Vehicle report

2021 CHRYSLER 300

Compare every CHRYSLER 300 yearNHTSA and EPA records

Service bulletins

175 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

S2208000045 REV.D

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

18-044-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P25E4-00 - B Camshaft Position - Unable To Achieve Locked Position Bank 1. (In Active or Stored status) ● P05BD-00 - Stop-Start Mode Switch Range/Performance. (In Active or Stored status) ● P0116-00 - Engine Coolant Temperature Sensor 1 Performance. (In Active or Stored status) ● P062B-00 - Internal Control Module Fuel Injector Control Performance. (In Active or Stored status) ● P0604-00 - Internal Control Module Random Access Memory Ram Error. (In Active or Stored status) ● P060C-00 - Internal Control Module Main Processor Performance. (In Active or Stored status)** ● P018B-00 - Fuel Pressure Sensor "B" Circuit Range/performance. **(In Active or Stored status)** ● P1CEA-00 - Boost Side EVAP Purge System Performance. **(In Active or Stored status)** ● P06DD-00 - Engine Oil Pressure Control Circuit Performance/Stuck Off. **(In Active or Stored status)** ● P00C6-00 - Fuel Rail Pressure Too Low - Engine Cranking. **(In Active or Stored status)** ● P0300-00 - Multiple Cylinder Misfire. **(In Active or Stored status)** Customers may also experience one or more of the following: ● **Oil Level High Warning in the Instrument Panel Cluster (IPC).** ● Fully Autonomous Parking Assist (FAPA) is not deactivated when accelerator pedal is pressed. ● Vehicle is not heating up fast enough at freezi

S2208000045 REV.C

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

S2621000003 REV.A

Service Bulletin/Repair Instructions

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

S2608000010

Service Bulletin/Repair Instructions

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

S1408000384 REV.I

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

109621

Warranty Program/Extension

D-25-17 Rev. A ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and/or Rocker Arm Replacements

109767

Warranty Program/Extension

ID-25-14 Rev. A ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and/or Rocker Arm Replacements

9100735

Service Bulletin/Repair Instructions

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

108463

Service Bulletin/Repair Instructions

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

108464

Service Bulletin/Repair Instructions

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

S2508000102

Service Bulletin/Repair Instructions

Intermittent Uconnect Box Requires Service Message. TBM Setting Stored Or Pending DTCs B22A9, B1560, B1561, B1562

S2509000009

Service Bulletin/Repair Instructions

Engine Oil Leak

107563

Warranty Program/Extension

D-25-17 ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and Rocker Arm Replacements

107564

Warranty Program/Extension

ID-25-14 ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and Rocker Arm Replacements

23-008-25 REV. A

Service Bulletin/Repair Instructions

Exterior Front Lamps Condensation Clearing Procedure *Some customers may report that on occasion vehicle exterior front lamps (headlamps, fog lamps, grille lamps, logo lamps or signature lamps) assemblies are fogged with a light layer of condensation on the inside of the lenses*

31-001-25 REV. A

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

31-001-25

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates

S258A000017

Service Bulletin/Repair Instructions

Door speaker Inoperative or No Sound

21-009-25 REV. C

Service Bulletin/Repair Instructions

850RE D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch.

S2208000138 REV.B

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

S2323000002 REV.A

Service Bulletin/Repair Instructions

Washer Light On And Will Not Turn Off After Adding Washer Solvent.

9100570

Service Bulletin/Repair Instructions

Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Visible "glitter" or debris in the pan does not justify complete unit replacements.

21-009-25 REV. B

Service Bulletin/Repair Instructions

850RE D Clutch Repair **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must have at least 11,265 km (7,000 mi.) and exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear This bulletin involves replacing the D clutch.

9100390 Rev 1

Service Bulletin/Repair Instructions

D Clutch Repair Kit For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback.

9100471

Service Bulletin/Repair Instructions

CANISTER Vapor -If an issue is detected with the Evaporative System Integrity Module (ESIM) Detector and not the Vapor Canister, only replace the ESIM Detector. -Before replacing the Vapor Canister due to Hard to Fill condition, replicate the condition at the Gas Station. If the condition is replicated, then check: 1) for kinked or pinched Clean Air Hose between the ESIM and the EVAP Air Filter; 2) for plugged EVAP Air Filter; 3) for kinked or pinched Vapor Hose between the Fuel Tank and the Vapor Canister. If the EVAP Filter is restricted, the replace the Filter. -Check if the Vapor Canister is flooded with fuel or the Recirculation Line has fuel. If fuel is found in the Vapor Canister or the Recirculation Line, then drop the Fuel Tank, remove the FDM Lock Ring to check if the internal Vapor Line is properly connected to the FDM Port. If the Vapor Line is not connected, then drain the fuel from the internal Vapor Line and properly connect to the FDM. Replace the Vapor Canister and the ESIM.

103239

Service Bulletin/Repair Instructions

AIR BAG - SIDE CURTAIN

21-009-25 REV.A

Service Bulletin/Repair Instructions

D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear. This bulletin involves replacing the D clutch

9100494

Service Bulletin/Repair Instructions

FUEL PUMP/LEVEL UNIT MODULE For vehicles with Saddle Fuel Tanks, need to determine if there are any DTCs in wiTECH. Follow Service Diagnostics published prior to making any changes. Review any existing SOL or TSBs published for customer complaint issue. Only the Fuel Pump Module should be replaced if there are DTCs associated with the Fuel Level Sensor number 1. Only the Auxiliary Level Sender should be replaced if there are DTCs associated with the Fuel Level Sensor number 2. If there is a mixture of DTCs between the Fuel Pump Module and the Auxiliary Level Sensor, then investigate if there is a Jumper Harness or circuit issue between the Level Sender and the PCM. Verify fuel transfer between auxiliary tank and the primary tank by monitoring the auxiliary level sensor to verify it drops after driving.

21-009-25

Service Bulletin/Repair Instructions

D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. **Customers may also comment on one or more of the following: ● Transmission slips when shifting. ● Vehicle will not move in reverse. ● Vehicle will not shift higher than third gear.** This bulletin involves replacing the D clutch."

9100455

Service Bulletin/Repair Instructions

EXHAUST - MUFFLER AND TAILPIPE For Exhaust noise squeak during startup acceleration deceleration please do following: 1. DO NOT remove actuators 2. Verify noise by cycling EEV manually via WiTech 3. Verify noise with test drive (optional) 4. If the noise is confirmed, replace the system without removing the actuators.

21-039-24 REV. H

Service Bulletin/Repair Instructions

S2208000045 REV.B

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

S2208000045 REV.A

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

21-039-24 REV. G

Service Bulletin/Repair Instructions

21-039-24 REV. F

Service Bulletin/Repair Instructions

21-039-24 REV. E

Service Bulletin/Repair Instructions

S2423000024 REV.B

Service Bulletin/Repair Instructions

Door Ajar Light On With Door(s) Closed.

21-039-24 REV. D

Service Bulletin/Repair Instructions

S228A000017 REV.A

Service Bulletin/Repair Instructions

Battery Drain Suspected or "Identified" From USB or Media Hub

21-039-24 REV. C

Service Bulletin/Repair Instructions

100164

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

21-039-24 REV. B

Service Bulletin/Repair Instructions

31-001-24

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

99500

Other

CARRIER – PLANETARY & SHAFT KIT - OUTPUT

9100390 Rev1

Service Bulletin/Repair Instructions

D Clutch Repair Kit TSB 21-039-24 REV A - D-Clutch repair kit missing Carrier Output Shaft Seals It has been identified the Carrier Output Shaft is missing 2 seals for some of the kits delivered to dealers. These seals are not available individually. MOPAR is working to get the parts. Do not rebuild the transmission without these seals otherwise the vehicle will not have reverse. Please refer to STAR Online Publication S2421000001 for instructions for inspecting if the seals are present on the Output Shaft Carrier Shaft. If seals are missing, please return the D-Clutch Kit as defective and order another kit. Transmission replacement is not recommended as this issue should be solved with replacement kits

S2421000001

Service Bulletin/Repair Instructions

No Reverse And/Or Forward Gear After D-Clutch Repair.

9100390

Service Bulletin/Repair Instructions

98931

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

98933

Other

PUMP – WATER & CONNECTOR - OIL COOLER TUBE

S1408000384 REV.F

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

21-039-24 REV. A

Service Bulletin/Repair Instructions

D Clutch Repair Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P1DA8-00 - Incorrect Gear Ratio Clutch A B or D Defective. ● P1D92-00 - Incorrect Gear Ratio - Clutch 4 Defective. This bulletin involves replacing the D clutch.

S2423000024 REV.A

Service Bulletin/Repair Instructions

Door Ajar Light On With Door(s) Closed.

21-039-24

Service Bulletin/Repair Instructions

9100338REV1

Service Bulletin/Repair Instructions

GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c. Check Alternator B+ Stud connection to be sure nut is securing positive cable terminal properly (i.e. nut is clamping terminal & connection is tight). d. Check fuse between the alternator B+ stud & PDC terminal to make sure it is not blown. e. Be sure to follow service manual sections on ALTERNATOR CONTROL CIRCUIT DIAGNOSTIC & ALTERNATOR SENSE CIRCUIT DIAGNOSTIC looking for any opens & shorts (to ground or battery voltage). 2. Check/verify all grounds in the charging system circuit a. Check tightness of mounting bolts securing alternator to engine block. Alternator is a case ground component. b. Check main ground from engine to chassis; connection must be tight. c. Check battery ground cable connections are tight. d. Potentially, loosen alternator mounting bolts, without removing alternator, and re-tighten to torque specifications in service manual. e. After all steps above are complete, re-start engine & check charging system operation. 3. Verify that the Smart Charging System is not the reason for alternator low voltage & current output (Amps). a. Alternator charging can be suspended during engine idle operation because of the Smart Charge strategy. b. Refer to service manual section "System Operation - Smart Charging System". c. Refer to Star Case S2008000031 Rev A for low charging voltage & Smart Charge Mode Voltage Range diagram & mode descriptions. d. The alternator has no internal regulator; thus, has no smart circuitry. All alternator control signals come from ECM. 4. If alternator is faulty, remove alternator & mounting bolts. Return alternator with bolts for analysis at QEC.

9100344

Service Bulletin/Repair Instructions

VALVE BODY & CONTROL UNIT Transmission Ensure clutch pressure check has been completed and documented prior to valve body replacement.

0802824

Service Bulletin/Repair Instructions

Radio Over The Air Update from QR39.82F to QR40.12 Software Version Customer may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.82F to QR40.12. NOTE: National launch for this FOTA update is expected to begin Feburary 19, 2024.

S238A000028

Service Bulletin/Repair Instructions

Radio Black Screen, Freezing, Reset, Cutting Out Or Inoperative Intermittently

0802524

Service Bulletin/Repair Instructions

Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.2 to QR40.11. NOTE: National launch for this FOTA update is expected to begin February 19, 2023.

S1408000384

Service Bulletin/Repair Instructions

0824523

Service Bulletin/Repair Instructions

Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of the following: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from Q339.3 to QR39.62. NOTE: The National launch for this FOTA update campaign is expected to begin December 04, 2023.

S2308000146

Service Bulletin/Repair Instructions

Power Door Locks Passenger Rear Door Inoperative or Door Ajar Lamp on Passenger Rear Door

0823023

Service Bulletin/Repair Instructions

Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more of the following symptoms: ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.6 to QR40.12. NOTE: National launch for this FOTA update is expected to begin November 06, 2023.

S238A000048

Service Bulletin/Repair Instructions

Radio Reset After Clock Adjustment

9100229

Service Bulletin/Repair Instructions

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

9100226

Service Bulletin/Repair Instructions

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.

S2221000003

Service Bulletin/Repair Instructions

8-Speed Transmission, Additional Transmission Fluid Leak Inspection/Repair Guidelines.

S2307000002

Service Bulletin/Repair Instructions

Suspected engine coolant leak.

93023

Service Bulletin/Repair Instructions

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

93120

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

2400623

Service Bulletin/Repair Instructions

A/C Diagnostic LOP Change

S2108000093

Service Bulletin/Repair Instructions

Apple CarPlay Does Not Work Or Not Connecting

9100196

Service Bulletin/Repair Instructions

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

ZD7

Service Bulletin/Repair Instructions

Customer Satisfaction Notification ZD7 - Radio Software update

0818123

Service Bulletin/Repair Instructions

Radio Over The Air Updating to QR40.12 Software Version ? Mobile Wi-Fi inoperative upon start up. ? Hotspot gives "No Internet" connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.62 and QR39.57 to QR40.12. NOTE: National launch for this FOTA update is expected to begin August 16, 2023

S238A000034

Service Bulletin/Repair Instructions

USB Hub In-Operable

ReferenceZD7

Service Bulletin/Repair Instructions

Customer Satisfaction Notification ZD7 - Radio Software Update

BulletinA

Service Bulletin/Repair Instructions

Customer Satisfaction Notification ZD7 - Radio Software Update

0700723

Service Bulletin/Repair Instructions

Water Quality When Mixed With Engine Coolant

S238A000024

Service Bulletin/Repair Instructions

SOS, Assistance Calls Not Successful After Radio Replacement or Radio Software Update

2101123

Service Bulletin/Repair Instructions

Flash: Transmission Control Module (TCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set. ? P0729-00 - Gear 6 Shift Incorrect Ratio. Other software enhancement: ? Improved vehicle downshift and coast down performance. This bulletin involves reprogramming the TCM with the latest available software.

9100142

Service Bulletin/Repair Instructions

Mirror

0810223

Service Bulletin/Repair Instructions

Amplifier (AMP) Software Update

1400323

Service Bulletin/Repair Instructions

Diesel Exhaust Fluid (DEF) Fluid Freezing Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set: ? P203E-00 - Reductant Level Sensor 1 Circuit Intermittent-Erratic. This bulletin involves replacing the urea delivery module and grade vent valve and updating the Dosing Control Unit (DCU) software.

1804823

Service Bulletin/Repair Instructions

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

9100146

Service Bulletin/Repair Instructions

CAMERA, Rear View Please consult STAR Online S2208000045 prior to replacing the camera. Cameras must be inoperative or fail the blurry image test to be eligible for warranty. All parts must be returned for analysis. If parts are found to be working as designed and trouble not found, a chargeback may be applied. Prior to camera replacement, please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.

0806423

Service Bulletin/Repair Instructions

Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot gives 9No Internet9 connection message on phone, when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from QR39.7 to QR40.12. NOTE: National launch for this FOTA update is expected to begin March 10, 2023. DISCUSSION: Vehicles sold in the U.S. and Canada can now receive software updates ?over-the-air?. Updates to software will occur in a phased roll-out. The software is updated through the built-in cellular modem in the radio.

9003357A

Service Bulletin/Repair Instructions

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.

9003357a

Service Bulletin/Repair Instructions

S228A000028

Service Bulletin/Repair Instructions

Radio Remained On After Ignition Is Switched Off, Dead Battery From Excessive Radio Current Draw

9003357

Service Bulletin/Repair Instructions

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.

3100123

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

08-022-23

Service Bulletin/Repair Instructions

Radio Over The Air Updating to 40.12 Software Version Mobile Wi-Fi inoperative upon start up. Hotspot gives 9No Internet9 connection message on phone when trying to connect to a device. This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from 39.5 to 40.12.

08-008-23

Service Bulletin/Repair Instructions

UAS and UCS Radio Enhancements Customers may experience one or more of the following: **Wi-Fi hotspot connection failure. Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Mobile Station Integrated Services Digital Network (MSISDN) missing from radio, no connected services working.** Wireless connectivity pairing and/or connection issues. Lost radio presets. Radio channels change by itself. SXMT icon inoperative. SXMT favorite song not displaying/playing. High pitch squeal, pop or hum noise from speakers. Anti-theft code request message. Lines appear across screen. Radio will not switch modes between AM, FM, SAT or Media. Performance control home screen shows ?Norm? mode for engine/transmission even when the vehicle is in ?Drag? mode (LA, LD, LX only). Can not change the time on the clock (LA, LD and LX only). USB hub inoperable (D-Trucks only). Backup camera gridlines missing (D-Trucks only). Device not supported message (D-Trucks only). Remote app inoperative (D-Trucks only). Unable to adjust volume (D-Trucks only). Heated steering wheel inoperable (D-Trucks only). In addition, the following enhancement are included in this update: CarplayT connectivity improvements. Improvement to wireless connectivity phone pairing. Improved sound quality when using a wireless connectivity phone. **This bulletin involves inspecting and if required, updating the radio software level to 40.1. Depending on the radio?s current software level the radio may need a one or two USB update.**

S2323000002

Service Bulletin/Repair Instructions

Washer Light On And Will Not Turn Off After Adding Washer Solvent.

S2208000197

Service Bulletin/Repair Instructions

Cluster Message ?Service Air Suspension?

08-003-22 REV. A

Service Bulletin/Repair Instructions

UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. ? Mobile Station Integrated Services Digital Network (MSISDN) missing from radio, no connected services working.** ? Intermittent, black radio display screen (Rear View Camera (RVC) not affected). ? Intermittent, radio freezes (RVC not affected). ? Wireless connectivity pairing and/or connection issues. ? Lost radio presets. ? Radio channels change by itself. ? SXMT icon inoperative. ? SXMT favorite song not displaying/playing. ? Incorrect navigation address/location/directions. ? Backup camera has black display screen or only displays Check Entire Surroundings with black screen (occurs when vehicle is shifted immediately to reverse upon key-on before RVC signal is received, recoverable with key cycle) . ? High pitch chime noise. ? Contact list not loading. ? Device not supported message. ? Remote app inoperative. ? Travel-Link fuel price incorrect. ? Backup camera gridlines missing. ? Unable to adjust volume. In addition, the following enhancement are included in this update: ? Enables map updates. ? Heavy Duty (HD) Truck USB HUB improvements. ? HD Truck heated steering wheel improvements This bulletin involves inspecting and if required, updating the radio software level to 40.1. Depending on the radio?s current software level the radio may need a one or two USB update.

31-002-22

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Digital imaging pre authorization is required for Smart Warranty Base dealers or Pre Approval is required from Regional Office depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

9100008

Service Bulletin/Repair Instructions

Telematic box module 2

9100096

Service Bulletin/Repair Instructions

Base Headlamp Bright, Base Headlamp Black

S2208000138RevA

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

S2208000073RevA

Service Bulletin/Repair Instructions

No Start After a Flash or Powertrain Control Module (PCM), Body Control Module (BCM) Replacement

9100088

Service Bulletin/Repair Instructions

RADIO ASSY - AUDIO ENTERTAINMENT With the concern of performance page app not loading, or not working, please diagnose the issue per STAR Online S228A000032 before ordering a radio. You can contact FCA Redacted Content for further assistance.

Recall Notificat

Service Bulletin/Repair Instructions

Customer Satisfaction Notification Z74 Rear Axle

S2223000063

Service Bulletin/Repair Instructions

Ambient Temperature Sensor Servicing.

3100122

Service Bulletin/Repair Instructions

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.

S2208000138

Service Bulletin/Repair Instructions

Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed

S228A000004RevB

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S1708000246RevB

Service Bulletin/Repair Instructions

Security Gateway (SGW) Module Theory and Operation

S228A000004RevA

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S228A000004

Service Bulletin/Repair Instructions

Panasonic VP4R Wi-Fi New Enrollment Pause

S2223000035

Service Bulletin/Repair Instructions

Blind Spot System False Alerts. Blind Spot Indicator On In Mirror For No Reason.

9004509

Service Bulletin/Repair Instructions

Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold For concerns of V8 oil filter leaks on 22MY and up vehicles: 1. Clean the area and use oil dye to know the exact location of the leak with black/UV light. 2. Removal torque (force needed to loosen the filter) 3. If the source of the leak cannot be identified, please contact FCA Redacted Content to FasTrak parts back for analysis. If no response in 15 minutes, proceed with repair and email pictures of the following: A) Oil filter from the bottom to know if it has a "Factory Installed" filter. B) Leak. C) Damage in filter (if any) D) Gasket. E) Block or Oil Filter Adapter(OFA) or Engine Oil Cooler(EOC) sealing surface.

S2209000004

Service Bulletin/Repair Instructions

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

S2208000073

Service Bulletin/Repair Instructions

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

S1708000118

Service Bulletin/Repair Instructions

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

S1708000118 RevB

Service Bulletin/Repair Instructions

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

S2208000068

Service Bulletin/Repair Instructions

?Device Not Supported? Message on the radio screen

1801322

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs): U0101 - Lost Communication With TCM. U0102 - Lost Communication With Transfer Case Control Module / AWD. U0103 - Lost Communication With Electric Gear Shift Module. U0104 - Lost Communication With Cruise Control Module. U0125 - Lost Communication With Dynamics Sensor. U0128 - Lost Communication With Park Brake Control Module. U0129 - Lost Communication With Brake System Control Module 1. U0140 - Lost Communication With Body Control Module. U0141 - Lost Communication With Ipm (BCM). U0155 - Lost Communication With Cluster-CCN. U0159 - Lost Communication With Parking Assist Control Module. U017E - Lost Communication With Seatbelt Sensor 1. U0293 - Lost Communication With Hybrid Control Module. U0402 - Implausible Data Received From TCM. U0403 - Implausible Data Received From Tcase. U0405 - Invalid Data Received Cruise Control Module. U0416 - Implausible Data Received From ESP. U0418 - Implausible Data Received From Brake System Control Module 1. U0429 - Implausible Data Received From SCM. U0432 - Invalid Data Received From Multi-Axis Acceleration Sensor Module. U0594 - Implausible Data Received From HCP. U110A - Lost Communication With SCM-CAN-C. U1110 - Lost Vehicle Speed Message. U1120 - Lost Wheel Distance Message. U1141 - Lost ESP Torque Request Message. U1186 - Lost Communication With Adaptive Cruise Control Module. U11BC - Lost Brake Switch Message. U11C2 - Lost Transmission Message. U11DE - Lost Speed Control Message. U145D - Implausible Data Received From TCM On D-PT. Customers may also experience one or more of the following:Loss of shifting and or fixed third gear operation. Loss of Anti-lock Brake System (ABS), Traction Control System (TCS)

0800322

Service Bulletin/Repair Instructions

UAQ and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.5 Customers may experience one or more of the following: Intermittent, black radio display screen. Intermittent, radio freezes. Bluetooth® pairing and/or connection issues. Lost radio presets. Radio channels change by itself. SXM icon inoperative. In addition, the following enhancement are included in this update:Enables map updates.

08-102-21 REV. A

Service Bulletin/Repair Instructions

UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.5 Customers may experience one or more of the following: Performance control home screen shows "Norm" mode for engine/transmission even when the vehicle is in "Drag" mode. High pitch squeal, pop or hum from all speakers. SXM favorite, displays empty song list. Intermittent, black radio display screen. Intermittent, radio freezes. Bluetooth® pairing and/or connection issues. Lost radio presets. Radio channels change by itself. SXM icon inoperative.

S2108000204

Service Bulletin/Repair Instructions

Radio Lockup In The Software Installation Screen After Accepting FOTA Update (Incorrect "S2008000204" indicated on published document)

S2108000198

Service Bulletin/Repair Instructions

Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit

S2108000170

Service Bulletin/Repair Instructions

Head unit button stuck DTC code B14DA-2A

S2108000163

Service Bulletin/Repair Instructions

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

S2109000004

Service Bulletin/Repair Instructions

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

75745

Service Bulletin/Repair Instructions

HUB AND BEARING - WHEEL

75610

Service Bulletin/Repair Instructions

BASE - FLOOR CONSOLE

75567

Service Bulletin/Repair Instructions

LATCH - FRONT DOOR

0810221

Service Bulletin/Repair Instructions

UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.5 Customers may experience one or more of the following: High pitch squeal, pop or hum from all speakers. SXM favorite, displays empty song list. Intermittent, black radio display screen. Intermittent, radio freezes. Bluetooth® pairing and/or connection issues. Lost radio presets. Radio channels change by itself. SXM icon inoperative.

75490

Service Bulletin/Repair Instructions

CAMSHAFT - INTAKE

75227

Service Bulletin/Repair Instructions

MUFFLER AND TAILPIPE ? EXHAUST

S2125000002

Service Bulletin/Repair Instructions

Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM:

75446

Service Bulletin/Repair Instructions

GLASS - SUNROOF

S1809000007

Service Bulletin/Repair Instructions

Customer Complaint May Include Engine Oil Leak Or Consumption

S1809000007RevC

Service Bulletin/Repair Instructions

Customer Complaint May Include Engine Oil Leak Or Consumption

75267

Service Bulletin/Repair Instructions

TUBE - TURBO WATER FEED

S2108000098RevB

Service Bulletin/Repair Instructions

Radio Screen Freeze, Blank Screen And Reset

S2108000127 Rev.

Service Bulletin/Repair Instructions

Radio Reboot Continually

S2108000127-1

Service Bulletin/Repair Instructions

Radio Reboot Continually

S2108000127REVA

Service Bulletin/Repair Instructions

Radio Reboot Continually

S2108000127RevA

Service Bulletin/Repair Instructions

Radio Reboot Continually

S2108000130

Service Bulletin/Repair Instructions

Bubbles Or Delamination On The Radio Display

S2108000127

Service Bulletin/Repair Instructions

Radio Reboot Continually

08-083-21

Service Bulletin/Repair Instructions

Flash: Driver Door Module (DDM) and Passenger Door Module (PDM) Updates This bulletin involves reprogramming the DDM and PDM with the latest available software. This software is for vehicles on the RRT VIN List is to improve the function and reliability of the power windows operation.

0808321

Service Bulletin/Repair Instructions

S2108000098

Service Bulletin/Repair Instructions

Radio Screen Freeze, Blank Screen And Reset

S2108000098 Rev.

Service Bulletin/Repair Instructions

Radio Screen Freeze, Blank Screen And Reset

S1809000007 Rev.

Service Bulletin/Repair Instructions

Customer Complaint May Include Engine Oil Leak Or Consumption

S2108000109

Service Bulletin/Repair Instructions

Remote Key Fobs Only Work In Close Range

S1708000118 Rev.

Service Bulletin/Repair Instructions

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination After Key Off

S1608000226

Service Bulletin/Repair Instructions

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

S2008000113

Service Bulletin/Repair Instructions

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

S2008000113 Rev.

Service Bulletin/Repair Instructions

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

S16080002261

Service Bulletin/Repair Instructions

Battery Tester Warranty Code Procedures, Medtronic Update Process

S1821000001

Service Bulletin/Repair Instructions

Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders

3100121

Service Bulletin/Repair Instructions

Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required.

S2108000092

Service Bulletin/Repair Instructions

Comfort Seat Module Setting DTC B10C4 - 4B Heated Steering Wheel Control-Over Temperature

9004009

Service Bulletin/Repair Instructions

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.

S2108000080

Service Bulletin/Repair Instructions

Radio Replacement Reset Routine, Radio Has Missing Icons Or Are Grayed Out

S2008000173 Rev.

Service Bulletin/Repair Instructions

Center Console USB Ports Are Inoperative Due To Pinched Wiring Harness

S2008000173RevA

Service Bulletin/Repair Instructions

Center Console USB Ports Are Inoperative Due To Pinched Wiring Harness

S2124000004

Service Bulletin/Repair Instructions

A/C does not cool and vehicle is low on Freon charge but no leak is found with sniffer or black light anywhere in the system

S2108000068

Service Bulletin/Repair Instructions

Tire Pressure Lamp Turns On

08-031-21

Service Bulletin/Repair Instructions

Door Control Module Window Inoperative This bulletin involves replacing one or both of the front door modules. The technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set:B18BA-12 - Window Control - Circuit Short to Battery B18BA-13 - Window Control - Circuit Open In addition the customer may notice one or more of the following:Driver and/or passenger windows stop working. If the window switch is held in the up position for at least two seconds,the obstruction autodown function may not work. Windows may go up slower than expected.

0803121

Service Bulletin/Repair Instructions

9002236 Rev. A

Service Bulletin/Repair Instructions

SENSOR, Tire Pressure If replacing parts due to C1501-96, C1502-96, C1503-96, or C1504-96, contact FCA Redacted Content prior to repair. If no response within 15 minutes, proceed with repair. Please document concern, diagnosis and correction well on repair order or for a possible follow-up call to clearly understand the issue.

9002236RevA

Service Bulletin/Repair Instructions

S2108000045

Service Bulletin/Repair Instructions

Favorite Song On-Air Alert List Empty

9004342

Service Bulletin/Repair Instructions

WINDSHIELD Windshield cracked or blemish. When customer comes in for a cracked windshield, please note the location of crack and take pictures before repair. Please send pictures to FCA Redacted Content or load to the warranty claims system.

S2108000001

Service Bulletin/Repair Instructions

Intermittent No Crank, Multiple CAN Communication Faults Present

S2008000182 Rev.

Service Bulletin/Repair Instructions

Driver Or Passenger Power Windows Do Not Go Up Or Down

9004334

Service Bulletin/Repair Instructions

Power Window Regulator or Motor Owners may complain that the Driver and or Passenger Windows are inoperative. Technician may find DTC?s B18BA-12 - Window Control - Circuit Short to Battery, B18BA-13 - Window Control - Circuit Open (stored or active). Replace the DDM or PDM per detailed repair information in Service Library or reference Star Online Publlication S2008000182. Replacing regulators or motors will not correct this issue.

S2008000182

Service Bulletin/Repair Instructions

Driver Or Passenger Power Windows Do Not Go Up Or Down

9003637

Service Bulletin/Repair Instructions

USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Verify the functionality of these applications using an OEM Apple Lightning cable or an OEM provided USB cable for Android phones before performing any additional troubleshooting. For questions regarding Android Auto or Apply Carplay functionality, please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair.

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.