B630526
Service Bulletin/Repair Instructions
After programming the vehicle via ISTA/RSUto I-level …26-03-5xx, some of the interiorambient lighting strips (arrows) may begin tofail sporadically after a deep sleep cycle.
Vehicle report
2024 BMW X3
Service bulletins
59 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B651926
Service Bulletin/Repair Instructions
Activation of the BMW Intelligent Personal Assistant voice is not possible via the Multifunction Steering Wheel (MFL) button and/or via the Central Information Display (CID). Intelligent voice control via the wake-up word “Hey BMW” is possible.
B120326
Emissions
Due to an implementation error in various OBD diagnostics in the vehicle's control units, in very rare cases itmay happen that stored fault memory codes (DTCs) and the MIL (warning light) are not automaticallydeleted even though the underlying malfunction has already been rectified. This does not comply with the statutory OBD specifications.
B010324
Warranty Program/Extension
The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.
B641224
Service Bulletin/Repair Instructions
1. Use of aftermarket accessory hang-on cellular phone holders and/or air fresheners can break the instrument panel air vent slats. Damage and/or issues caused by outside influences are not covered under the BMW limited warranties. Originally, the air vent slats were only repairable by replacing the entire front center dash vent assembly; which in some applications, also included the IHKA control module.
B062026
Other
KLE Control Unit Return
B310126
Service Bulletin/Repair Instructions
When driving over an uneven road surface, a “thumping” noise can be heard from the front axle. Seeattached video V 31 01 26. Under certain weather conditions, a “groaning” noise may be heard during steering movements
B061326
Other
Auxiliary Water Pump Return
B060926
Other
Set of Insert Return
B061126
Other
Edge Trim Return
InVehicle-InApp-Comm
Over The Air
The ACSM control unit, which controls the driving safety and driving dynamics sensor system, may be faulty. Cracks could have formed on the printed circuit board during production. In very rare cases, the crack can enlarge due to mechanical load and lead to failure of the control unit. In this case, the driver will be informed accordingly by various warning displays about the failure and deactivation of the driving safety functions as well as restricted driving dynamics functions.
B065925
Other
Left Door Cover Return
B510925
Service Bulletin/Repair Instructions
Oxidation/corrosion on the tailgate latch electrical connector and/or mechanical cable. This is caused by pressure washing the tailgate for a long period of time at close distance, resulting in water entering the vehicle through the gaps of the tailgate.
B661323
Service Bulletin/Repair Instructions
Various Check Control messages (CCM) can be displayed to the customer, which indicate a restricted function or an unavailability of the driver assistance systems or driver assistance functions. During the diagnosis, the following fault memory entries are entered individually or in combination: 800AC4 - Camera calibration failed 800AC8 - Permanent calibration error 800A24 - Temporary software fault 800ABE - KAFAS camera: Field of view permanently faulty This only affects vehicles with the following optional equipment: 5AU Driving AssistantProfessional.
B540525
Service Bulletin/Repair Instructions
A “popping” sound is heard coming from the Roof/B-pillar area when driving over small driveway curbs.
B840625
Service Bulletin/Repair Instructions
In some situations, an emergency call may be triggered in the vehicle without either the customer pressing the SOS Call button, or an airbag deployment event. In some cases, the customer may not even be inside the vehicle.
B065325
Other
Front Bumper Trim Return
B340825
Service Bulletin/Repair Instructions
Starting from I-level …24-07-500, it is possible that the Automatic Hold function is not automatically storedfor the next journey. The function must be activated again by the driver at the beginning of every trip. After asoftware update to 25-03-500 and higher, this occurs more frequently.
B064125
Other
Seal Return
B063925
Other
Adapter Disc Return
B063725
Other
Storage Net Return
B120125
Emissions
EMISSIONS RECALL 25E-A03: PROGRAM CONTOL UNITS (DME)
B840225
Service Bulletin/Repair Instructions
When making phone calls via BMW Bluetooth (not Apple CarPlay) in the vehicle, the person in the calloutside the vehicle hears a distorted voice reproduction.
B320425
Service Bulletin/Repair Instructions
After prolonged straight-ahead driving (e.g. highway driving), there may be a temporary, slightly noticeable increase in steering forces when steering out of the steering wheel center position. This minimally noticeable increase in steering forces is perceived as a slight, brief resistance. After overcoming this brief resistance when steering out of the steering wheel center position, no permanent increase in steering forces is noticeable.
B320525
Service Bulletin/Repair Instructions
“Knocking/thumping” noise during steering wheel movements and returning to the center position. See attached video V32 05 25 Column noise.
B340625
Service Bulletin/Repair Instructions
Brake “groaning” noises heard at the rear axle at slow speeds, i.e. close to standstill, stop and go driving;when parking or maneuvering.
B630418
Service Bulletin/Repair Instructions
One or more of the LED daytime running lights are dim or discolored.
B320325
Service Bulletin/Repair Instructions
Customer states that the steering wheel heating is inoperative. Fault code “30490 Missing LIN slave” is stored in Body Domain Controller.
B640125
Service Bulletin/Repair Instructions
The customer may hear an intermittent “humming” or “foghorn” type sound in vehicle. It sounds like a lowhum that last for only a few seconds. This can occur with the engine operating or may be heard for up to one hour after engine shut down.
B510224
Service Bulletin/Repair Instructions
A squeaking sound is heard when folding either of the exterior mirrors assemblies in or out
B514616
Service Bulletin/Repair Instructions
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B060525
Other
Door Trim Return
B320125
Service Bulletin/Repair Instructions
Rumbling, groaning type noises from the EPS when the steering wheel is at the end stops.
B512224
Service Bulletin/Repair Instructions
On the main door seal, detachment behavior can be detected in the sealing joint area. Overtime, the sealing material continues to detach more and more, which can cause the seal to dangle and become visible to the customer.
B653524
Service Bulletin/Repair Instructions
Customers may report that the Central Information Display (CID) side of the Multifunction Display flickersonce on and off. This flickering is not continuous but may occur once every 15 to 50 seconds. No fault memory entry is stored for this customer complaint.
B068324
Other
Wastegate Valve Actuator Return
B240324
Service Bulletin/Repair Instructions
Electric driving: A power reduction while electric driving Electric driving is not possible even though the high voltage (HV) battery is sufficiently charged Starting of the internal combustion engine (ICE): There is a noticeable cutting in of the ICE when it starts The cutting in of the ICE is slower Check Control Message (#2390): “Engine is starting… Please wait.” The possibility of the electric drive not starting the ICE Hybrid Driving: Reduced acceleration Jolts during upshifts Delays during downshifts Possible stored fault codes- EGS-EME: 039A2A – EGS-EME, temperature sensor, coolant: Excess temperature 039A2B – EGS-EME: Excess temperature BA0842 – EGS-EME, temperature sensor, coolant circuit: upper threshold value exceeded BA0845 – EGS-EME, temperature sensor, coolant circuit: Gradient implausible DME: 034D5C – Cooling failed: Inverter
B310524
Service Campaign
DELIVERY STOP: REPLACE WISHBONE HEXAGON NUT
B641024
Service Campaign
DELIVERY STOP: COOLANT LINE
B512724
Service Bulletin/Repair Instructions
The Ethernet bus of the Body Domain Controller (BDC) is interrupted so that audio output, rear viewcamera, or the driver assistance systems fail. The symptoms begin to appear during auto locking at approx.10 mph, or after the Central Locking button is activated. Dependent upon vehicle equipment, the following permanent SAE faults may be stored in the vehicle: S 0219, No Communication possible with: Amplifier S 0261, No Communication possible with: Camera-based driver assistance S 0273, No Communication possible with: Headunit S 0313, No Communication possible with: All-round vision camera S 0386, No Communication possible with: Instrument Panel S 0394, No Communication possible with: Telematics control unit
B652624
Service Bulletin/Repair Instructions
A check control message (CCM) for the restraint system (Air bag) appears. In the instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: Short circuit to negative terminal 93094F - Knee airbag, front passenger: Short circuit to negative terminal 93094C - Knee airbag driver's side: Resistance too great 930952 - Knee airbag, front passenger: Resistance too great
B310122
Service Bulletin/Repair Instructions
During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/or outer CV boots.
B512024
Service Bulletin/Repair Instructions
Distorted sound coming from the front and rear door panel speakers when the volume is adjusted high.
B541119
Service Bulletin/Repair Instructions
This bulletin outlines known areas of possible water entry, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints from the roof area. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the panoramic sunroof of BMW Sports Activity Vehicles which have quality improvement measures already in place.
B410722
Service Bulletin/Repair Instructions
While driving the vehicle on normal roads at10mph and above, a "cracking" sound fromthe top of the B-pillar(s) is heard.
B310624
Service Campaign
DELIVERY STOP: REPLACE TENSION STRUT HEXAGON NUT
B540124
Service Campaign
Incorrect evaluation of the camera system at the manufacturer. It was not recognized that the drain tubes forthe panoramic sunroof were not connected to the sunroof inner frame (aka “cassette”) at the front of thevehicle. If the drain tubes are not connected to the sunroof cassette, it is possible for water to enter the front footwell of the vehicle.
B270220
Service Bulletin/Repair Instructions
There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads There are no warning lights or Check Control messages.
B650121
Service Bulletin/Repair Instructions
No Bass or a cracking noise can be heard from the bass speakers.
B650421
Service Bulletin/Repair Instructions
A rattling/ droning noise is heard in the vehicle interior when the air conditioning (AC) is activated. Vibrationsare felt in the driver’s footwell.
B651224
Service Bulletin/Repair Instructions
The Central information Display (CID) screen goes black and the Headunit (HU-H3) resets sporadically.After a short period of time, the function of the CID and HU-H3 is available again. Additionally, fault code B7F8F9 – “HU-H: Reset” will be stored in the HU-H3. The issue may occur multiple times while driving longer distances. CAUSE Unfavorable
B510819
Service Bulletin/Repair Instructions
The basic conditions for initializing the power windows are not met.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B310124
Service Bulletin/Repair Instructions
With the vehicle is on a lift and the front struts are in the extended position, there may be a cracking and orclicking type noise when turning the steering wheel left/right. See attached video V31 01 24. The sound can reoccur when the vehicle is lowered, and the wheels are once again under load. The noise might also be heard for a short time while driving.
B160123
Service Bulletin/Repair Instructions
A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a âÃÂÃÂlarge leak,âÃÂàafter confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
B320523
Service Bulletin/Repair Instructions
The bolting of the sensor housing on the steering gear may not have been carried out correctly. The originalbolting may cause a low offset in the sensor signal and result in a noticeable asymmetry of the steering assistance.
B521823
Service Bulletin/Repair Instructions
A noise can be heard from underneath the seat while the seat is being moved either forwards or backwards. This can occur to the driverâÂÂs and/or the passengerâÂÂs front seat.
B653323
Service Bulletin/Repair Instructions
Due to an improper process during vehicle production, the roof-mounted antenna housing may not be correctly affixed to the roof, and water could enter the vehicle.
B540421
Service Bulletin/Repair Instructions
This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.