Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
0500106A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB
0500305
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
0500204
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
1900303
POP/TICK SOUND IN STEERING WHEEL AREA. *TT
2304402
COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT
0500102A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT
0801102
CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
1900801
EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT
0700601
SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE. *TT
0900801
SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0200401
EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
0500301
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. *TT
0500101
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. THIS CONDITION CAN LEAD TO TEMPORARY FREEZING OF THE REAR BRAKE LININGS TO THE DRUMS. *TT
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
2304200
EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED. *TT
2601000
INFORMATION REGARDING UPDATES TO THE FUEL SYSTEM SERVICE PROCEDURES. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
231100A
A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT
231100
THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
190999
A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
180200
CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS. *TT
051099
INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS. *TT
084599
VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
050999
INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
182299
SOME VEHICLES MAY EXHIBIT INTERMITTENT MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH HEX CODE $1B (P0123) THROTTLE POSITION SENSOR (TPS) VOLTAGE HIGH. *TT
190699
INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE. *TT
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
082799
CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE. *TT
140399
EXPERIENCING VIBRATION / BUZZ IN THE ACCELERATOR PEDAL AT 2200 - 2500 RPM AND ABOVE 3500 RPM. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
230199A
EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT
070299
CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY. *TT
220399
SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION. *TT
220299
CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE. *TT
210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT
210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
180599
CONCERNS WITH SAGS / HESITATION / STUMBLE / START & STALL, A/C BUMP IMPROVEMENTS, ADDITION OF LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
230399
CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE. *TT
795
EMISSIONS RECALL -- VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *TT
230199
SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
090798
SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK. *YC
235998
WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR. *AK
090198 REV B
VEHICLE EXPERIENCING A TICKING NOISE WHILE AT IDLE FROM ENGINE. *YC
090598
A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
980801260898
SERVICE MANUAL REVISIONS. *YC
030698
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK
021098
A SQUEAKING / CHIRPING NOISE IS HEARD ( INSIDE OR OUTSIDE THE VEHICLE ) FROM THE STRUT TOWER AREA( S ). *YC
084098
SUBJECT REGARDING BODY CONTROL MODULE AUTO HEADLAMP SENSOR/ SIGNAL CIRCUIT DIAGNOSTIC TROUBLE CODE (DTC). *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
081798 REV B
SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC
020998
RATTLE NOISE FROM REAR OF THE VEHICLE WHEN DRIVING OVER ROAD BUMPS. *AK
190598
A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS. *YC
9843
EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION. *YC
233498
THE FRONT DOOR BODY MOUNTED WEATERSTRIP FALLS OFF MOUNTING FLANGE, USUALLY ALONG THE TOP OF THE DOOR OPENING. *YC
241198
SUBJECT REGARDING A/C SUCTION AND / OR DISCHARGE LINE REQUIRES REPLACEMENT DUE TO CRACKING AT OR NEAR COMPRESSOR. *AK
082798
PERCEIVED LOSS OR CAHNGE OF RADIO STATION PRESETS. *AK
980424231498
SYMPTOMS WITH ROOF RACK RATTLES AT HIGHWAY SPEEDS. *YC
9830
SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT. *YC
240798
CONDITIONS WITH A/C COMPRESSOR LOCK-UP AT LOW MILEAGE. *YC
9827
INFORMATION ON BODY CONTROL MODULE (BCM) REPLACEMENT. *YC
98771
THE RADIATOR FAN RELAY MAY NOT TURN ON THE RADIATOR COOLING FANS, CAUSING ENGINE TO OVERHEAT. *AK
210798
SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK
220298
*DURING LOW SPEED VEHICLE EXPERIENCES SIDE TO SIDE OSCILLATION/WOBBLE WHILE DRIVING BETWEEN 10-45MPH. *AK
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
090198
SOME VEHICLES MAY EXPERIENCE A CONDITION WHERE THE VALVE TRAIN MAKES A TAPPING NOISE. *YC
110598
SOME VEHICLES MAY PRODUCE A HIGH PITCHED WHISTLE NOISE DURING WIDE OPEN THROTTLE ACCELERATION. *YC
110398
INFORMATION ON REMOVAL OF THE EXHAUST DRONE. *YC
1812098
SUBJECT ON TIP-IN SAGS/HESITATIONS OR ROUGH IDLE AFTER A HOT SOAK RESTART. *YC
9814
CONDITION WITH THE SOFTWARE WITHIN THE POWERTRAIN (PCM) MAY NOT OPERATE THE SOLID STATE RELAY FOR THE RADIATOR FAN CORRECTLY. *YC
220198
INFORMATION ON VEHICLE ALUMINUM WHEELS HAVING A UNIQUE BALANCE WEIGHT RETENTION FLANGE. *YC
210398
SUBJECT ON TRANSAXLE DESENSITIZATION TO INTERMITTENT FAULTS / DRIVEABILITY IMPROVEMENTS. *YC
987591/7592
VARIOUS INFORMATION ON VECI LABEL REPLACEMENT. *YC
183397
SUBJECT REGARDING IMPROPER COOLING FAN RELAY ACTUATION. *YC
090997
INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM
191497
THIS BULLETIN INVOLVES INTERMITTENT POPPING ON FRONT END. *NLM
236997
THIS BULLETIN INVOLVES SEAT BACK CREAK NOISE - DRIVERS SIDE. *NLM
084097
INFORMATION ON BODY CONTROL MODULE AUTO HEADLAMP SENSOR/SIGNAL CIRCUIT DIAGNOSTIC TROUBLE CODE (DTC). *NLM
191197
CONCERNS WITH "HONK" NOISE DURING PARKING LOT MANEUVERS. *NLM
230197
CREAK SOUND HEARD UPON ACCELERATION AND/OR DECELERATION- SOUND SEEMS TO COME FROM FLOORPAN/DASH AREA. *JD
23097 A
TEST
083997
VEHICLE MAY EXPERIENCE REMOTE KEYLESS ENTRY TRANSMITTER BATTERIES DISCHARGE PREMATURELY. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
020997A
CONCERNS WITH THUMPING NOISE AT REAR OF VEHICLE DURING COLD OPERATION. *NLM
181997A
EXHIBITING A PERIODIC BUMP IN POWER TRAIN WHEN THE A/C IS OPERATING
190197
SOME VEHICLES EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING WHEN TURNING CORNERS WITH THE A/C OR DEFROSTER
235297
SOME VEHICLES MAY HAVE A MARGINAL OR PARTIAL BOND OF THE BACKLIGHT TO THE LIFTGATE THAT MAY DEVELOP INTO A WATER LEAK. *YC
234397A
CONCERN WITH WATER LEAK ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING. *NLM
970912234397
WATER LEAKS ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING. *YC
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
190197A
DURING HIGH HUMIDITY CLIMATE CONDITIONS, SOME VEHICLES MAY EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING WHEN TURNING CORNERS WITH THE A/C OR DEFROST
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.