Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B611526
In vehicles equipped with the Roof Function Center “FZD‑21” variant, a quiescent‑current violation mayoccur if the system fails to enter sleep mode. When this sleep error is present, a remote software upgrade(RSU) may be aborted and the FZD can become degraded. The following Check Control Messages (CCMs) may be displayed: “Energy Management — Increased Energy Consumption While Parked.” “Software Upgrade Failed — Workshop Visit Required.”
B320526
“Cracking” noise might be heard when turning the steering wheel from lock to lock. See attached video V3202 26 EPS noise.
B340124
After replacement of the Integrated Braking system (IB)/Power Brake the total distance covered might belower than when handed over to the workshop for the repair.
B630526
After programming the vehicle via ISTA/RSUto I-level …26-03-5xx, some of the interiorambient lighting strips (arrows) may begin tofail sporadically after a deep sleep cycle.
B652026
The Central Information Display (CID) side of the Multifunction Display (MFD) may flicker intermittently. Theflickering manifests itself in three phases: The image is distorted The central information display turns black (black screen) The image is OK again The complete flickering episode with all the above-mentioned three phases only lasts about half a second intotal each time.
B120326
Due to an implementation error in various OBD diagnostics in the vehicle's control units, in very rare cases itmay happen that stored fault memory codes (DTCs) and the MIL (warning light) are not automaticallydeleted even though the underlying malfunction has already been rectified. This does not comply with the statutory OBD specifications.
B310626
Noises from the front axle when driving over rough road surfaces, or when turning.
B310526
“Popping” noise from the front axle when cornering and driving on uneven road surfaces.
B320326
“Groaning” noise from the EPS when the steering wheel is at the end stops.
B120526
A “knocking” sound from the fuel tank area can be heard in the passenger area. Occurrence information below. 1. The noise occurs when the engine is at idle 2. The noise occurs sporadically 3. The noise disappears when the fuel filler cap is opened 4. The noise also disappears when the tank ventilation valve is disconnected There is no relevant fault saved in the fault memory.
In-Vehicle-InApp-Comm
The water drain hose of the slide/tilt sunroof must be checked and, if necessary, re-attached. If the front left water drain hose is not connected, water can enter the footwell via the A-pillar and the carpet on the driver's side can soak up the water that has entered.
B060726
Wiring Harness Return
B160225
The assembly cover on the left side of the fuel tank may not have been properly plastic welded. Thiscould lead to a smell of fuel after refueling or service engine soon light (MIL) for an evaporative leakin the fuel system.
B060126
Power Kit Electronics Return
B540625
Through quality checks, it has been detected that the front left water drain hose for the slide/tilt sunroof isnot connected.
B121125
One or both of the following faults stored in the DME: 034AA5 - Mixture control bank 1, lambda regulation, mixture too lean 034AA8 - Mixture control bank 1, lambda adaptation, mixture too rich And additionally with the faults above, these affected vehicles may have one or more of the followingirregular combustion-related faults also stored: 033812 033813 033814 033815 033816 033817 033818 033819
B631025
RSU availability. The ambient lighting color cannot be saved permanently. The personalized color of the ambient lighting resets after the vehicle has gone to sleep.
B840625
In some situations, an emergency call may be triggered in the vehicle without either the customer pressing the SOS Call button, or an airbag deployment event. In some cases, the customer may not even be inside the vehicle.
B510325
The front and/or rear doors only close if increased force is exerted, or with increased closing speed.
B340825
Starting from I-level …24-07-500, it is possible that the Automatic Hold function is not automatically storedfor the next journey. The function must be activated again by the driver at the beginning of every trip. After asoftware update to 25-03-500 and higher, this occurs more frequently.
B320825
When the steering column is adjusted inwards towards the instrument cluster, the noise may occur near thelimit position.
B631023
Condensation is present in the inner surface in one or both (inner and/or outer) taillamps.
B064125
Seal Return
B063925
Adapter Disc Return
B610125
During highly dynamic driving, washer fluid may be forced out of the windshield washer nozzles. This canlead to the washer fluid reservoir being completely emptied.
B660325
Check control message is displayed indicating the parking assistance systems have limited functionality dueto errors detected within PDC sensors. The warning indicates parking assistance features have limitedfunctionality while the errors continue to be detected. Following faults may be stored 8031BA Ultrasonic Sensor Rear Side Left Software Error 8031CO Ultrasonic Sensor Rear outer left Software error 8031AE Ultrasonic Sensor Rear Outer Right Software Error 8031A8 Ultrasonic Sensor Rear Side Right Software Error 8031B4 Ultrasonic Sensor Rear Middle Right Software Error 8031C6 Ultrasonic Sensor Rear Middle Left Software Error
B410525
While attempting to fuel/charge the vehicle,the fuel/charge door will not open.
B120425
EMISSIONS RECALL 25E-A02: PROGRAM CONTROL UNITS
B340425
As a result of a data input error, certain fault memories are permanently stored. The permanent storage offault memories does not comply with the legal specifications of the authority (California Air Resources Board– CARB). The fault has no effect on the use of the vehicle by the customer.
B660725
The speed limit warning adopted speed, which is set by the customer, is automatically reverting to lowervalue after an extended duration of the sleep cycle.
B651525
When initiating a phone call to a specific saved contact, Intelligent Personal Assistant may not be able tolocate the contact or may call the incorrect contact.
B650925
Customer may complain that Projected Modes (Apple CarPlay/Android Auto) do not connect in the vehicle. Itis found that the WiFi in the vehicle is also not active and cannot be turned on.
B320225
Parts of the steering shaft universal joint may have been joined together without having beengreased. As a result, there can be audible squeaking and cracking noises. In some cases, moresteering force is required.
B513019
A groaning noise is present from the door frame of any door, most commonly when driving over rough roadsor during body flex. This situation may be worse in vehicles which are regularly waxed in th e area of the door jamb.
B630418
One or more of the LED daytime running lights are dim or discolored.
B240224
Due to a manufacturing issue, the torque on the bolts of the transmission Mechatronics was not carried outaccording to the specification. The faulty torquing can cause a malfunction within the transmission, and as a result, the emergencyoperation of the transmission.
B510224
A squeaking sound is heard when folding either of the exterior mirrors assemblies in or out
B513124
The clear coat on the carbon fiber MPerformance rear spoiler is delaminating.
B510824
The Augmented Reality Camera (ARCAM) shows up blurry when activated.
B520225
The electric front seat adjustment does not work. The problem can occur to the left, as well as the right seat.
B514616
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B110924
During manufacturing, the dual-mass flywheel has not been sufficiently greased. The insufficient grease may result in acoustic abnormalities and vibrations in the vehicle's powertrain.
B320125
Rumbling, groaning type noises from the EPS when the steering wheel is at the end stops.
B370125
DELIVERY STOP: SUSPENSION STRUT HOLDER
B512224
On the main door seal, detachment behavior can be detected in the sealing joint area. Overtime, the sealing material continues to detach more and more, which can cause the seal to dangle and become visible to the customer.
B511924
There is a matte “veil” or milky stain on the exterior mirror glass.
B611124
After performing a BMW Remote Software Upgrade (RSU), the functionality of the Comfort Access and Passive Go/Exit features may be reduced.
B610124
When driving over rough surfaces, a low-frequency rattling noise can be heard inside the vehicle's cabin. The noise typically sounds as though it is coming from the front right footwell area.
B068724
Spring Strut Return
B653624
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
B653824
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theater Screen is not possible
B840424
Customers may report issue with Personal eSIM operation, to include: Personal eSIM does not finish the set-up process in the vehicle Telephone function via eSIM is not possible WiFi Hotspot function cannot be used Streaming video service via the BMW Theatre Screen is not possible
B653524
Customers may report that the Central Information Display (CID) side of the Multifunction Display flickersonce on and off. This flickering is not continuous but may occur once every 15 to 50 seconds. No fault memory entry is stored for this customer complaint.
B068324
Wastegate Valve Actuator Return
B068224
Spring Strut Return
B160224
There may be a restriction in the low-pressure fuel line at the tank flange for the in-tank delivery pump (lowpressure pump). As a result, the required fuel flow volume is not available. If there is an insufficient supply offuel (even if only for a very brief period), the high-pressure pump might suffer preliminary damage. Inaddition, in the event of a fault, there might be a power reduction or “jerking” motions while driving.
B512724
The Ethernet bus of the Body Domain Controller (BDC) is interrupted so that audio output, rear viewcamera, or the driver assistance systems fail. The symptoms begin to appear during auto locking at approx.10 mph, or after the Central Locking button is activated. Dependent upon vehicle equipment, the following permanent SAE faults may be stored in the vehicle: S 0219, No Communication possible with: Amplifier S 0261, No Communication possible with: Camera-based driver assistance S 0273, No Communication possible with: Headunit S 0313, No Communication possible with: All-round vision camera S 0386, No Communication possible with: Instrument Panel S 0394, No Communication possible with: Telematics control unit
B340324
Improved diagnostic software for the brake system.
B612424
Small debris may accumulate inside the volume control thumbwheel of the iDrive Controller. Existing gaps between the glass application and the light guide could allow external debris to enter inside the volume thumbwheel under normal usage. This debris can be seen through the crystal volume thumbwheel, giving the appearance of a cosmetic defect with the thumbwheel itself. Active lighting makes this debris more visible when illuminated. This could make the false illusion of a cosmetically defective volume thumbwheel more visible (many small dark spots or streaks).
B511424
The hood is difficult to close, or may not close.
B630224
After programming the vehicle or completing aBMW RSU (Remote Software Upgrade), theblue accents (arrows) of both headlights arenot functioning.
B330224
When driving over a rough road surface (e.g., cobblestone or similar surfaces), a rattling noise may beheard from the rear axle. See attached video V33 01 24, raise your speaker volume.
B660424
The washer fluid cleaning system has air remaining in its components, and/or the fluid lines after a previous repair has been performed. The previous repair may have involved draining, opening, and replacingcomponents in the system.
B270220
There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads There are no warning lights or Check Control messages.
B651024
Quality improvements and robustness measures are to be implemented on the affected vehicles via thissoftware update. The software update improves functions in the following areas of the vehicle: Bluetooth malfunctions The start-up phase of the head unit (HU) has been shortened (faster start of the operating system) The number of disconnections from Apple CarPlay have been reduced Vehicle access and the drive-ready state have been improved The AC charging abort error has been fixed Remote Control Parking without function
B064724
Rear Carbon Spoiler Return
B651424
Intermittently the iDrive Controller may stop functioning. This applies to the iDrive Controller knob and alsothe iDrive Controller function buttons (NAV, MEDIA, TEL, etc.). The touch functions on the Multifunction Display and voice interactions through the Intelligent PersonalAssistant will still function normally.
B651224
The Central information Display (CID) screen goes black and the Headunit (HU-H3) resets sporadically.After a short period of time, the function of the CID and HU-H3 is available again. Additionally, fault code B7F8F9 – “HU-H: Reset” will be stored in the HU-H3. The issue may occur multiple times while driving longer distances. CAUSE Unfavorable
B064024
Steering Wheel Module Return
B640524
When the interior temperature of the vehicle is between 5 F (-15 C) and 23 F (-5 ), the defroster function is limited; and the interior doesnâÃÂÃÂt heat up quickly enough.
B170224
The following fault is stored in the DME during the pre-delivery inspection (PDI, aka Quality Certification 1,QC1): 224123 âÃÂàCoolant pump for low-temperature cooling circuit, internal test: Blockage detected
B520224
The seat initialization and memory has been lost; Or Repeat failure of seat initialization after completing the test module via ISTA. One or both of the following check control messages (CCM) may be present: CCM 108 âÂÂDriver restraint systemâ CCM 109 âÂÂPassenger restraint systemâÂÂ
B640424
1. The center air vent on the left (a) is closed. All other air vents on the left side then only blow cold air intothe passenger area. OR 2. Both center (b) air vents are closed. All other air vents then only blow cold air into the passenger area. OR 3. The center air vent on the right (c) is closed. All other air vents on the right side then only blow cold airinto the passenger area.
B510819
The basic conditions for initializing the power windows are not met.
B611305
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B160623
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B653423
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
B661523
Emergency Stop Assistant is activated. Thisicon will appear in the CID when this function is activated.
B521513
Once the rear seat heating has been activated via voice control, the seat heating can no longer be adjusted manually using the control panel of the automatic rear air conditioning.
B631223
Upon performing a vehicle read out, faultcode (CD0D16- Control unit light (BEL)(LIN): Wrong variant installed) is stored inthe BCP (Basic Central Platform). Note: Functionality of the exterior lights and switch is fully operational when fault code is present.
B511123
The tailgate/trunk will not unlatch or open whensignaled via the interior button (driverâÃÂÃÂs door panel)or the key fob.
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.