14V600000
EQUIPMENT ADAPTIVE/MOBILITY Recall
Collins Bus Corporation (Collins) is recalling certain model year 2006-2014 Collins and Mid Bus Super Bantam, Grand Bantam, Super Guide, Grand Guide, DE416WR, DH416WR, and DE516WR school buses manufactured January 1, 2006, to June 16, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.
Remedy: Collins will notify owners, and dealers will install a supplemental platform support bumper kit. Any platform that has already started cracking will be replaced, free of charge. The began on December 15, 2014. Owners may contact Collins customer service at 1-800-533-1850 or Ricon customer service at 1-800-322-2884.
13V469000
ELECTRICAL SYSTEM Recall
Collins Bus Corporation (Collins) is recalling certain model year 2009-2010 Bantam, Super Bantam, Grand Bantam, Mid Bus Guide, Super Guide, and Grand Guide school buses manufactured September 2009 through April 2010, and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.
Remedy: Collins will notify owners, and dealers will inspect and, if necessary, replace the circuit board free of charge. The recall began on December 4, 2013. Owners may contact Collins at 1-800-533-1850.
11V293000
SEATS Recall
COLLINS IS RECALLING CERTAIN MODEL YEAR 2002-2011 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM OCTOBER 2002 THROUGH MAY 20, 2011, FOR FAILING TO CONFORM TO THE LEG PROTECTION ZONE IMPACT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 222 "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
Remedy: COLLINS WILL NOTIFY OWNERS AND DEALERS WILL INSTALL ADDITIONAL FOAM PADDING UNDER THE UPHOLSTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 18, 2011. OWNERS MAY CONTACT COLLINS BUS AT 1-800-533-1850.
10V441000
OTHER:SCHOOL BUS STOP ARM ASSEMBLY Recall
COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 SUPER BANTAM AND GRAND BANTAM AND MID BUS SUPER GUIDE AND GRAND GUIDE SCHOOL BUSES BUILT ON FORD AND CHEVROLET PLATFORMS FROM MARCH 31, 2008 THROUGH JULY 31, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.
Remedy: COLLINS WILL NOTIFY OWNERS AND LIGHT KITS WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 17, 2010. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850.
10V049000
EXTERIOR LIGHTING:BRAKE LIGHTS Recall
COLLINS IS RECALLING CERTAIN MODEL YEAR 2009 BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES MANUFACTURED BETWEEN APRIL 1 AND OCTOBER 1, 2009, BUILT ON FORD CUTAWAY CHASSIS. THE BRAKE-TURN SEPARATOR MODULE WHICH IS USED TO CONTROL THE BRAKE LIGHTS AND TURN SIGNALS LIGHTS IN THE REAR MAY NOT ALWAYS DISTINGUISH CORRECTLY BETWEEN A BRAKE SIGNAL INPUT AND A TURN SIGNAL INPUT FROM THE FORD CHASSIS OEM WIRING. FOR TYPICAL BRAKE AND TURN SIGNAL OPERATION, THE STOP/TAIL/TURN LIGHTS AT THE REAR OF THE BUS WILL FUNCTION PROPERLY. HOWEVER, IF THE BRAKES ARE PUMPED/APPLIED IN A FREQUENCY MATCHING THAT OF THE BLINKING TURN SIGNAL WHILE THE TURN INDICATOR IS ON, THERE IS THE POTENTIAL THAT THE BRAKE SIGNAL THROUGH THE MODULE MAY CANCEL OUT THE TURN SIGNAL TEMPORARILY OR CAUSE IT TO FLASH INTERMITTENTLY.
Remedy: COLLINS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE BRAKE-TURN SIGNAL SEPARATOR MODULE, IF THE BUS IS EQUIPPED WITH ONE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2010. OWNERS MAY CONTACT COLLINS TOLL-FREE AT 1-800-533-1850 EXT. 424.