17-NA-073
Service Bulletin/Repair Instructions
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
Vehicle report
1995 CHEVROLET G SERIES
Service bulletins
28 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
G-197151
Service Bulletin/Repair Instructions
00064H - SPECIAL COVERAGE (REVISED PART INFORMATION). SOME CUSTOMERS MAY EXPERIENCE A FAILURE OF THE ELECTRONIC DIESEL FUEL INJECTION PUMP. THIS SPECIAL POLICY APPLIES ONLY TO ELECTRONIC DIESEL-FUEL INJECTION PUMP REPAIRS AND/OR REPLACEMENT AS A RESULT OF INJECTION PUMP FAILURE. THIS SPECIAL COVERAGE DOES NOT COVER: GLOW PLUGS, TURBOCHARGER WEAR, LOW COMPRESSION ENGINES OR PCM/PCM WIRING CONDITIONS.
130089009
Service Bulletin/Repair Instructions
Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
00064C
Service Bulletin/Repair Instructions
A FAILURE OF THE ELECTRONIC DIESEL FUEL INJECTION PUMP, LEAKING TO COMPLAINTS OF POOR PERFORMANCE OR FUEL ECONOMY, HARD / NO STARTS, HESITATION, AS WELL AS ILLUMINATION OF THE SERVICE ENGINE SOON LIGHT. *TT
00064B
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY EXPERIENCE A FAILURE OF THE ELECTRONIC DIESEL FUEL INJECTION PUMP. *JG
000601023A
Service Bulletin/Repair Instructions
INFORMATION USED WHEN DIAGNOSING NOISE CONDITIONS SUCH AS ENGINE RATTLE NOISE, SPARK KNOCK AT 2000 - 2500 RPM RANGE, UNDER A MODERATE TO HEAVY LOAD WITH A WARMED UP ENGINE. *TT
00064A
Service Bulletin/Repair Instructions
SPECIAL POLICY ADJUSTMENT FOR VEHICLES EXPERIENCING A FAILURE OF THE ELECTRONIC DIESEL FUEL INJECTION PUMP LEADING TO COMPLAINTS OF POOR PERFORMANCE OR FUEL ECONOMY, HARD / NO STARTS, HESITATION, AS WELL AS ILLUMINATION OF THE SERVICE ENGINE SOON LIGHT. *TT
00064
Service Bulletin/Repair Instructions
DEDUCTIBLE REIMBURSEMENT CLARIFICATION AND VIN BREAKPOINT CORRECTION TO 00064 - SPECIAL POLICY ADJUSTMENT - ELECTRONIC DIESEL-FUEL INJECTION PUMP FAILURE - REPAIR / REPLACE. *TT
000604002
Service Bulletin/Repair Instructions
SUBJECT REGARDING A HARD, NO START OR EXCESSIVE GRAY OR WHITE SMOKE CONDITION ON START UP AFTER RECENT GLOW PLUG REPLACEMENT. *TT
776306A
Service Bulletin/Repair Instructions
FUEL SOLENOID DRIVER LOCATED ON THE SIDE OF THE FUEL INJECTION PUMP FAILED, CAUSING VEHICLE TO NO START OR STALL.
776306
Service Bulletin/Repair Instructions
COMMENTS OF A NO START, STALL CONDITION. *YC
677153A
Service Bulletin/Repair Instructions
NO UPSHIFT/2ND GEAR ONLY AFTER COLD START-INTERMITTENT DTC 87 - HIGH RATIO ERROR (REPLACE EPROM). *TW
577126B
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING). *TW
666309
Service Bulletin/Repair Instructions
ENGINE HARD TO START (REPLACE FUEL PUMP PULSATOR). *TW
9674L60E04A
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING). *TW
577126A
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING). *TW
577126R
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAK FROM PUMP BODY/REPLACE BUSHING. *TW
631216
Service Bulletin/Repair Instructions
INSUFFICIENT A/C PERFORMANCE AND/OR NOISY COMPRESSOR CLUTCH DUE TO PREMATURE WEAR OF THE COMPRESSOR SHAFT SEALS. *TW
01404
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMMENT ABOUT A STARTER CLICK-NO-CRANK CONDITION IN COLD AMBIENT TEMPERATURES BELOW 15 DEGREES F. *SD
MSG95C24/C32
Service Bulletin/Repair Instructions
THE SUBJECT CAMPAIGNS ARE BOTH BEING REVISED TO INCREASE THE TIME ALLOWANCE FOR FOR THE G-VAN MODELS TO 2.4 HOURS. *SD
573201
Service Bulletin/Repair Instructions
POWER STEERING PUMP PULLEY MISALIGNMENT (MOVE PULLEY FORWARD). *SD
576115
Service Bulletin/Repair Instructions
UNKNOWN
CAMP/95C32
Service Bulletin/Repair Instructions
UNKNOWN
576403
Service Bulletin/Repair Instructions
STARTER MOTOR CONTINUES TO RUN OR CRANK AFTER THE ENGINE IS RUNNING OR TURNED OFF (SOLENOID GROUND WIRE). *TW
GM563402
Service Bulletin/Repair Instructions
LEAF SPRING U-BOLT ANCHOR PLATE CONTACTS JOUNCE BUMPER BRACKET ON SIDE RAIL (INSTALL NEW U-BOLTS AND ANCHOR PLATE). *TW
577103
Service Bulletin/Repair Instructions
TRANSMISSION LEAK AT REAR EXTENTION HOUSING AND PROP SHAFT. *TW
376602A
Service Bulletin/Repair Instructions
NEW CAST IRON EXHAUST MANIFOLD AND STAINLESS STEEL GASKET TO CORRECT ENGINE NOISE CONDITION. *TW
MSG01376
Service Bulletin/Repair Instructions
MESSAGE TO DEALERS ANNOUNCING MANUFACTURER RECALL 95C14. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.