WI-097-2026
Service Bulletin/Repair Instructions
Under different circumstances, it may be necessary to remove and replace the belt rail along a slide-out. The following instructions provide direction for performing this procedure.
Vehicle report
2023 BRINKLEY RV MODEL Z
Service bulletins
24 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
WI-001-2024 REV B
Service Bulletin/Repair Instructions
Update to WI-001-2024 Model Z Bed Platform Repair and Vent installation. This is to correct the placement of the bedroom slide-out rollers on the bedroom floor.
WI-092-2026
Service Bulletin/Repair Instructions
Model Z front cap repositioning instructions.
WI-006-2025 REV-C
Service Bulletin/Repair Instructions
This document refers to the adjustment of a Dinesk™ system that won’t close properly or is bowed up when extended. Updated affected models
WI-003-2024 Rev-B
Service Bulletin/Repair Instructions
Updated Work instructions to WI-003-2024. This Revision (REV B) shows how to replace the decorative light lens cover on the front cap which may peel and allow for water intrusion. This could damage the LED light strip behind them.
WI-029-2025 (REV-F)
Service Bulletin/Repair Instructions
Updated work instructions for Model Z fifth wheel (except Z3610) sidewall replacement.
WI-014-2025 (REV-E)
Service Bulletin/Repair Instructions
This is a revised version of a previously distributed instruction outlining sidewall repair instructions in the event there are cracks in the sidewall of a unit. This instruction has been shared with a limited number of dealer partners who have been trained on the specific fiberglass and associated repairs on Brinkley RV Model G and Model Z 3610.
WI-029-2025
Service Bulletin/Repair Instructions
This is a revised version of a previously distributed instruction outlining sidewall repair instructions in the event there are cracks in the sidewall of a unit. This instruction has been shared with a limited number of dealer partners who have been trained on the specific fiberglass and associated repairs on Brinkley RV Model Z.
WI-014-2025
Service Bulletin/Repair Instructions
This is a revised version of a previously distributed instruction outlining sidewall repair procedures in the event there are cracks in the sidewall of a unit. This instruction has been shared with a limited number of dealer partners who have been trained on the specific fiberglass and associated sidewall repairs on Brinkley Model G and Model Z 3610 units.
WI-008-2025 Model Z REV C
Service Bulletin/Repair Instructions
This is an updated Work Instruction (new part number) explaining how to install a new magnet switch and relay to address a pantry light switch that is operating intermittently.
WI-014-2025 Model G and Z
Service Bulletin/Repair Instructions
This is a repair instruction outlining how to make sidewall repairs in the event there are cracks in the sidewall of a unit. This instruction has been shared with a limited number of dealer partners who have been trained on the specific fiberglass and associated sidewall repairs on Brinkley Model G and Model Z3610 units.
WI-029-2025 Model Z
Service Bulletin/Repair Instructions
This is a repair instruction outlining how to make sidewall repairs in the event there are cracks in the sidewall of a unit. This instruction has been shared with a limited number of dealer partners who have been trained on the specific fiberglass and associated sidewall repairs on Brinkley Model units (excluding Model Z3610).
WI-003-2024 REV-B
Service Bulletin/Repair Instructions
REV-B revision to previous document: Brinkley RV has determined that under certain conditions the decorative light lens covers on the front cap may peel, allowing the possibility of water intrusion and damage to the LED light strips behind them.
WI-035-2025
Service Bulletin/Repair Instructions
Work Instruction for entry door camber adjustments to ensure proper sealing of the door.
WI-037-2025
Service Bulletin/Repair Instructions
Brinkley RV has determined that some Model Z AIR Travel Trailers may have missing seals at the front baggage compartment door latch striker plates.
WI-019-2024
Service Bulletin/Repair Instructions
Brinkley RV has determined that under certain circumstances there can be minor water intrusion into the bedroom under the bedroom slide out. Brinkley RV has determined the bottom slide-out facia backer presses against the water tray below the slideout when the room is fully extended. This pressure can limit the water tray’s ability to dissipate the water as designed. Brinkley RV will, at no charge to the customer, pay to modify the bedroom slide-out fascia backer so it no longer adversely affects flow through the water tray.
WI-008-2025 Model Z
Service Bulletin/Repair Instructions
In certain models and floor plans, Brinkley RV has identified a concern with the pantry light switch becoming inoperable. The following are detailed instructions for installation of a new magnet switch and relay to improve product performance.
Water Intrusion Service
Service Bulletin/Repair Instructions
Brinkley RV has determined the bottom slide-out facia backer, in some cases, presses against the water tray below the slideout when the room is fully extended. This pressure can limit the water tray’s ability to dissipate the water as designed. Brinkley RV will, at no charge to the customer, pay to modify the bedroom slide-out facia backer so it no longer adversely affects flow through the water tray.
Front_Cap_Lens_Peeling_RE
Service Bulletin/Repair Instructions
Brinkley RV has determined that under certain conditions the decorative light lens covers may peel, allowing the possibility of water intrusion and damage to the LED light strips behind them. This is a supporting document to the previous informational submittal 24MC11003772.
CSC-2309
Service Bulletin/Repair Instructions
It has come to our attention that the polycarbonate plastic utilized to manufacture attic vents for the RV industry may be incompatible with the 5121 self-leveling roof sealant that we utilize. We have received reports of cracked attic vents in the field that we believe are the result of the sealant being more rigid than what is traditionally utilized. This additional rigidity does not permit the attic vent to expand and contract and can result in the attic vent cracking either along the location of the mounting screw holes and, in some cases, cracking vertically up the attic vent. Brinkley RV will pay for the Campaign to be completed. There is no charge to the customer for the remedy.
CSC-2301
Service Bulletin/Repair Instructions
After communication with the supplier (Lippert), Brinkley has decided to issue Customer Satisfaction Campaign, CSC-2301. This CSC is to replace the LCI awning pitch bolts with improved bolts and to add additional washers to the installment (parts supplied by LCI). This measure is being done to prevent the pitch bolts from sheering during operation of the awning.
CSC-2302
Service Bulletin/Repair Instructions
Brinkley is issuing CSC-2302 regarding the soffit panel. VINs ending in 1000004-1000039, could have a loose securement allowing the soffit panel to sag. To correct this, additional fasteners are to be installed into the soffit framing, and the panel should then be reinstalled.
CSC-2303
Service Bulletin/Repair Instructions
Brinkley is issuing CSC-2303, as a preventative measure for a potential leak at the lower rail of the bedroom slide. The lower rails of the slide should be removed so a small foam gasket can be installed onto the rail before it is reinstalled. This will ensure water cannot trail into the RV via the rail when the RV is unlevel. CSC-2303 only pertains to units ending in 1000004-1000052.
CSC-2304
Service Bulletin/Repair Instructions
Brinkley is issuing CSC-2304, regarding the attic vents on the roof assembly. VINs ending in 1000004-1000029, may have had a primer applied to the attic vent itself that could cause the material to prematurely crack allowing water infiltration into the roofing assembly. To prevent this from occurring, the attic vents are to be replaced with new and resealed.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.