B-13-03-10
BMW: PROGRAM CONTROL UNITS. VEHICLES WITH M57Y DIESEL ENGINE. SERVICE ENGINE SOON LAMP (MIL) IS ILLUMINATED ERRONEOUSLY. DDE SOFTWARE ERROR. *PE
SIB-61-18-09
BMW VEHICLES: VARIOUS SIMULTANEOUS ELECTRICAL PROBLEMS. THERE IS A SOFTWARE ERROR IN THE JBBFE-3R CONTROL MODULE. VERY INTERMITTENTLY, THE JBBFE-3R WAKES UP IN BOOTLOADER ODE INSTEAD OF APPLICATION MODE. PERFORM DIAGNOSTICS WITH ISTA AND WORK THROUGH ANY RELATED TEST MODULES. *PE
SIB-16-02-09
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE
SIB-16-08-06
BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. RIGHT SIDE FUEL SENDING UNIT IS DISLODGED FROM ITS BRACKET DUE TO INCORRECT ASSEMBLY. NO MODEL YEARS LISTED. *PE UPDATED 4/29/11. *PE
SIB-41-02-09
BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. AS A RESULT, A DISTINCT CLICKING NOISE CAN BE HEARD FROM THE AREA OF THE REAR AXLE CARRIER DURING CERTAIN DRIVING CONDITIONS. MODEL E46 (3SERIES). NO MODEL YEARS LISTED. *PE
SIB-16-01-06
BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. *PE
SIB-36-05-07
BMW: TIRE WARNING LIGHT ILLUMINATED DUE TO LOW AMBIENT TEMPERATURE. MODEL E90, E91(3 SERIES);E92, E92 (3 SERIES); E60 (5 SERIES); E60 (M5); E63, E64 (6 SERIES); E63, E64 (M6); E65, E66 (7 SERIES); E70 (X5); E83 (X3); AND E85, E86 (Z4). *PE
SIB-11-14-07
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. IN ADDITION, THE COMPLAINTS OF A SLIGHT REDUCTION OF POWER SIMILAR TO AN INCREASED TURBO LAG. THE VACUUM SUPPLY TO THE WASTE GATES MAY BE RESTRICTED OR BLOCKED. NO MODEL YEARS LISTED. *PE
SIB-34-078-07
BMW VEHICLES: DSC DISABLING FUNCTION. DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.