Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B011724
Warranty Program/Extension
The Fuel Injector Condition-Specific Repair Coverage Program applies to qualifying repairs for the required replacement of one or more the fuel injectors which were determined to have failed due to a buildup of external corrosion in the engine’s center fuel injector bore area that resulted after this location was periodically contaminated by engine coolant residue over time. This special program’s coverage is 15 years / 150,000 miles as determined from the vehicle's original in-service / first delivery date.
B630418
Service Bulletin/Repair Instructions
One or more of the LED daytime running lights are dim or discolored.
B510819
Service Bulletin/Repair Instructions
The basic conditions for initializing the power windows are not met.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B360121
Service Bulletin/Repair Instructions
At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic acknowledgement (clunk) as seen at the 11 second mark of the video. See attached video V36 01 21.
B160123
Service Bulletin/Repair Instructions
A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a âÃÂÃÂlarge leak,âÃÂàafter confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
B610524
Service Bulletin/Repair Instructions
The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 ÃÂâÃÂÃÂÃÂàÃÂâÃÂÃÂÃÂÃÂHU-H: ResetÃÂâÃÂÃÂÃÂàwill be stored in the HU-H3.
B320223
Service Bulletin/Repair Instructions
SITUATION Unusual noises occur only when operating the steering column in the axial direction. 1. A one-time thump sound at the start of movement Shortly after the steering column starts moving, retracting, or extending, a one-time thump noise is heard. See attached video V32 03 23 2. Humming noise while steering column extends in the axial direction. The sound is only heard when the steering column is extended, not when the steering column is retracted. When the steering column starts to move in the extended direction, the humming noise can be heard. See attached video V32 04 23
B160623
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B653423
Service Bulletin/Repair Instructions
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
B011423
Service Bulletin/Repair Instructions
PRESSURE CONTROL VALVE (PCV) EXTENDED LTD WTY 15 YEARS/150,000 MILES
B612823
Service Bulletin/Repair Instructions
A thumping sound is heard when the window reaches the closing end stop.
B631323
Service Bulletin/Repair Instructions
The carpet welcome light(s) turns on either after a delay, or does not function at all.
B631123
Service Bulletin/Repair Instructions
Moisture is visible in one or both of the Daytime Running Light (DRL) headlights.
B520121
Service Bulletin/Repair Instructions
?The front seat will not calibrate/initialize, and the stored faults cannot be deleted.
B540521
Service Bulletin/Repair Instructions
?The sunroof will not operate in either direction.
B090221
Service Bulletin/Repair Instructions
With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service Pack 15 vehicles may receive new functionality or modifications in their features.
B320420
Service Bulletin/Repair Instructions
A groaning type noise is heard during the height adjustment.
B611320
Service Bulletin/Repair Instructions
In the event of an accident, the two-battery Dual Storage System (DSS) is disconnected from the electrical system via an internal relay.
B630821
Service Bulletin/Repair Instructions
Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permitted short circuit cycles exceeded
B640821
Service Bulletin/Repair Instructions
The air conditioning cycles from cold to warm air while driving or while at a stand still. The vent outlet temperatures vary by 25 degrees Fahrenheit or more (38 F to 60 F +) without changing any climate control settings.
B514616
Service Bulletin/Repair Instructions
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B610123
Service Bulletin/Repair Instructions
Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.
B651523
Service Bulletin/Repair Instructions
After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.
SIB660823
Service Bulletin/Repair Instructions
Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the customer KAFAS camera system cannot be activated due to system restrictions that are not clear to the customer Road signs are sporadically not detected.
B260422
Service Bulletin/Repair Instructions
There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving after a cold start, when the outside temperature is 32 F (0 C) or lower.
B651623
Service Bulletin/Repair Instructions
Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn indicators, acoustic signals) may also have failed.
B840822
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
B841422
Service Bulletin/Repair Instructions
Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).
SIB510223
Service Bulletin/Repair Instructions
POPPING SOUND AT THE TOP OF THE C-PILLAR
SIB260422
Service Bulletin/Repair Instructions
Engine Variants Updated.
B110417
Service Bulletin/Repair Instructions
The coolant lines routed to the exhaust turbochargers may develop an external coolant leak.
B122519
Service Bulletin/Repair Instructions
After an automatic engine start (MSA start), the transmission intermittently goes into the Park "P" or Neutral "N" position without any customer influence.
B170617
Service Bulletin/Repair Instructions
Coolant leaking from the engine compartment. Traces of coolant leaking from the expansion tank of the low temperature cooling system.
B240222
Service Bulletin/Repair Instructions
A cracking, metallic noise from under the center of the vehicle.
B612922
Service Bulletin/Repair Instructions
The saved steering column positions, vertical and horizontal, are not stored long term.
B613322
Service Bulletin/Repair Instructions
Due to a software error, Remote Software Upgrade (RSU) and Remote Support are currently not possible. Additionally, the Integrated Owner's Handbook cannot be displayed.
B662419
Service Bulletin/Repair Instructions
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.
SIB650922
Service Bulletin/Repair Instructions
The sound output intermittently drops out entirely. This can be reproduced with all audio sources as well as telephone and voice output.
SIB010522
Service Bulletin/Repair Instructions
Component-Specific Limited Warranty Extension For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's front and rear air suspension strut assemblies (item # 1 Front and # 2 Rear, shown) to: 8 years/80,000 miles, as determined by the vehicle's original in-service date. Other air suspension system-related components/issues are excluded from this coverage. This component-specific limited warranty extension applies to defects in materials or workmanship. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks.