103954
Service Bulletin/Repair Instructions
ACTUATOR - A/C AND HEATER
Vehicle report
2007 CHRYSLER SEBRING
Service bulletins
56 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
104087
Service Bulletin/Repair Instructions
ACTUATOR - A/C AND HEATER
9100226
Service Bulletin/Repair Instructions
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
9004009
Service Bulletin/Repair Instructions
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
S1121000006 Rev.
Service Bulletin/Repair Instructions
(Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
S1121000006RevA
Service Bulletin/Repair Instructions
(Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
23-015-20
Service Bulletin/Repair Instructions
Disinfectant Solution Recommended for COVID-19
08-049-20
Service Bulletin/Repair Instructions
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003687
Service Bulletin/Repair Instructions
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
9003623
Service Bulletin/Repair Instructions
Wiper If Mopar OE wipers are unavailable, the below alternatives can be offered instead. 05066964A$ = WBRW0011A$ 05066973A$ = WB000019A$ or WBF00019A$ 05096134A$ = WB000027A$ or WBF00028A$ 55154762A$ = WB000013A$ 68001330A$ = WB000019A$ or WBF00019A$ 05012611A$ = WB000021A$ or WBF00021A$ 05102881A$ = WBRW0011A$
23027
Service Bulletin/Repair Instructions
Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.
23104
Service Bulletin/Repair Instructions
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
23137
Service Bulletin/Repair Instructions
Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
20244
Service Bulletin/Repair Instructions
CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.
Volume 2, Issue
Service Bulletin/Repair Instructions
Warranty Operations Newsletter Updates from Warranty Operations
22867
Service Bulletin/Repair Instructions
Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22892
Service Bulletin/Repair Instructions
Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22958
Service Bulletin/Repair Instructions
1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
20616
Service Bulletin/Repair Instructions
P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement part can be obtained by ordering the same part number (CBSZR068AA) Please return suspect parts back to your facing depot using Return Code 02, before 02 September, 2016.
05170303A
Service Bulletin/Repair Instructions
Housing cover mounting bolt holes use self-tapping fasteners. New fasteners are required with housing replacement.
R2118796A
Service Bulletin/Repair Instructions
Valve Body. These may cause over drive cycling.
68018095A
Service Bulletin/Repair Instructions
HVAC Distribution Housing
RL108213A$
Service Bulletin/Repair Instructions
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
R2108213A$
Service Bulletin/Repair Instructions
W5A580 (NAG1) Valve Body - complete
9003215
Service Bulletin/Repair Instructions
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002887
Service Bulletin/Repair Instructions
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
9002519
Service Bulletin/Repair Instructions
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
09-001-13
Service Bulletin/Repair Instructions
Gasoline Engine Diagnostic Inspection Procedure This bulletin provides a procedure to determine repair versus replacement of a gasoline long block engine assembly. This procedure is to be used prior to conducting any engine related repairs or removal of engine components.
78
Service Bulletin/Repair Instructions
STAR Center News No. 78 - Jan/Feb 2013: Instead of limiting the use of the tether anchor to 48 pounds (child weight) the new guideline states that the tether anchor can be used with a seatbelt to install a child restraint up to the recommended weight limit of the child restraint.
CSN-K16
Service Bulletin/Repair Instructions
CHRYSLER DODGE SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AUTOMATIC TRANSMISSION SHIFT LEVER INTERLOCK SPRING. TRANSMISSION GEAR SHIFT LEVER INTERLOCK SPRING RETAINER HOOK ON VEHICLES MAY BREAK. A BROKEN INTERLOCK SPRING RETAINER HOOK WILL RESULT IN THE INABILITY TO MOVE THE GEAR SHIFT LEVER OUT OF THE PARK POSITION. CSC LETTER WAS REC'D. *PE
SB-1800309 REVC
Service Bulletin/Repair Instructions
CHRYSLER/JEEP/DODGE: FLASH-DRIVEABILITY IMPROVEMENTS OR MIL ILLUMINATION DIAGNOSTIC TROUBLE CODE P0452-EVAP PRESSURE SWITCH STUCK CLOSED. INCLUDES MY09 TOWN&COUNTRY; VOYAGER AND CARAVAN. *PE
H 11
Service Bulletin/Repair Instructions
CHRYSLER DODGE JEEP SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CUSTOMER SATISFACTION NOTIFICATION H11; RADIO SOFTWARE UPDATE. THIS NOTIFICATION APPLIES ONLY TO VEHICLES EQUIPPED WITH A MYGIG RADIO (SALES CODE RER WITH NAVIGATION SYSTEM OR REN WITHOUT NAVIGATION SYSTEM). CSC WAS RECEIVED. *PE
08-031
Service Bulletin/Repair Instructions
DVD SOFTWARE UPDATE MYGIG RADIO FOR MANY RADIO FUNCTIONAL ISSUES AND IMPROVEMENTS. *NJ
08-007-08
Service Bulletin/Repair Instructions
NO ENGINE CRANK OR NO ENGINE START DUE TO ELECTRONIC LOCKUP OF THE WCM/SKREEM. *NJ
2100207
Service Bulletin/Repair Instructions
TORQUE CONVERTER SHUDDER / SHIFT QUALITY IMPROVEMENTS / DTC P0732. *KB UPDATED 08-13-07. *KB UPDATED 01/09/08. *NJ UPDATED 3/7/08. *NJ
2100308
Service Bulletin/Repair Instructions
FLASH: TORQUE CONVERTER SHUDDER WITH COORDINATED CHANGE OR SHIFT QUALITY IMPROVEMENTS. *NJ
07050
Service Bulletin/Repair Instructions
SPEED SENSOR WIRE HARNESS MODIFICATION. *NJ
2304207
Service Bulletin/Repair Instructions
REAR GLASS COMES OUT OF TRACK - VEHICLES BUILT BEFORE 11/4/07. *NJ
2304106
Service Bulletin/Repair Instructions
EXTERIOR LAMP - LENS FOGGING. *NJ
0500407
Service Bulletin/Repair Instructions
FLASH ESP/TRACTION CONTROL SENSITIVITY ON TIGHT CURVES *NJ
23
Service Bulletin/Repair Instructions
EMISSIONS RECALL REPROGRAM TIPM - TRANSMISSION DEFAULT. TOTALLY INTEGRATED POWER MODULE (TIPM) WAS INADVERTANTLY PROGRAMMED WITH SOFTWARE THAT MAY PREVENT THE TRANSMISSION FROM SHIFTING PROPERLY. *KB
0801007
Service Bulletin/Repair Instructions
STEERING ANGLE SENSOR - NOT INITIALIZED/INTERNAL. *KB
2100807
Service Bulletin/Repair Instructions
HARSH TRANSMISSION ENGAGEMENT OR CLUNK WHEN SHIFTING OUT OF REVERSE OR FROM DRIVE, THROUGH REVERSE INTO PARK. *KB
07001
Service Bulletin/Repair Instructions
TORQUE CONVERTER SHUDDER PREVENTION / SHIFT QUALITY IMPROVEMENTS. *KB
06059
Service Bulletin/Repair Instructions
LADDER FRAME INSPECTION / LONG BLOCK REPLACEMENT. *KB
1803306
Service Bulletin/Repair Instructions
MIL ILLUMINATION/GENERATOR LAMP ILLUMINATION/ OIL PRESSURE LAMP ILLUMINATION/DRIVEABILITY IMPROVEMENTS. *KB
2304706
Service Bulletin/Repair Instructions
CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE. *KB
06048
Service Bulletin/Repair Instructions
OIL INDICATOR LAMP MOMENTARY ILLUMINATION OR FLICKER AT IDLE. *KB
2200406
Service Bulletin/Repair Instructions
TIRE PRESSURE MONITOR SYSTEM INFORMATION. *KB
0803006
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.