B010324
Warranty Program/Extension
The EVAP systems purge (vent) valve limited warranty for defects in materials and / or workmanship has been extended to 15 years / 150,000 miles as determined from the original first in-service / delivery date.
Vehicle report
2022 BMW X4
Service bulletins
77 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B641224
Service Bulletin/Repair Instructions
1. Use of aftermarket accessory hang-on cellular phone holders and/or air fresheners can break the instrument panel air vent slats. Damage and/or issues caused by outside influences are not covered under the BMW limited warranties. Originally, the air vent slats were only repairable by replacing the entire front center dash vent assembly; which in some applications, also included the IHKA control module.
B661323
Service Bulletin/Repair Instructions
Various Check Control messages (CCM) can be displayed to the customer, which indicate a restrictedfunction or an unavailability of the driver assistance systems or driver assistance functions. During the diagnosis, the following fault memory entries are entered individually or in combination: 800AC4 - Camera calibration failed 800AC8 - Permanent calibration error 800A24 - Temporary software fault 800ABE - KAFAS camera: Field of view permanently faulty This only affects vehicles with the following optional equipment: 5AU Driving AssistantProfessional.
B310122
Service Bulletin/Repair Instructions
During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/orouter CV boots.
B120125
Emissions
EMISSIONS RECALL 25E-A03: PROGRAM CONTOL UNITS (DME)
B652624
Service Bulletin/Repair Instructions
A check control message (CCM) for the restraint system (Air bag) appears. In the instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: Short circuit to negative terminal 93094F - Knee airbag, front passenger: Short circuit to negative terminal 93094C - Knee airbag driver's side: Resistance too great 930952 - Knee airbag, front passenger: Resistance too great
B410722
Service Bulletin/Repair Instructions
While driving the vehicle on normal roads at10mph and above, a "cracking" sound from the top of the B-pillar(s) is heard.
B630418
Service Bulletin/Repair Instructions
One or more of the LED daytime running lights are dim or discolored.
B640422
Service Bulletin/Repair Instructions
An interference noise (groaning noise) can be heard from within the heating and air-conditioning unit in thecenter of the instrument panel. The groaning noise always occurs when either a ventilation flap, air stratification flap or the recirculated airflap moves to a different position. Due to the complex design of the heating and air-conditioning unit, the kinematics causing it (top or bottom,left or right) may not be able to be precisely located. Depending on the vehicle model, the number of servomotors (and the associated kinematics unit) varies.Various models use either 2 or 3 servomotors.
B170122
Service Bulletin/Repair Instructions
The Check Control message below appears even though the coolant level is not below minimum when theengine is cold. Check Control message (ID 166): Top up coolant.
B510819
Service Bulletin/Repair Instructions
The basic conditions for initializing the power windows are not met.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B310124
Service Bulletin/Repair Instructions
With the vehicle is on a lift and the front struts are in the extended position, there may be a cracking and orclicking type noise when turning the steering wheel left/right. See attached video V31 01 24. The sound can reoccur when the vehicle is lowered, and the wheels are once again under load. The noise might also be heard for a short time while driving.
B360121
Service Bulletin/Repair Instructions
At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic acknowledgement (clunk) as seen at the 11 second mark of the video. See attached video V36 01 21.
B541119
Service Bulletin/Repair Instructions
This bulletin outlines known areas of possible water entry, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints from the roof area. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the panoramic sunroof of BMW Sports Activity Vehicles which have quality improvement measures already in place.
B160123
Service Bulletin/Repair Instructions
A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a âÃÂÃÂlarge leak,âÃÂàafter confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
B610524
Service Bulletin/Repair Instructions
The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 ÃÂâÃÂÃÂÃÂàÃÂâÃÂÃÂÃÂÃÂHU-H: ResetÃÂâÃÂÃÂÃÂàwill be stored in the HU-H3.
B521823
Service Bulletin/Repair Instructions
A noise can be heard from underneath the seat while the seat is being moved either forwards or backwards. This can occur to the driverâÂÂs and/or the passengerâÂÂs front seat.
B540421
Service Bulletin/Repair Instructions
This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
B511823
Service Bulletin/Repair Instructions
A groaning noise is heard from the trunk when driving on rough roads.
B120423
Service Bulletin/Repair Instructions
?An unapproved nut was used for the ground point for the chassis ground.
B310223
Service Bulletin/Repair Instructions
?Disturbing noises (thump/pop) when reversing slowly near the steering wheel limit position; for example, when leaving a parking space.
B540123
Service Bulletin/Repair Instructions
?Water leaking into the vehicle from the headliner/microphone area.
B610220
Service Bulletin/Repair Instructions
?When driving over uneven pavement or cobblestones, a knocking noise is present from the passenger side front area (A pillar). Once the vehicle is driven on a flat, even surface; the noise is no longer present.
B650122
Service Bulletin/Repair Instructions
A check control message (CCM) for the restraint system (Air bag) appears. In the instrument cluster, the red air bag warning light lights up permanently.
B090221
Service Bulletin/Repair Instructions
With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service Pack 15 vehicles may receive new functionality or modifications in their features.
B120323
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop effective June 6, 2023 on certain Model Year 2023 - 2024 BMW vehicles that were produced between October 26, 2022 and May 8, 2023.
B630821
Service Bulletin/Repair Instructions
Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permitted short circuit cycles exceeded
B340223
Service Bulletin/Repair Instructions
Brake squeak may occur with cold brakes and driving slowly or reversing
B510823
Service Bulletin/Repair Instructions
Upon opening or closing (i.e., folding in or out) the exterior mirror assembly, a creaking sound is heard from either the driver and/or passenger side.
B511722
Service Bulletin/Repair Instructions
Due to the semiconductor supply, the Local Interconnect Network module in either of the exterior mirrors was switched to another controller. That one provides an imprecise voltage measurement, which the main controller interprets as a fault.
B514616
Service Bulletin/Repair Instructions
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B610123
Service Bulletin/Repair Instructions
Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.
B651523
Service Bulletin/Repair Instructions
After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.
B651921
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective October 15, 2021) on certain Model Year 2022 BMW vehicles that were produced between September 28, 2021 and October 8, 2021. The issue involves the Active Crash Safety Module (ACSM) sensor.
SIB120123
Service Bulletin/Repair Instructions
In hot ambient conditions, if the engine was running for a prolonged time while the vehicle is stationary, a jolt may be experienced while lightly accelerating.
SIB310223
Service Bulletin/Repair Instructions
Disturbing noises (thump/pop) when reversing slowly near the steering wheel limit position; for example, when leaving a parking space.
SIB511722
Service Bulletin/Repair Instructions
Due to the semiconductor supply, the Local Interconnect Network module in either of the exterior mirrors was switched to another controller.
SIB660823
Service Bulletin/Repair Instructions
Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the customer KAFAS camera system cannot be activated due to system restrictions that are not clear to the customer Road signs are sporadically not detected.
B610923
Service Bulletin/Repair Instructions
The gear selector switch (GWS) consists of the control electronics circuit and the selector lever. The sensors for recording the gearshift lever position and for inhibiting inadvertent gearshifts are integrated in the control electronics.
B620223
Service Bulletin/Repair Instructions
In SPORT mode, a black square appears in the RPM gauge (tachometer) section of the instrument cluster display.
B651623
Service Bulletin/Repair Instructions
Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn indicators, acoustic signals) may also have failed.
B840822
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
B841422
Service Bulletin/Repair Instructions
Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).
B630822
Service Bulletin/Repair Instructions
Uneven ambient lighting emission (bright spots/dark spots) on the door trim panel.
B652422
Service Bulletin/Repair Instructions
Visible white spots on the edge of the central information display (CID) from being touched with a finger.
B160322
Service Bulletin/Repair Instructions
The Check Engine Light is on (MIL). After checking faults and diagnosis there is raw fuel found in the charcoal canister and the NVLD pressure switch (in R/R wheel well). Possible faults stored in the DME: 190F08 - Fuel tank venting system: Malfunction 191C02 - Fuel tank venting system,2. discharge point: Malfunction The vent line inside the fuel tank is disconnected.
B611222
Service Bulletin/Repair Instructions
After opening the vehicle with the radio remote control and changing the profile, the exterior mirror settings are lost.
B651222
Service Bulletin/Repair Instructions
The seal of the roof-mounted antenna housing is separating from the vehicle.
B651922
Service Bulletin/Repair Instructions
The customer complains that the radio stations change by themselves.
B611421
Service Bulletin/Repair Instructions
The BMW Gesture Control function may fail permanently as a result of high temperature fluctuations.
B662419
Service Bulletin/Repair Instructions
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.
B662719
Service Bulletin/Repair Instructions
The Lane Change Warning (LCW) yellow triangle symbol on either one, or both the exterior side view mirrors does not illuminate to alert the driver when it should.
SIB010921
Service Bulletin/Repair Instructions
Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Leak Diagnosis Module with hose assembly (NVLD, shown) to: 15 years/150,000 miles as determined by the vehicle's original in-service date. For eligible MY 2017 BMW 530i Sedan and xDrive (B460) vehicles that are currently registered in the State of California (CA) or a State that has fully adopted the State of California PZEV/SULEV regulation (CT, ME, MD, MA, NJ, NY, RI, and VT), the standard component-related coverage for the NVLD is 15 years/150,000 miles. This component-specific limited warranty extension applies to defects in materials or workmanship. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Over time, the Leak Diagnosis Module (NVLD) (with connected hose) component material may fail, this can create a fine leak to develop in the Evaporative Emission Control System (EVAP). Should this occur, corresponding fault codes will be stored in the DME memory and the MIL (Malfunction Indicator Lamp) will illuminate.
SIB011219
Service Bulletin/Repair Instructions
Component-Specific Limited Warranty Extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Radiator Grille Upper and Lower Active Air Flaps to: 15 years/150,000 miles as determined by the vehicle's original in-service date. 1. Air flap control (link) active, upper (G12, G30 and G32) 2. Air flap control (drive), active, upper 3. Air flaps, upper (assembly) 4. Air flaps, lower (assembly) For eligible MY 2017 BMW 530i (B460) vehicles that are currently registered in the State of California (CA) or a State that has fully adopted the State of California PZEV/SULEV regulation (CT, ME, MD, MA, NJ, NY, RI, and VT), the standard emission-related coverage for the Radiator Front Grille Air Vent Flaps is15 years/150,000 miles. This component-specific limited warranty extension applies to defects in materials or workmanship.' This coverage is subject to the same vehicle eligibility requirements, limitations, and exclusions that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. A check control message or MIL (Malfunction Indicator Lamp) may be illuminated with faults stored related to the upper and/or lower active air flap(s). Potential causes include: Faulty upper air flap link (G12, G30, G32) Faulty upper air flap actuator (G01, G02, G12, G30, G32) Faulty upper flap assembly (G01, G02, G12, G30, G32) Faulty lower air flap assembly (G01, G02, G12, G30, G32) Software error in the DME affecting the upper flap (G01, G02 only) Or: Upon visual inspection, the passenger side upper active air flaps are either stuck open or closed, and they will not move and there are no faults stored for the active air flaps (With no check control message or check engine light or displaying)
SIB650922
Service Bulletin/Repair Instructions
The sound output intermittently drops out entirely. This can be reproduced with all audio sources as well as telephone and voice output.
SIB510522
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective March 28, 2022) on certain Model Year 2022 BMW vehicles that were produced between March 1, 2022 and March 8, 2022 because the torsion struts may not have been installed at the plant. Do not deliver to a customer, a New, Certified Pre-Owned or Used vehicle subject to a Delivery Stop, until the vehicle is repaired. Do not use or sell replacement equipment/parts subject to a Delivery Stop.
SIB650122
Service Bulletin/Repair Instructions
A check control message for the restraint system appears. In the instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: short circuit to negative terminal 93094F - Knee airbag, front passenger: short circuit to negative terminal.
SIB662419
Service Bulletin/Repair Instructions
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.
SIB090121
Service Bulletin/Repair Instructions
BMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service technicians. The new ISTA Version is also able to be used in case of a Remote Software Upgrade (RSU) programming failure to get the customer car reprogrammed on site. In case of a Remote Software Upgrade failure, the engine start is prevented for safety reasons until the vehicle is programmed correctly. Most of the errors occur when only one control unit fails to program correctly.
SIB170122
Service Bulletin/Repair Instructions
The Check Control message below appears even though the coolant level is not below minimum when the engine is cold. Check Control message (ID 166): Top up coolant.
SIB510722
Service Bulletin/Repair Instructions
This bulletin outlines known areas of possible functional issues, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints pertaining to the doors, windows, and mirrors. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the door, windows, and mirrors of BMW Sports Activity Vehicles which have quality improvement measures already in place.
SIB610722
Service Bulletin/Repair Instructions
Check Control Message (CCM) displays "Vehicle key missing" after engine start.
SIB610822
Service Bulletin/Repair Instructions
When using the Key Reader to retrieve information from the customer's key, no current vehicle data is available.
SIB640222
Service Bulletin/Repair Instructions
Mist formation on the windshield inside surface may occur at departure or after MSA (automaticstart/stop). Acoustic abnormality in the area of the recirculated air flap (recirculation flap closing and opening severaltimes). The above may occur individually or in combination.
SIB651312
Service Bulletin/Repair Instructions
The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and was introduced in 3/2014. This uses map North America EVO. The Headunit High 4 (HU-H4, also called MGU21) superseded the MGU starting with certain MY2021 vehicles with option code 6U3 Live Cockpit Professional. This uses map North America JOY. The ENTRY Media/Navigation (HU-B) is the low line business version of the navigation system and was introduced in 3/2014. This uses map North America ROUTE. The ENTRY NAV EVO (HU-B2) replaced Entry Media/Navigation as the low-line business version and was introduced in certain MY2018 vehicles. This uses map North America WAY.
SIB660620
Service Bulletin/Repair Instructions
The functionality of the right front SRR sensor could be reduced which would display the "Driving Assistance" Check Control Message.
B610121
Service Bulletin/Repair Instructions
48 V battery may become totally discharged, and possible replacement needed.
B610622
Service Bulletin/Repair Instructions
No actuation of front and rear windscreen wipers is possible.
B610722
Service Bulletin/Repair Instructions
Check Control message (CCM) displays "Vehicle key missing" after engine start.
B270122
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective January 11, 2022) on a small number of Model Year 2022 BMW vehicles that were produced between December 23, 2021 and January 4, 2022. Do not deliver to a customer, a New, Certified Pre-Owned or Used vehicle subject to a Delivery Stop, until the vehicle is repaired. Do not use or sell replacement equipment/parts subject to a Delivery Stop. Due to a production failure, the control unit was assembled with a capacitor instead of a resistor.
B510522
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective March 28, 2022) on certain Model Year 2022 BMW vehicles that were produced between February 28, 2022 and March 8, 2022 because the torsion struts were not installed at the plant.
B520221
Service Bulletin/Repair Instructions
Milky-white stains (discolorations) in the leather are observed in the second-row seat bottom, backrests and/or headrests. Refer to attachment for details. This only affects vehicles with the Merino leather.
B640121
Service Bulletin/Repair Instructions
A whistling noise is present from the fresh air inlet area (engine compartment bulkhead area), in the right front area of the vehicle, at speeds above 40 mph. The noise is loudest when the sunroof is in the vent position.
B661519
Service Bulletin/Repair Instructions
The steering intervention for Lane Departure Warning (LDW) is too strong (severe), which can create an uncomfortable feeling for the driver. Background: Steering intervention helps keep the vehicle in the lane if the system detects that a lane marking has been crossed. The steering intervention can be noticed on the steering wheel and can be manually overridden at any time.
B110721
Service Bulletin/Repair Instructions
MAIN BEARING SHELL.
B012518
Service Bulletin/Repair Instructions
Starting with Model Year 2022, retroactively, the remaining standard scheduled maintenance coverage is now transferable to the next vehicle owner without a Refresh.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.