Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B611305
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
MC330423
Since October 2023, a new maintenance schedule is valid for all K5x models. For the first time, maintenance positions for the cardan shaft (Driveshaft) are included. NOTICE: 1. The new maintenance schedule is not limited to vehicles affected by the SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), but is valid for all K5x models - including retroactively. In case of retroactive validity (model year 2023 and older), affected customers will be informed about the change. This will be in the form of a direct-to-customer letter with a description of the new maintenance schedule, specific ownerâÂÂs manual insert, and consumer warranty book insert. 1. For vehicles affected by SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), this service action must be performed first. All conditions described in this bulletin apply after the open Service Action has been completed. No additional communication is required for K5x models model year 2024 and onwards. Those models have the new maintenance schedule in their ownerâÂÂs manual.
MC160214
BMW Motorrad USA has become aware of a potential durability issue with the film type fuel level sender âÂÂFuel Stripâ equipped on certain model year 2005 to 2013 R and K series motorcycles.
MC000222
BMW Motorrad is aware of a number of cases in which the screw connections of the Paralever link and/or the rear brake caliper have loosened in customer vehicles while driving.
MC000521
One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.
MC610315
BMW Motorrad has ascertained that in isolated cases the fuse for the voltage regulator is not correctly secured in the holder by the threaded fasteners.
MC610821
When diagnosing fault codes (0x3A13D7, 0x3A13D9), technicians erroneously condemn the electronic throttle grip, which analyses show is rarely the culprit.
MC660118
The bike does not shut down with a short press of the keyless ride button. The keyless Ride button must be pressed for several seconds to shut the bike down
MC64465398
The hill start control operation may be sporadic.
MC63876474
Various malfunctions in Navigator VI GPS due to older software which requires update.
MC63849336
Faulty data means that the programming of the BMS-X at I level K001-17-11-500 is prevented for these vehicles.The faulty I level is expected to be rolled out to the trade with ISTA 4.08 and ISTA/P 3.63.1 from 08.11.2017.
SIM010717
The engine?s intake charge-air duct limited warranty extension to 10 years/120,000 miles applies to ?eligible USspecification
MC3300317
In November of 2017 BMW Motorrad updated the rear drive for the K5X model line, as a result longer bolts will be used for the rear brake caliper mounting. Vehicles affected K5x motorcycles produced before and up to 10/31/2017, in the event the rear drive needs replaced or the rear brake caliper is removed and installed.
MC62335843
After turning ignition key on and first scroll through of the Board Computer (BC), all menu items are displayed. When a scond scroll through is done th abmient tempertuire and average speed displays are missing. Only range and average consumption are displayed.
MC59823415
Oil leak immediately after replacing cylinder head cover seal set.
SIB-16-002-14
BMW MC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE WARRANTY EXTENSION, WITH OUT MILEAGE LIMITATIONS, TO 12 YEARS DUE TO A POTENTIAL DURABILITY ISSUE WITH FILM TYPE FUEL LEVEL SENDER FUEL STRIP. MODEL 2005-2013 R, K SERIES. *PE
MC5382641801
R1200R has no fuel level or engine temperature display despite having an on-board computer
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.