B110723
Emissions
The return springs on the exhaust camshaft followers (switchable rocker arm) may break.
Vehicle report
2023 BMW X7
Service bulletins
137 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
B120326
Emissions
Due to an implementation error in various OBD diagnostics in the vehicle's control units, in very rare cases itmay happen that stored fault memory codes (DTCs) and the MIL (warning light) are not automaticallydeleted even though the underlying malfunction has already been rectified. This does not comply with the statutory OBD specifications.
B652025
Service Bulletin/Repair Instructions
After replacing the Multifunctional Display (MFD), the Central Information Display (CID) is black. The backlight of the CID is illuminated, and touch function does register an audible sound.
B640320
Service Bulletin/Repair Instructions
The center console and front cup holder get noticeably too warm to the touch on long journeys with the interior "Heating on".
B641224
Service Bulletin/Repair Instructions
1. Use of aftermarket accessory hang-on cellular phone holders and/or air fresheners can break the instrument panel air vent slats. Damage and/or issues caused by outside influences are not covered under the BMW limited warranties. Originally, the air vent slats were only repairable by replacing the entire front center dash vent assembly; which in some applications, also included the IHKA control module.
B652724
Service Bulletin/Repair Instructions
A check control message (CCM) for the restraint system (Air bag) appears. In the instrument cluster, the redair bag warning light lights up permanently. One of the following fault codes is stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: Short circuit to negative terminal 93094F - Knee airbag, front passenger: Short circuit to negative terminal 93094C - Knee airbag driver's side: Resistance too great 930952 - Knee airbag, front passenger: Resistance too great
B120224
Emissions
RSU availability. VOLUNTARY EMISSIONS RECALL 24E-A02: VALVETRONIC
B120725
Emissions
A quality check revealed that the DME in these vehicles has a programming error. This results in a deviation of the fuel-air mixture in the internal combustion engine.
B340425
Emissions
As a result of a data input error, certain fault memories are permanently stored. The permanent storage offault memories does not comply with the legal specifications of the authority (California Air Resources Board– CARB). The fault has no effect on the use of the vehicle by the customer.
B120425
Service Campaign
As a result of a data input error, certain fault memories are permanently stored. The permanent storage offault memories does not comply with the legal specifications of the authority (California Air Resources Board– CARB). The fault has no effect on the use of the vehicle by the customer.
B511223
Service Bulletin/Repair Instructions
A vehicle listed above may arrive with a Check Control Message (CCM), and/or malfunction indicator lamp(MIL) illuminated. After carrying out the vehicle test, one or more of the stored faults indicate that the operation of the frontbottom active air flap is obstructed or blocked.
B521923
Service Bulletin/Repair Instructions
In vehicles equipped with the second row 60% / 40% split seat, the flex cable assembly can come out of the seat rail mechanism (circled). This stops the forwards and backwards travel of the seat.
B630125
Service Bulletin/Repair Instructions
Contamination/condensation in the uppersection of the Daytime Running Lights (DRL)headlight(s); driver’s headlamp shown.
B660325
Service Bulletin/Repair Instructions
A check control message is displayed, indicating that the parking assistance systems have limitedfunctionality due to errors detected within PDC sensors. The warning indicates parking assistance featureshave limited functionality while the errors continue to be detected. Following faults may be stored 8031BA Ultrasonic Sensor Rear Side Left Software Error 8031CO Ultrasonic Sensor Rear outer left Software Error 8031AE Ultrasonic Sensor Rear Outer Right Software Error 8031A8 Ultrasonic Sensor Rear Side Right Software Error 8031B4 Ultrasonic Sensor Rear Middle Right Software Error 8031C6 Ultrasonic Sensor Rear Middle Left Software Error 8031CD Ultrasonic Sensor Voltage Supply Sensors Back: Short Circuit 8031CC Ultrasonic Sensor Voltage Supply Front: Short Circuit 8031CA Ultrasonic Sensors Front Extraneous Noise
B111024
Service Campaign
The engine oil pump mounting screws may not have been tightened with the correct torque.
B520920
Service Bulletin/Repair Instructions
HEAD RESTRAINT AND/OR BACKREST OF 3RD ROW SEATS CANNOT BE FOLDED DOWN
B310223
Service Bulletin/Repair Instructions
When turning the steering wheel while stationary or when driving on uneven roads; cracking, creaking, or knocking noises may be heard.
B270220
Service Bulletin/Repair Instructions
There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads There are no warning lights or Check Control messages.
B660524
Service Campaign
The usage of the Highway Assist Hands-Off function (option code 5AX) is not possible.
B651024
Service Campaign
Quality improvements and robustness measures are to be implemented on the affected vehicles via thissoftware update. The software update improves functions in the following areas of the vehicle: Bluetooth malfunctions The start-up phase of the head unit (HU) has been shortened (faster start of the operating system) The number of disconnections from Apple CarPlay have been reduced Vehicle access and the drive-ready state have been improved The AC charging abort error has been fixed Remote Control Parking without function
B511224
Service Bulletin/Repair Instructions
There are two possible situations (rear left, right or both sides): A. The electric sunshade in the rear door does not function or sticks upon operation, and/or B. The electric sunshade is wavy.
B650121
Service Bulletin/Repair Instructions
No Bass or a cracking noise can be heard from the bass speakers.
B652023
Service Campaign
The Service Acti on related to SIB 65 20 23 has been completed and the defect code has been closed by warranty. Alllisted VINs have had the acti on performed. This Service Acti on is complete and the informati on is no longer valid
B840224
Service Bulletin/Repair Instructions
The Check Control Message “Emergency call not available” is displayed to the customer. Check Control Message 299 is stored in the Instrument Cluster check control message list or in the vehiclekey data. This fault may be intermittent and can heal itself after a drive cycle. It may no longer be displayed to the customer in the next life cycle.
B810424
Service Bulletin/Repair Instructions
Certain vehicles with a Wireless Charging Tray installed may experience operation issues with ComfortAccess or remote functions.
B120224B
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective April 12, 2024) on certain Model Year 2023 - 2025 BMW vehicles that were produced between July 21, 2021, and April 11, 2024.
B120224A
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective April 12, 2024) on certain Model Year 2023 - 2025 BMW vehicles that were produced between July 21, 2021, and April 11, 2024.
B521019
Service Bulletin/Repair Instructions
The seat leather upholstery detaches from the front of the thigh support (aka knee bolster) of either front seat.
B630523
Service Bulletin/Repair Instructions
The connection between the LED module and the light tube inside the upper/top headlamp housing is damaged.
B611124
Service Bulletin/Repair Instructions
After performing a BMW Remote Software Upgrade (RSU), the functionality of the Comfort Access andPassive Go/Exit features may be reduced. Also, one or more of the following error memory entries below may be stored in the Basic Central Platform(BCP) module. 80424A Remote control receiver at the front (FBD5 VM): Programming defective 80424B Remote control receiver at the rear (FBD5 HM): Programming defective 80424C Remote control receiver at the front left (FBD5s VL): Programming defective 80424D Remote control receiver at the front right (FBD5s VR): Programming defective 80424E Remote control receiver at the rear right (FBD5s HR): Programming defective 80424F Remote control receiver at the rear left (FBD5s HL): Programming defective
B511520
Service Bulletin/Repair Instructions
Deactivated: Currently investigating other components that maybe playing a factors besides what is mentioned in the SIB. Topic is under investigation.
B612723
Service Bulletin/Repair Instructions
The original Conditioned Based Service (CBS) Key data point closed with 23-07 soft ware, all CBS systems are now collectively under analysis.
B310122
Service Bulletin/Repair Instructions
During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/o router CV boots.
B630418
Service Bulletin/Repair Instructions
One or more of the LED daytime running lights are dim or discolored.
B120721
Service Bulletin/Repair Instructions
Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt betweenCombustion engine and starter generator torn And/or one or more of the following other issues are also occurring: Noise in the area of the belt drive. Odor from the engine compartment. Smoke formation in the area of the belt drive. Drive belt damaged or prematurely worn. Torn drive belt.
B170122
Service Bulletin/Repair Instructions
The Check Control message below appears even though the coolant level is not below minimum when theengine is cold. Check Control message (ID 166): Top up coolant.
B510819
Service Bulletin/Repair Instructions
The basic conditions for initializing the power windows are not met.
B611305
Service Bulletin/Repair Instructions
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle âÂÂdischarged batteryâ complaints.
B360121
Service Bulletin/Repair Instructions
At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic acknowledgement (clunk) as seen at the 11 second mark of the video. See attached video V36 01 21.
B541119
Service Bulletin/Repair Instructions
This bulletin outlines known areas of possible water entry, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints from the roof area. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the panoramic sunroof of BMW Sports Activity Vehicles which have quality improvement measures already in place.
B160123
Service Bulletin/Repair Instructions
A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a âÃÂÃÂlarge leak,âÃÂàafter confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
B541319
Service Bulletin/Repair Instructions
The roller sunshade (aka sun protection or sunblind) of the front panoramic sunroof is bunching up during operation or may hang down and appear loose.
B610524
Service Bulletin/Repair Instructions
The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 ÃÂâÃÂÃÂÃÂàÃÂâÃÂÃÂÃÂÃÂHU-H: ResetÃÂâÃÂÃÂÃÂàwill be stored in the HU-H3.
B641123
Service Bulletin/Repair Instructions
Check Engine light is on IHKA has stored fault 80131C âÂÂIHKA: 12V voltage sensor plausibilityâÂÂ
B320223
Service Bulletin/Repair Instructions
SITUATION Unusual noises occur only when operating the steering column in the axial direction. 1. A one-time thump sound at the start of movement Shortly after the steering column starts moving, retracting, or extending, a one-time thump noise is heard. See attached video V32 03 23 2. Humming noise while steering column extends in the axial direction. The sound is only heard when the steering column is extended, not when the steering column is retracted. When the steering column starts to move in the extended direction, the humming noise can be heard. See attached video V32 04 23
B160623
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B340423
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective December 20, 2023) on certain Model Year 2023 - 2024BMW vehicles that were produced between July 4, 2022, and October 26, 2023.
B521423
Service Bulletin/Repair Instructions
A change in the Bowden cable routing is observed in the third seat row backrest. Replacement Bowden cables are shorter than original parts.
B522319
Service Bulletin/Repair Instructions
Two areas of the third-row seat backrest that may cause a noise concern have been added.
B653423
Service Bulletin/Repair Instructions
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
B653523
Service Bulletin/Repair Instructions
Customers may be experiencing one or more of these following issues with Bluetooth operation: Bluetooth cannot be switched on or off in the head unit (HU-H5) Paired mobile devices cannot be deleted Customer is unable to make phone calls or stream music with mobile device Customer is unable to connect a new mobile device via Bluetooth Mobile device does not automatically reconnect via Bluetooth in the next drive cycle (after short sleep cycle
B652723
Service Bulletin/Repair Instructions
Customers may be experiencing one or more of these 3 issues with Apple CarPlayî operation: No selections can be made in Apple CarPlayî using the I-Drive Controller Apple CarPlayî connections may intermittently be dropped and reconnected When connecting a mobile device using Apple CarPlayî, the following warning pop-up may be displayed
B661523
Service Bulletin/Repair Instructions
Emergency Stop Assistant is activated. Thisicon will appear in the CID when this function is activated.
B410822
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective December 21, 2022) on a small number of Model Year 2023BMW X7 SAV vehicles that were produced between September 1, 2022 and December 3, 2022. During assembly of the vehicle, a heat shield was mistakenly installed above the transmission. Note: No heat shield should have been installed. It may contact other components in the narrowspace along the bottom of the transmission tunnel.
B653123
Service Bulletin/Repair Instructions
A vehicle may arrive at your center with various faults and check control messages. During diagnosis with ISTA, these modules do not respond: Receiver Audio Module (RAM) Instrument Cluster Module (KOMBI) Telematics Module (TCB4) Headunit 5 (HU-H5)
B410423
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective September 14, 2023) on certain model year 2023 â 2024BMW vehicles that were produced between May 9, 2023 and May 30, 2023. The weld seam at the towing eye did could not meet the BMW requirements.
B410203
Service Bulletin/Repair Instructions
Due to prolonged, normal body flex acting on the vehicle during its service life, a small indentation and/or a crack can form in the body sheetmetal in the right rear wheelwell (aka wheel house). Potential water ingress and a risk of corrosion is possible.
B660523
Service Bulletin/Repair Instructions
Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
B540421
Service Bulletin/Repair Instructions
This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
MCAS4023
Service Bulletin/Repair Instructions
BMW AG has requested the inspection of all dealer stock of the following part number(s) listed below to ensure the spacer is conformed to drawing.
B120623
Service Bulletin/Repair Instructions
The engine malfunction warning is illuminated and one or more of the following faults are stored in theDME: 034D63 - Exhaust switchable cam follower, system: continuous deactivation, maximum number of switchingerrors exceeded 035601 - Exhaust switchable cam follower 1, electrical: cable break 035604 - Exhaust switchable cam follower 2, electrical: cable break 034BBF - Exhaust switchable cam follower, system: switching errors
B110823
Service Bulletin/Repair Instructions
Due to an assembly ase ventilation line connections may not be securely locked.
B652823
Service Bulletin/Repair Instructions
Customers may be experiencing one or more of these following issues with Bluetooth operation: Bluetooth cannot be switched on or off in the head unit (HU-H4) Paired mobile devices cannot be deleted Customer is unable to make phone calls or stream music with mobile device Customer is unable to connect a new mobile device via Bluetooth Mobile device does not automatically reconnect via Bluetooth in the next drive cycle (after short sleep cycle)
B240323
Service Bulletin/Repair Instructions
?A software error may cause an unwanted pressure pulsation in the transmission during a "Remote Engine Start."
B520121
Service Bulletin/Repair Instructions
?The front seat will not calibrate/initialize, and the stored faults cannot be deleted.
B540123
Service Bulletin/Repair Instructions
?Water leaking into the vehicle from the headliner/microphone area.
B630923
Service Bulletin/Repair Instructions
The interior lights in the rear of the passenger area do not work.
B650222
Service Bulletin/Repair Instructions
A check control message (CCM) for the restraint system (Air bag) appears.
B652523
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop: KNEE AIRBAG.
B661223
Service Bulletin/Repair Instructions
?BMW AG has issued a Delivery Stop for BMW X5, X6, X7, and 7 Series sedan vehicles that were produced between July 7, 2023 and August 15, 2023. Usage of the Highway Assist function (option code 5AX) is not possible.
B090221
Service Bulletin/Repair Instructions
With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service Pack 15 vehicles may receive new functionality or modifications in their features.
B120223
Service Bulletin/Repair Instructions
Due to a manufacturing defect in the ignition coil BMW AG has issued a Delivery Stop (effective June 1, 2023) on a small number of Model Year 2023 - 2024 BMW vehicles.
B120323
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop effective June 6, 2023 on certain Model Year 2023 - 2024 BMW vehicles that were produced between October 26, 2022 and May 8, 2023.
B240223
Service Bulletin/Repair Instructions
BMW AG has issued an Emissions Recall (effective March 17, 2023) on a certain Model Year 2021 - 2023 BMW vehicles that were produced between June 16, 2020, and December 13, 2022. Due to a software failure, there is the possibility that the transmission does not go into "sleep mode" if the car is turned off.
B630321
Service Bulletin/Repair Instructions
Condensation is present on the inner surfaces in one or both taillights (circled).
B630821
Service Bulletin/Repair Instructions
Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permitted short circuit cycles exceeded
B640821
Service Bulletin/Repair Instructions
The air conditioning cycles from cold to warm air while driving or while at a stand still. The vent outlet temperatures vary by 25 degrees Fahrenheit or more (38 F to 60 F +) without changing any climate control settings.
B011323
Service Bulletin/Repair Instructions
Interim Class Action Settlement F95/96, G05/G06/G07 front center console cupholder United States District Court Central District of California.
B340720
Service Bulletin/Repair Instructions
DSCi units which potentially have a faulty hydraulic valve were installed in the vehicles. The affected units may activate a sporadic red-colored Check Control Message.
B410223
Service Bulletin/Repair Instructions
Due to prolonged, normal body flex acting on the vehicle during its service life, a small indentation and/or a crack can form in the body sheetmetal in the right rear wheelwell (aka wheel house). Potential water ingress and a risk of corrosion is possible.
B510222
Service Bulletin/Repair Instructions
In the affected vehicles, faulty spindle drives for the tailgate (lower section) may have been installed, which can fail over time.
B510823
Service Bulletin/Repair Instructions
Upon opening or closing (i.e., folding in or out) the exterior mirror assembly, a creaking sound is heard from either the driver and/or passenger side.
B511722
Service Bulletin/Repair Instructions
Due to the semiconductor supply, the Local Interconnect Network module in either of the exterior mirrors was switched to another controller. That one provides an imprecise voltage measurement, which the main controller interprets as a fault.
B514616
Service Bulletin/Repair Instructions
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
B610123
Service Bulletin/Repair Instructions
Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.
B630823
Service Bulletin/Repair Instructions
The reading lights for the second and third row seating activate automatically without customer input.
B651921
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective October 15, 2021) on certain Model Year 2022 BMW vehicles that were produced between September 28, 2021 and October 8, 2021. The issue involves the Active Crash Safety Module (ACSM) sensor.
B661023
Service Bulletin/Repair Instructions
After programming to I-level 23-03-5xx, the fault memory 0x022270 is stored in the mPAD (Medium Platform Automatic Driving) and cannot be deleted. A Check Control message "Driver assistance" is displayed in the central information display.
SIB160323
Service Bulletin/Repair Instructions
Engine cranks but will not start.
SIB510623
Service Bulletin/Repair Instructions
The hazard light (aka emergency flasher) button gets stuck in the ON or OFF position when actuated.
SIB511722
Service Bulletin/Repair Instructions
Due to the semiconductor supply, the Local Interconnect Network module in either of the exterior mirrors was switched to another controller.
SIB630123
Service Bulletin/Repair Instructions
The following headlight CC messages are displayed: 128 "Left high beam headlight faulty" 130 "Right high beam headlight faulty" The following fault codes are stored during a vehicle test: 805A22- MLC: Communication fault timeout FLM-03 left 805BA2- MLC: Communication fault timeout FLM-03 right
SIB660823
Service Bulletin/Repair Instructions
Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the customer KAFAS camera system cannot be activated due to system restrictions that are not clear to the customer Road signs are sporadically not detected.
B320123
Service Bulletin/Repair Instructions
When turning the steering wheel while stationary or when driving on uneven roads; cracking, creaking, or knocking noises may be heard.
B320420
Service Bulletin/Repair Instructions
A groaning type noise is heard during the height adjustment.
B610923
Service Bulletin/Repair Instructions
The gear selector switch (GWS) consists of the control electronics circuit and the selector lever. The sensors for recording the gearshift lever position and for inhibiting inadvertent gearshifts are integrated in the control electronics.
B630423
Service Bulletin/Repair Instructions
Possible failure of lighting operation in either left or right front headlamp assemblies (i.e., daytime driving lights, low beam lights, turn indicators.
B651623
Service Bulletin/Repair Instructions
Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn indicators, acoustic signals) may also have failed.
B840822
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
B841422
Service Bulletin/Repair Instructions
Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).
SIB652021
Service Bulletin/Repair Instructions
Central information display.
SIB610223
Service Bulletin/Repair Instructions
Windshield Wiper.
SIB410123
Service Bulletin/Repair Instructions
POPPING SOUND AT THE TOP OF THE C-PILLAR.
B160223
Service Bulletin/Repair Instructions
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) when diagnosing with ITSA.
B410123
Service Bulletin/Repair Instructions
While driving the vehicle on normal roads at 10 mph and above, a popping sound from the top of the Cpillar(s) is heard. The sound can occur on either the left or right side of the C-pillar.
B610120
Service Bulletin/Repair Instructions
Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt power socket plug. Alternatively, it will only operate when constant downward hand pressure is maintained.
B610223
Service Bulletin/Repair Instructions
Check control message (CCM) 183 Windscreen wiper malfunction is displayed.
B630123
Service Bulletin/Repair Instructions
The following headlight CC messages are displayed: 128 Left high beam headlight faulty 130 Right high beam headlight faulty; The following fault codes are stored during a vehicle test: 805A22- MLC: Communication fault timeout FLM-03 left 805BA2- MLC: Communication fault timeout FLM-03 right.
B650422
Service Bulletin/Repair Instructions
Due to component-related supply issues, the central information displays (CID) in some of the Model Year 2022 vehicles listed above were produced without the integrated touch screen function.
B652021
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective October 25, 2021) on certain Model Year 2022 BMW vehicles that were produced after October 25, 2021. Due to supply chain limitations, certain vehicles were produced without a CID with touch function and and without Reversing Assistant.
B122519
Service Bulletin/Repair Instructions
After an automatic engine start (MSA start), the transmission intermittently goes into the Park "P" or Neutral "N" position without any customer influence.
B170617
Service Bulletin/Repair Instructions
Coolant leaking from the engine compartment. Traces of coolant leaking from the expansion tank of the low temperature cooling system.
B512322
Service Bulletin/Repair Instructions
When starting the vehicle remotely, the radiator blind of the active air flap control remains closed. This results in inadequate climate control in the vehicle interior.
B612922
Service Bulletin/Repair Instructions
The saved steering column positions, vertical and horizontal, are not stored long term.
B630822
Service Bulletin/Repair Instructions
Uneven ambient lighting emission (bright spots/dark spots) on the door trim panel.
B660322
Service Bulletin/Repair Instructions
Driver Assistance Reduced check control message (CCM) appears.
B841222
Service Bulletin/Repair Instructions
BMW AG has issued a Delivery Stop (effective November 10, 2022) on a small number of Model Year 2023 BMW vehicles that were produced between August 8, 2022 and October 18, 2022.
B360322
Service Bulletin/Repair Instructions
Loss of tire pressure with corresponding Check Control Message.
B520419
Service Bulletin/Repair Instructions
The driver's side (left rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail).
B520422
Service Bulletin/Repair Instructions
When returning the 2nd row seat 60% (left) side from Easy-Entry: The seat stops moving before reaching the final home position, a check control message (CCM) appears alerting the customer that the seat back is unlocked.
B521919
Service Bulletin/Repair Instructions
The passenger's side (right rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail).
B630422
Service Bulletin/Repair Instructions
When activating the turn signal function, the low beam/cornering light will flicker.
B651122
Service Bulletin/Repair Instructions
There is potential ingress via the roof antenna housing.
B651322
Service Bulletin/Repair Instructions
After updating dealer owned vehicles to software 22-07-5XX, many current BMW customers and previous Demo users may receive emails stating that they are linked to BMW vehicles they do not own. Also, many users of the MyBMW app may find additional vehicles in their "My Garage" tab that they do not recognize.
B660422
Service Bulletin/Repair Instructions
Usage of the high-beam assistant is not possible.
B662419
Service Bulletin/Repair Instructions
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.
B662719
Service Bulletin/Repair Instructions
The Lane Change Warning (LCW) yellow triangle symbol on either one, or both the exterior side view mirrors does not illuminate to alert the driver when it should.
SIB090222
Service Bulletin/Repair Instructions
Programming of various modules will provide quality improvements and system robustness to: Valet parking mode, accessed via the Center Information Display (CID) app System Settings. Voice commands, actuated using the microphone button on the steering wheel's right spoke (arrow). Driver Assistance Systems, accessed via the CID app Driving Settings.
SIB170220
Service Bulletin/Repair Instructions
Symptom 1: There are traces of coolant leaking under the vehicle, or there is significant pressure released along with coolant loss when opening the low temperature cooling system reservoir (engine cold). The following fault code may also be stored in the DME: 20A201 - Charge air cooling system: Coolant pump protective function activated due to dry running Symptom 2*: The air conditioning may have low cooling output with the following fault stored in the IHKA: 80120A - Compressor: Shut down due to overpressure in refrigerant system. Symptom 2 is an additional symptom related to Symptom 1. Diagnose the IHKA fault with ISTA test plans if it is the only fault stored (if no DME faults are stored related to coolant loss, this bulletin repair does not apply).
SIB650922
Service Bulletin/Repair Instructions
The sound output intermittently drops out entirely. This can be reproduced with all audio sources as well as telephone and voice output.
SIB660322
Service Bulletin/Repair Instructions
Driver Assistance reduced checked control message (CCM) appears. All or some of the system functions maybe inoperative. The following fault will be stored: 481CC6.
SIB511222
Service Bulletin/Repair Instructions
The following LIN faults for electric door sunshade may be present in the BDC fault memory. D90D81-Sunblind rear driver (LIN): Missing LIN-slave D90D84-Sunblind rear passenger (LIN): Missing LIN-slave 8049B2-Sunblind rear driver (LIN): Line interruption 8049B6-Sunblind rear passenger (LIN): Line interruption 8049B3-Sunblind rear driver (LIN): Button jammed 8049B7-Sunblind rear passenger (LIN): Button jammed.
SIB650522
Service Bulletin/Repair Instructions
The incorrect Bluetooth module was installed in the headunit. Bluetooth functionality cannot be guaranteed, and mobile phones may possibly not be paired via Bluetooth.
SIB840622
Service Bulletin/Repair Instructions
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. For this purpose the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
SIB640821
Service Bulletin/Repair Instructions
The air conditioning cycles from cold to warm air while driving or while at a stand still. The vent outlet temperatures vary by 25 degrees Fahrenheit or more (38 F to 60 F +) without changing any climate control settings. In some cases the air conditioning may have stopped blowing cold air altogether.
SIB650222
Service Bulletin/Repair Instructions
A check control message for the restraint system appears. In the Instrument cluster, the red air bag warning light lights up permanently. One of the following fault codes stored in the ACSM (air bag control unit): 930949 - Knee airbag, driver: short circuit to negative terminal; 93094F - Knee airbag, front passenger: short circuit to negative terminal.
SIB662419
Service Bulletin/Repair Instructions
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.