Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003623
Wiper If Mopar OE wipers are unavailable, the below alternatives can be offered instead. 05066964A$ = WBRW0011A$ 05066973A$ = WB000019A$ or WBF00019A$ 05096134A$ = WB000027A$ or WBF00028A$ 55154762A$ = WB000013A$ 68001330A$ = WB000019A$ or WBF00019A$ 05012611A$ = WB000021A$ or WBF00021A$ 05102881A$ = WBRW0011A$
23027
Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.
23104
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
23137
Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
20244
CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.
Volume 2, Issue
Warranty Operations Newsletter Updates from Warranty Operations
22867
Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22892
Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22958
1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
20616
P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement part can be obtained by ordering the same part number (CBSZR068AA) Please return suspect parts back to your facing depot using Return Code 02, before 02 September, 2016.
R2118796A
Valve Body. These may cause over drive cycling.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0800107
PASSENGER AIR BAG DEACTIVATION. *KB
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
0802801
MOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION. *TT
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
0600105
TRANSMISSION GEAR RATTLE SOUND AT IDLE. *TT
0300604
FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT
1900304
STEERING COLUMN CLICK SOUND. *TT
1802004
FLASH: ENGINE SAG OR ROUGH IDLE OR VEICHLE SURGE AT ENGINE SPEEDS AROUND 3000 RPM. *MJ
1900402
STEERING COLUMN CLICK SOUND. *MJ
0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
2304602
REAR CHILD SEAT LOWER ANCHOR TOO LARGE. *TT
0800802
SUBJECT REGARDING EXCESSIVE IGNITION OFF DRAW VOLTAGE. *SLC
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2200102
CHROME WHEEL CARE. *SLC
2300402
SUBJECT REGARDING FRONT WINDOW REGULATOR SQUEAK. *TT
1802701
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT
1900601A
EXPERIENCING STEERING COLUMN CLICK SOUND WHEN THE STEERING WHEEL IS TURNED. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
1900601
SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *TT
1400101A
A CONDITION MAY EXIST IN WHICH THE FUEL GAUGE DOE SNOT REGISTER FULL EVEN THOUGH THE FUEL TANK IS FULL. *TT
2301001
SUBJECT REGARDING SUNROOF WIND DEFLECTOR VIBRATION. *TT
0801301
SUBJECT REGARDING RADIO CONNECTOR REPAIR KIT. *TT
2600601
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES REQUIRING HAND WRITTEN CHANGES TO EXISTING PAGES. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2300801
A CONDITION MAY EXIST WHEN THE HVAC UNIT BLOWER IS TURNED ON HIGH, A TICKING SOUND CAN BE HEARD FROM THE REAR SEATING POSITION. THE CAUSE OF THE TICKING SOUND IS THE BODY EXHAUSTER FLAPS HITTING THE BODY EXHAUSTER HOUSING RETAINER. THIS BULLETIN INVOLVES REPLACING THE REAR BODY EXHAUSTER ON VEHICLES THAT EXHIBIT THE SYMPTOM. *TT
0900301
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES. *TT
2600501
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES. *TT
2600401
SUBJECT REGARDING SERVICE / DIAGNOSTIC MANUAL REVISIONS. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
1400101
CUSTOMERS MAY COMPLAIN THAT FUEL GUAGE WILL NOT INDICATE FULL. *JB
2300301
THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201. *TT
01001
SOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE. *JB
0700400
INFORMATION REGARDING TRANSAXLE COOLER LINE SPLICE KIT. *JB
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0803700
THIS BULLETIN INVOLVES THE SERVICE OF THE FOAM RUBBER PADS UNDER THE DRIVERS AIRBAG RETENTION CLIPS. *TT
0803800
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
2303600
CUSTOMERS MAY COMPLAIN OF LOOSE OR MISSING STANCHION COVERS ON ROOF RACK. *TT
0803600
SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE. *TT
0803400
SUBJECT REGARDING PDC RELAY REMOVER / INSTALLATION TOOL. *TT
0803300
SOME VEHICLES MAY EXHIBIT A FAULT CODE IN THE RADIO WHEN PERFORMING DIAGNOSTIC USING THE DRB III. THE CODE READS COLD CD. THE FAULT CODE IS NOT DISPLAYED TO THE CUSTOMER AND IS ONLY DISPLAYED WHEN PERFORMING DIAGNOSTICS. *TT
00062
ADVANCE SERVICE INFORMATION REGARDING UNDER-SEAT STORAGE BIN RETROFIT. *TT
00057
SOME VEHICLES MAY EXHIBIT A CONDITION DESCRIBED BY CUSTOMERS AS FUEL TANK CANNOT BE FILLED TO FULL, GAS PUMP SHUTS OFF BEFORE TANK IS FULL, OR GAUGE DOES NOT INDICATE FULL. *TT
00055
ADVANCE SERVICE INFORMATION REGARDING STEERING WHEEL FOAM PAD INSTALLATION. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
0048
CUSTOMERS MAY COMPLAIN OF LOOSE OR MISSING STANCHION COVERS ON THE ROOF RACK OF CERTAIN VEHICLES. *TT
181800
SUBJECT REGARDING DRIVEABILITY IMPROVEMENTS / SYSTEM ENHANCEMENTS. *TT
0043
DUE TO A DELAMINATION PROBLEM, THE ACCESSORY DRIVE BELT FOR THE POWER STEERING PUMP AND A/C COMPRESSOR MAY REQUIRE REPLACEMENT. *TT
140400
A CONDITION MAY EXIST WHERE THE VEHICLE IS HARD OR SLOW TO START. *TT
180400
THE CUSTOMER WILL NOTICE AN ERRONEOUS MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH P0441 - EVAP PURGE FLOW MONITOR FAILURE. *TT
231600
THE FRONT DOOR WATER DAM MAY CONTACT THE SPEAKER AND CREATE A BUZZ / HUM TYPE SOUND. *TT
231400
INFORMATION CONCERNING CARGO NET INSTALLATION INSTRUCTIONS. *TT
081400
CUSTOMER MAY REPORT THAT THE FUEL GAUGE NEEDLE DOES NOT REACH THE FULL MARK WITH THE FUEL TANK FULL, EVEN AFTER TOPPING THE TANK OFF. *TT
0018
SOME VEHICLES MAY EXHIBIT WIND BUFFETING WITH THE WINDOWS AND / OR SUNROOF IN CERTAIN OPEN OR PARTIALLY OPEN POSITIONS. *TT
050200
SUBJECT REGARDING REVISED PARKING BRAKE EQUALIZER ASSEMBLY REMOVAL PROCEDURES. *TT
0017
SUBJECT REGARDING OWNERS MANUAL ADDENDUM ITEMS. *TT
190200
BRIEF INFORMATION REGARDING IGNITION LOCK CYLINDER SERVICE. *TT
080400
SUBJECT REGARDING LIGHT BULB APPLICATIONS AND REPLACEMENT INFORMATION. *TT
030100
SUBJECT PERTAINING TO DRIVESHAFT REMOVAL INFORMATION. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.