B010224
Warranty Program/Extension
The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.
Vehicle report
2022 BMW X1
Service bulletins
53 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B061726
Other
Turbocharger Return
InVeh-InApp-Comm
Over The Air
Residues from the production process may be present on the Frontal Light Electronics circuit board. This could result in the failure of a lighting function (e.g. daytime driving lights, low-beam headlight, turn indicators) on the affected side in the front area. In the event of a fault, you will be informed by a Check Control message. The front light module will be replaced.
B310122
Service Bulletin/Repair Instructions
During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/orouter CV boots.
B065525
Other
Gasket Set Return
B651825
Service Bulletin/Repair Instructions
When the alarm system is activated and doors are locked, within a short period the doors will unlock, and a “double beep” acoustic confirmation is heard from vehicle.
B120425
Emissions
EMISSIONS RECALL 25E-A02: PROGRAM CONTROL UNITS
B660625
Service Bulletin/Repair Instructions
In rare occasions the “Active Cruise Control” is deactivated automatically while driving, and a white CheckControl Message (number 914) appears “Limited Driver Assistance”. In addition, the following fault codes are generated: 030845 - Cruise control with brake function not available 030847 - Active Cruise Control function not available This symptom can occur if the accelerator pedal is actuated very lightly when “Active Cruise Control” isswitched on while the vehicle switches to overrun mode. As the result “Active Cruise Control” driver assistance may be deactivated in individual cases.
B513019
Service Bulletin/Repair Instructions
A groaning noise is present from the door frame of any door, most commonly when driving over rough roadsor during body flex. This situation may be worse in vehicles which are regularly waxed in th e area of the door jamb.
B340425
Service Campaign
As a result of a data input error, certain fault memories are permanently stored. The permanent storage offault memories does not comply with the legal specifications of the authority (California Air Resources Board– CARB). The fault has no effect on the use of the vehicle by the customer.
B280123
Service Bulletin/Repair Instructions
Check control message (790) “Emergency gearbox release activated” is displayed immediately after starting the engine. This applies only to U11 equipped with the 7-speed M-DCT transmission.
B613024
Service Campaign
Due to a software error in the Basic Central Platform (BCP), Remote Software Upgrade (RSU) is no longerpossible.
B840324
Service Bulletin/Repair Instructions
The “End of life” or “Emergency call system error” Check Control message appears in the vehicle. The following fault memory entry is stored: B7F341 – Emergency battery: Hardware faulty
B651024
Service Campaign
Quality improvements and robustness measures are to be implemented on the affected vehicles via thissoftware update. The software update improves functions in the following areas of the vehicle: Bluetooth malfunctions The start-up phase of the head unit (HU) has been shortened (faster start of the operating system) The number of disconnections from Apple CarPlay have been reduced Vehicle access and the drive-ready state have been improved The AC charging abort error has been fixed Remote Control Parking without function
B280224
Service Bulletin/Repair Instructions
Micro-movements combined with frictional corrosion can increase wear on the longitudinal splined connection between the double clutch transmission (DCT) and the transfer box.
B610323
Service Bulletin/Repair Instructions
The buttons on the GWS do not work, or the function indicator lighting has failed. One or more of the following faults are saved in the fault memory for the GWS : 80268E - Park button sticking and/or 80268F - Parking button defective and/or 802680 - Functional display defective and/or 802681 - Locator lighting defective and/or 802691 - Release button fault
B511024
Service Bulletin/Repair Instructions
The tailgate sporadically fails to open when signaled via- The interior button (driverâÂÂs door panel) Button on key fob The switch on the tailgate (inside or outside) In some cases, the tailgate will release and open only a short distance before stopping.
B410523
Service Bulletin/Repair Instructions
Contact between the taillamps and the tailgate/side panel(s) can occur. This can cause paint abrasion, and over time corrosion can form on the body of the vehicle/tailgate. Note: This can occur on either one or both sides of the vehicle.
B640416
Service Bulletin/Repair Instructions
Customer complains of a musty odor or damp front footwell carpet.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B521723
Service Bulletin/Repair Instructions
Customer states one of the front seats is inoperative. The seat heater and power supply are inoperative. During the vehicle test, the seat module does not respond. The power supply fuse for the seat module isfound to have blown.
B160623
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B612723
Service Bulletin/Repair Instructions
When using the Key Reader to retrieve CBS information from the customer key, no current vehicle data is available, or the data does not match the maintenance schedule.
B653423
Service Bulletin/Repair Instructions
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
B120723
Service Bulletin/Repair Instructions
Vehicle exhibits a slight acceleration delay when taking off from a MSA (automatic engine start-stopfunction) stop.
B612123
Service Bulletin/Repair Instructions
The steering wheel heating takes a long time to achieve the desired temperature.
B513218
Service Bulletin/Repair Instructions
The paint finish on the door jamb (above the door striker) is scratched due to the inner door cavity window seal.
B511923
Service Bulletin/Repair Instructions
When opening the front door(s), a âÃÂÃÂclackingâÃÂàsound is heard.
B660523
Service Bulletin/Repair Instructions
Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
B511123
Service Bulletin/Repair Instructions
The tailgate/trunk will not unlatch or open whensignaled via the interior button (driverâÃÂÃÂs door panel)or the key fob.
B631023
Service Bulletin/Repair Instructions
?Condensation is present in the inner surface in one or both (inner and/or outer) taillamps.
B120223
Service Bulletin/Repair Instructions
Due to a manufacturing defect in the ignition coil BMW AG has issued a Delivery Stop (effective June 1, 2023) on a small number of Model Year 2023 - 2024 BMW vehicles.
B120323
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop effective June 6, 2023 on certain Model Year 2023 - 2024 BMW vehicles that were produced between October 26, 2022 and May 8, 2023.
B520723
Service Bulletin/Repair Instructions
The front seat heating does not heat up after vehicle departure with the climate control in the automatic mode.
B514616
Service Bulletin/Repair Instructions
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B630623
Service Bulletin/Repair Instructions
Contact between the headlamp housing and the front fender can occur, causing paint abrasion.
B651523
Service Bulletin/Repair Instructions
After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.
B661023
Service Bulletin/Repair Instructions
After programming to I-level 23-03-5xx, the fault memory 0x022270 is stored in the mPAD (Medium Platform Automatic Driving) and cannot be deleted. A Check Control message "Driver assistance" is displayed in the central information display.
SIB160323
Service Bulletin/Repair Instructions
Engine cranks but will not start.
SIB630123
Service Bulletin/Repair Instructions
The following headlight CC messages are displayed: 128 "Left high beam headlight faulty" 130 "Right high beam headlight faulty" The following fault codes are stored during a vehicle test: 805A22- MLC: Communication fault timeout FLM-03 left 805BA2- MLC: Communication fault timeout FLM-03 right
B510323
Service Bulletin/Repair Instructions
While driving on rough roads, a knocking sound can be heard coming from top of the instrument panel (aka dashboard) in the bulkhead area.
B510423
Service Bulletin/Repair Instructions
Black resin is leaking from below the outside door handle(s).
B520423
Service Bulletin/Repair Instructions
The seat module control unit controls the seat functions. A software error can lead to the loss of the initialization function.
B651623
Service Bulletin/Repair Instructions
Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn indicators, acoustic signals) may also have failed.
B840822
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
B160223
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) when diagnosing with ITSA.
B630123
Service Bulletin/Repair Instructions
The following headlight CC messages are displayed: 128 Left high beam headlight faulty 130 Right high beam headlight faulty; The following fault codes are stored during a vehicle test: 805A22- MLC: Communication fault timeout FLM-03 left 805BA2- MLC: Communication fault timeout FLM-03 right.
B512322
Service Bulletin/Repair Instructions
When starting the vehicle remotely, the radiator blind of the active air flap control remains closed. This results in inadequate climate control in the vehicle interior.
B613222
Service Bulletin/Repair Instructions
The Smart Opener (SMO) "kick" function must be repeated several times to open or close the rear tailgate. In some cases, unintentional opening or closing of the tailgate may occur.
B220222
Service Bulletin/Repair Instructions
During a vehicle inspection and/or while addressing a customer's concern, the engine stabilizer bar/link appears to be worn.
B220322
Service Bulletin/Repair Instructions
During load reversal or taking off from a stop, there is a creaking or droning noise heard from the lower engine area.
B612622
Service Bulletin/Repair Instructions
When signaling the vehicle to open the tailgate, the tailgate will only open a few millimeters.
SIB840622
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. For this purpose the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.