B510819
Service Bulletin/Repair Instructions
The basic conditions for initializing the power windows are not met.
Vehicle report
2001 BMW 5 SERIES
Service bulletins
38 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B160623
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B653423
Service Bulletin/Repair Instructions
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
B660523
Service Bulletin/Repair Instructions
Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
B122917
Service Bulletin/Repair Instructions
SERVICE ACTION: PROGRAM DME: The incorrect dataset could be programmed into DME 5.2.1 control module.
SIB-61-37-12
Service Bulletin/Repair Instructions
BMW: THE HIGH-VOLTAGE (HV) BATTERY CELLS COULD BE DAMAGED IF THE VEHICLE IS PREVENTED FROM ENTERING SLEEP MODE FOR AN EXTENDED PERIOD OF TIME. UPDATED 03/11/2013 *JS
SIB240812
Service Bulletin/Repair Instructions
BMW: INTERMITTENTLY GOES INTO PARK DURING A MSA ENGINE START. THE TRANSMISSION CAN INTERMITTENTLY GO INTO THE PARK POSITION (P) WHEN MSA ENGINE START IS OCCURRING. A DRIVE GEAR CAN BE SELECTED IN ORDER TO DRIVE AWAY, AND NO RELEVANT FAULTS ARE STORED. *JS
SIB-11-02-08
Service Bulletin/Repair Instructions
BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. IF THE IGNITION IS CYCLED, THE ENGINE THEN USUALLY PERFORMS NORMALLY. *PE UPDATED 2/7/11. *PE UPDATED ON 06/09/2011. *KB UPDATED 8/10/11. *PE UPDATED 1/11/13. *PE
B61-17-12
Service Bulletin/Repair Instructions
BMW: WIPERS LIGHTS AND FRONT POWER WINDOWS ARE INOPERATIVE. THIS SITUATION MAY START AND LEAD TO A PERMANENT FAULT. ALSO INCLUDED MODEL F07 (5 SERIES GRAN TURISMO) MODEL YEARS UP TO MARCH 2012. *JS
SIB-63-03-11
Service Bulletin/Repair Instructions
BMW: WIRING ON THE HEADLIGHTS MAY HAVE DETERIORATED DUE TO ENVIRONMENTAL CONDITIONS AND THE COVER NOT BEING SECURED PROPERLY. E60/E92. *RM UPDATED 9/30/11. *PE
SIB-65-75-06
Service Bulletin/Repair Instructions
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. *PE UPDATED 9/30/11. *PE
SIB-12-15-11
Service Bulletin/Repair Instructions
BMW: THE SERVICE ENGINE SOON LIGHT IS ON. THERE ARE TROUBLE CODES STORED FOR THE CRANKSHAFT SENSOR. NO DRIVEABILITY ISSUES. *RM
SIB-33-01-02
Service Bulletin/Repair Instructions
BMW: A GRINDING NOISE IS COMING FROM THE DIFFERENTIAL DURING SLOW CORNERING. WHEN TURNING A SLIP/STICK EFFECT IS CREATED ON THE LINING AND STEEL DISCS INCORPORATED IN THE DIFFERENTIAL CLUTCH CAUSES A GRINDING NOISE. *RM
SIB-63-10-10
Service Bulletin/Repair Instructions
BMW VEHICLE: ADAPTIVE HEADLIGHTS. A CHECK CONTROL (CC) MESSAGE IS DISPLAYED FOR THE ADAPTIVE HEADLIGHTS. THE HEADLAMPS NO LONGER TURN WITH STEERING WHEEL MOVEMENT. FAULT CODE 800FC6 IS ENTERED IN THE FOOTWELL MODULE (FRM3). A SECOND TURN SIGNAL REQUEST IS MADE AT THE EXACT MOMENT WHEN THE STEERING WHEEL IS AUTOMATICALLY CANCELLING FROM A PREVIOUS TURN SIGNAL REQUEST. F07 (5 SERIES), F01, F02, F07 (7 SERIES). *PE
SIB-65-22-10
Service Bulletin/Repair Instructions
BMW VEHICLES: REPLACED SEAT OCCUPANCY SENSOR MAT WILL NOT ENABLE. AFTER REPLACING A CIS (CAPACITIVE SENSING PASSENGER OCCUPANCY MAT), THE NEW MAT WILL NOT ENABLE WHEN USING ISTA/P. HOWEVER, ISTA/P SHOWS THAT THE ACSM (ACTIVE CRASH SAFETY MODULE) WAS CODED CORRECTLY. THE FOLLOWING FAULTS ARE STORED IN THE ACSM CONTROL MODULE:9309ED, 9309F4 AND 930A23. ADSM CODING *PE
SIB-63-02-01
Service Bulletin/Repair Instructions
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
SIB-11-08-03
Service Bulletin/Repair Instructions
BMW: SIX DIFFERENT MODELS EQUIPPED WITH THE M54 ENGINE COULD HAVE VALVE COVERS BREAK IN COLD WEATHER AND RUIN THE ENGINE. THIS IS DUE TO MOISTURE ACCUMULATION. *RM
SIB-32-04-07
Service Bulletin/Repair Instructions
BMW: A NEW TECHNICAL PROCESS HAS BEEN CREATED FOR BMW TO IDENTIFY CAUSES OF STEERING COMPLAINTS WITH A WIDE RANGE OF MODELS. *RM
SI-B37-01-09
Service Bulletin/Repair Instructions
BMW: VEHICLE HAS A CHECK CONTROL MESSAGE SELF LEVELING SUSPENSION FAILED/MALFUNCTIONING DISPLAYED. AT LEAST ONE OF THE FOLLOWING FAULT CODES IS STORED AND IS CURRENTLY PRESENT IN THE EHC CONTROL UNIT: 5F98 CONTROL TIME FAULT LIFTING REAR LEFT; 5F99 CONTROL TIME FAULT LIFTING REAR RIGHT; 5F9A CONTROL TIME FAULT LIFTING. MODEL YEARS UNKNOWN. *PE UPDATED 11/17/10. *PE
SIB-16-02-09
Service Bulletin/Repair Instructions
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE
SIB-12-07-06
Service Bulletin/Repair Instructions
BMW: SERVICE ENGINE SOON LAMP ILLUMINATED-FC 23F4 MAP THERMOSTAT. IN SOME VEHICLES HAVE INSUFFICIENT HEAT. E90, E91 (3 SERIES), E60, E61 (5 SERIES) 3/06 AND E83 (X3 SERIES) 9/08. *PE
SI-B12-02-09
Service Bulletin/Repair Instructions
BMW: SERVICE ENGINE SOON LAMP OR THE CHECK GAS CAP WARNINGS ARE ILLUMINATED WHILE DRIVING. WHEN DIAGNOSED, THE DME HAS STORED FAULTS FOR SMALL LEAK, MICRO LEAK, SUPER FINE LEAK, OR LARGE LEAK IN RELATION TO THE TANK VENTILATION OR EVAPORATIVE SYSTEM *PE UPDATED 10/27/09. *PE
SI-B-62-01-09
Service Bulletin/Repair Instructions
BMW: ALL INSTRUMENT DIALS ARE INOPERATIVE AND THE ILLUMINATION OF THE INFORMATION DISPLAY IN THE INSTRUMENT CLUSTER IS VERY BRIGHT. *PE
SI-B-11-01-07
Service Bulletin/Repair Instructions
BMW: SMALL NUMBER OF VEHICLES EXPERIENCE PROBLEMS RANGING FROM LEAKING OIL FILLER CAPS, LEAKING OR BROKEN VALVE COVERS, TO COMPLETE ENGINE FAILURE IN EXTREMELY COLD CLIMATE CONDITIONS. MOISTURE ACCUMULATING IN ENGINE CRANKCASE VENTILATION VALVE OR HOSES CAN FREEZE DUE TO LOW AMBIENT TEMPERATURES. *PE
SI B63-04-08
Service Bulletin/Repair Instructions
BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE
SI B11 13 07
Service Bulletin/Repair Instructions
N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. *PE
SIB-12-09-07
Service Bulletin/Repair Instructions
BMW VEHICLE: SERVICE ENGINE SOON LIGHT ILLUMINATED: S85-VARIOUS VANOS RELATED FAULTS STORED. (E60 (5SERIES), E63 & E64 (6SERIES). NO MODEL YEARS LISTED. *PE
SIB-12-09-08
Service Bulletin/Repair Instructions
BMW VEHICLE: DRIVEABILITY COMPLAINTS DUE TO COOLING FAN RELAY FAILURE. THE CUSTOMER MAY COMPLAIN OF INTERMITTENT DRIVEABILITY PROBLEMS, DESCRIBED AS-ENGINE IS LACKING POWER WHEN ACCELERATING UPHILL; TRANSMISSION WILL NOT UPSHIFT UNDER HEAVY ACCELERATION; DISTINCT HESITATION WHEN ACCELERATING FROM 30-45MPH. NO MODEL YEARS LISTED. *PE
SI B12 01 08
Service Bulletin/Repair Instructions
N52 EDK THROTTLE JAMMING FAULTS 2D09, 2CED AND 2CEC. MODEL E90 AND E91 (3 SERIES) AND E60 AND E61 (5 SERIES), ALL MODELS UP TO 11/2005 WITH N52 ENGINE. *PE
SI B62 0406
Service Bulletin/Repair Instructions
INSTRUMENT CLUSTER: FAILURE OF DISPLAYS/FUNCTIONS. MODEL E60, E61 (5 SERIES) AND E63, E64 (6 SERIES). *PE
SIB-62-04-06
Service Bulletin/Repair Instructions
BMW: INSTRUMENT CLUSTER-FAILURE OF DISPLAYS/FUNCTIONS. TOTAL OR PARTIAL FAILURE OF DISPLAYS OR FUNCTIONS IN THE INSTRUMENT CLUSTER. THE DISPLAYS OR FUNCTIONS START WORKING AGAIN AFTER THE VEHICLE HAS BEEN PARKED (SLEEP MODE). INTERNAL ERROR IN THE PROCESSING OF INCOMING MESSAGES FROM THE K CAN BUS. THERE MAY BE VARIOUS CAN MESSAGE ERRORS STORED IN THE FAULT MEMORY. *PE
SI B65 25 07
Service Bulletin/Repair Instructions
RECODE OR REPLACE OC3 SEAT MAT. VEHICLES PRODUCED UP TO MARCH 31, 2005. *NJ
SIB-11-14-07
Service Bulletin/Repair Instructions
BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. IN ADDITION, THE COMPLAINTS OF A SLIGHT REDUCTION OF POWER SIMILAR TO AN INCREASED TURBO LAG. THE VACUUM SUPPLY TO THE WASTE GATES MAY BE RESTRICTED OR BLOCKED. NO MODEL YEARS LISTED. *PE
SIB-25-03-07
Service Bulletin/Repair Instructions
BMW VEHICLE: SPORT TRANSMISSION PADDLE SHIFTERS INOPERATIVE-DIAGNOSIS. THE DIRECT COMMUNICATION INPUT LINE BETWEEN THE PADDLE SHIFTERS AND THE EGS TRANSMISSION CONTROL MODULE IS INTERRUPTED. NO MODEL YEARS LISTED. *PE
SIB-34-07-07
Service Bulletin/Repair Instructions
BMW VEHICLE: DSC DISABLING FUNCTION. DUE TO REVISED DME, DSC AND CCC SOFTWARE, THE MDM (M DYNAMIC MODE) BUTTON LOCATED IN THE CENTER CONSOLE SWITCH CLUSTER (SZM) NOW HAS TRIPLE FUNCTIONALITY-DEFAULT STATE-DSC ON; SHORT PRESS-MDM ON (GREEN MDM INDICATOR DISPLAYED IN THE CLUSTER); PRESS AND HOLD-DSC OFF (YELLOW DSC INDICATOR DISPLAYED IN THE CLUSTER; MESSAGE APPEARS IN THE CONTROL DISPLAY). NO MODEL YEARS LISTED. *PE
120405
Service Bulletin/Repair Instructions
CHECK ENGINE LAMP ILLUMINATED AND/OR VEHICLE OVERHEATS. BMW E90 (3 SERIES) ALL E90 (3 SERIES) AND E60 (5 SERIES) MODELS EQUIPPED WITH N52 ENGINE. *TT
651201
Service Bulletin/Repair Instructions
CUSTOMERS MAY COMPLAIN OF A DISCHARGED BATTERY WITH THE ALPINE CD53 RADIO. *TT
000200
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEW VEHICLE PREPARATION AND MAINTENANCE REQUIREMENTS. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.