Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B611305
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
MC330423
Since October 2023, a new maintenance schedule is valid for all K5x models. For the first time, maintenance positions for the cardan shaft (Driveshaft) are included. NOTICE: 1. The new maintenance schedule is not limited to vehicles affected by the SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), but is valid for all K5x models - including retroactively. In case of retroactive validity (model year 2023 and older), affected customers will be informed about the change. This will be in the form of a direct-to-customer letter with a description of the new maintenance schedule, specific ownerâÂÂs manual insert, and consumer warranty book insert. 1. For vehicles affected by SI 33 02 22 (SERVICE ACTION: Swingarm Drain retrofit and Driveshaft Check), this service action must be performed first. All conditions described in this bulletin apply after the open Service Action has been completed. No additional communication is required for K5x models model year 2024 and onwards. Those models have the new maintenance schedule in their ownerâÂÂs manual.
MC160214
BMW Motorrad USA has become aware of a potential durability issue with the film type fuel level sender âÂÂFuel Stripâ equipped on certain model year 2005 to 2013 R and K series motorcycles.
SIB330222
Multiple factors may cause the driveshaft to become damaged; among them are corrosion in certain parts of the driveshaft, and wear and tear exacerbated by certain climatic conditions.
MC3300317
In November of 2017 BMW Motorrad updated the rear drive for the K5X model line, as a result longer bolts will be used for the rear brake caliper mounting. Vehicles affected K5x motorcycles produced before and up to 10/31/2017, in the event the rear drive needs replaced or the rear brake caliper is removed and installed.
SIB-16-002-14
BMW MC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE WARRANTY EXTENSION, WITH OUT MILEAGE LIMITATIONS, TO 12 YEARS DUE TO A POTENTIAL DURABILITY ISSUE WITH FILM TYPE FUEL LEVEL SENDER FUEL STRIP. MODEL 2005-2013 R, K SERIES. *PE
SIB-11-03-08
BMW: CRANKCASE PRESSURE DIAGNOSIS AND INFORMATION FOR ALL VEHICLES. *RM UPDATED ON 4/24/2013. *KB
SIB-63-02-01
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
SIB-16-02-09
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE
SB-22768813-01
BMW MOTORCYCLE: TEMPORARY OR SPORADIC FLAT SPOT WHEN ACCELERATING FROM CRUISE AT ABOUT 75MPH. SOMETIMES THERE IS A LITTLE HESITATION NOTICED. PROBLEM OCCURS ESPECIALLY AT HIGH TEMPERATURES AND LOWER FUEL QUALITY. PROBLEM WAS NOTICED AFTER UPDATE REGARDING THE KNOCKING CONTROL. E SERIES (K25; K25/02; K25/03; K25/11; K25/12; K25/HP; K26; K26/02; K27; K28). *PE
SB-17927831-02
BMW MOTORCYCLE: WHEEL SPEED DEPENDENT, CLEARLY AUDIBLE CLANKING NOISE OCCURS WHEN BRAKING TO ADJUST SPEED. E SERIES (K25; K25/02; K25/03; K25/11; K25/12; K25/HP; K26; K27; K28; K29; K29/HP; K40; K41; K43; K43/HV; K44; K589/03; K71). NO MODEL YEARS LISTED. *PE
SB-00-021-07
BMW MOTORCYCLE: ENGINE FUELS CONTAINING ETHANOL. BMW MOTORRAD HAS NO OBJECTION TO THE USE OF SI ENGINE FUELS CONTAINING UP TO A MAXIMUM OF 10% ETHANOL AND IMPOSES NO WARRANTY RESTRICTIONS. ETHANOL MIXTURES IN PROPORTIONS HIGHER THAN 10% CAN HAVE AN ADVERSE EFFECT ON PERFORMANCE AND CAN RESULT IN DAMAGE TO COMPONENTS THAT COME INTO CONTRACT WITH FUEL. NO WARRANTY CLAIMS WHATSOEVER FOR DAMAGE CAUSED IN THIS WAY WILL BE ACCEPTED. NO MODEL YEARS LISTED. *PE
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.