MCAS2026
Other
Hose Set Idle Actuator Return
Vehicle report
2009 BMW F 650 GS
Service bulletins
14 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
MC610321
Service Bulletin/Repair Instructions
The motorcycle will not start. The vehicle battery is empty even though the battery charger was permanently connected to the 12V power socket.
MC55297495
Service Bulletin/Repair Instructions
Vehicle battery not charged despite the battery charger being connected to the on-board socket (manufactured before 2009)Headlights and rear lights light up intermittently despite the ignition being switched off and the battery charger being connected to the on-board socket.
MC210221
Service Bulletin/Repair Instructions
The clutch plates do not tolerate frequent and prolonged operation at the clutch friction zone, causing a shorter service life in motorcycles that see intensive use
MC610208
Service Bulletin/Repair Instructions
The wiring harness of the F 650 GS and F 650 GS Dakar (R13) models is routed along the right-hand top rail of the frame. Weld spatter on the frame and/or adverse routing in the vicinity of the banjo bolt of the hydraulic spring base adjuster can result in the chafing of the wiring harness.
MC59759165
Service Bulletin/Repair Instructions
Transmission rattles when the engine is at operating temperature and idling.
MC62332524
Service Bulletin/Repair Instructions
Occasionally it's not possible to downshift the transmission; especially from 3rd to 2nd gear.
MC53055102
Service Bulletin/Repair Instructions
Gear lever does not return to neutral position. Uneven faces on shifting pawl.
MC51142327
Service Bulletin/Repair Instructions
Leaks have been reported in fork legs. The cause is reported be from oil lubricating film with accompanying dirt/grease ring is incorrectly interpreted to be a leaking fork leg. Investigations have shown that the part is not defective.
MC1965083203
Service Bulletin/Repair Instructions
Oil leaking from around the oil sump gasket.
SIB-11-03-08
Service Bulletin/Repair Instructions
BMW: CRANKCASE PRESSURE DIAGNOSIS AND INFORMATION FOR ALL VEHICLES. *RM UPDATED ON 4/24/2013. *KB
SIB-63-02-01
Service Bulletin/Repair Instructions
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
SIB-16-02-09
Service Bulletin/Repair Instructions
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.