Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
DOR-X6W2U-06
This SKU is a Clock Spring. The customer communication requested return of unsold inventory to inspect the internal spring. If the internal spring is not seated, the electrical circuit for the horn is disconnected and the horn will not function. The horn electrical circuit does not affect the airbag circuit.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
03004
INOPERATIVE ANTI-LOCK BRAKE SYSTEM (ABS) SOFTWARE REPROGRAMMING. ADVANCE SERVICE INFORMATION #03-004. *TT
2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
1801702
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR INJECTOR CIRCUIT FAULT. *SLC
1801802
SUBJECT REGARDING FLASH: NOX EMISSION FAILURE WHEN PERFORMING AN ASM TYPE I/M EMISSION TEST. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
1800402
SUBJECT REGARDING 1999 MY ENGINE SPARK KNOCK. *TT
1803001
SUBJECT REGARDING 46RE SHIFT QUALITY AND DURABILITY IMPROVEMENTS. *TT
2401301
SOME VEHICLES MAY BLOW WARM AIR OUT THE INSTRUMENT PANEL OUTLETS WHILE THE A/C IS ON AT IDLE. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2500401
SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT
2600501
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
180600C
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT TO MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
0200600
SUBJECT REGARDING UPPER CONTROL ARM BUSHING SERVICE. *TT
2304000
SOME VEHICLES MAY EXHIBIT A REAR DOOR LOCK(S) THAT DO NOT OPERATE PROPERLY. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
233400
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
030800
;SUBJECT REGARDING RTV USE ON CORPORATE AXLE. *TT
180600B
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
082400
ON SOME VEHICLES THE ENGINE CRANKS BUT DOES NOT START OR STARTS AND STALLS. *TT
020500
SOME CUSTOMERS MAY COMMENT ABOUT A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT
081000
EXPERIENCING A DEAD BATTERY AND / OR IGNITION OPERATED ELECTRICAL ACCESSORIES FUNCTION WITH THE IGNITION SWITCH OFF. *TT
080800
CONCERNS WITH AN INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
030200
SUBJECT PERTAINS TO 9.25 AXLE GEAR MARKING COMPOUND CAUSING A MILKY-LIFE APPEARANCE TO THE AXLE FLUID. *TT
080700
SOME VEHICLES MAY EXHIBIT AN ERRONEOUS MALFUNCTION INDICATOR LAMP DUE TO DIAGNOSTIC TROUBLE CODE P0443 (PURGE CKT) AND / OR A POSSIBLE KEY-OFF BATTERY DRAW. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
020699A
THIS BULLETIN MENTIONS THAT THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT
242099A
A CONDITION MAY OCCUR WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAN THAT OF THE FLOOR VENTS. *TT
182599
INFORMATION ON ERRONEOUS ENGINE MISS WHILE PERFORMING DIAGNOSTICS WITH THE DIAGNOSTIC SCAN TOOL (DRB III). *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
235299
SUBJECT REGARDING A SQUEAK HEARD COMING FROM THE WINDOW AREA AS THE WINDOW IS ROLLED DOWN. *TT
021599
EXPERIENCING A SQUEAK NOISE COMING FROM REAR LEAF SPRING. *TT
070399
SOME VEHICLES MAY EXPERIENCE A HIGH ENGINE TEMPERATURE CONDITION. *TT
242099
SUBJECT REGARDING VEHICLES THAT EXPERIENCE WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAT THAT OF THE FLOOR VENTS. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
241999
SUBJECT REGARDING AIR CONDITIONING PERFORMANCE. *TT
233299
CONCERNS WITH THE CENTER CONSOLE / ARMEST LID HINGE BEING BENT. *TT
241199
SUBJECT ON AIR CONDITIONER COOLING PERFORMANCE DETERIORATING AFTER A FEW MINUTES OF OPERATION. *TT
9912A
SUPPLEMENTAL INFORMATION REGARDING REPAIR PROCEDURE CHANGE FOR VEHICLES WITH AN INCORRECT AXLE RATIO IDENTIFIED ON THE MONRONEY LABEL. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
020599
EXPERIENCING SQUEAKING OR CREAKING FROM FRONT WHEEL AREA AT LOW SPEEDS. *TT
020699
ON SOME VEHICLES THE FRONT WHEEL BEARINGS MAY INCORRECTLY BE DIAGNOSED AS FAULTY DUE TO THE EVIDENCE OF WHEEL BEARING GREASE ON THE BEARING SEAL AREAS. *TT
081699A
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
030499
CONDITIONS WITH DIFFERENTIAL GEAR LUBRICANT WEEPING FROM THE FRONT DIFFERENTIAL VENT. *TT
081699
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
180999
INFORMATION PERTAINING TO COMMON DIAGNOSTIC TROUBLE CODES CAUSED BY AN OPEN FUSE. *TT
9923
CONDITIONS MAY EXIST WHERE OIL SEEPAGE PAST THE ENGINE OIL FILTER ADAPTER PLATE GASKET. *TT
180799
EXHIBITING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $A8 (P1763) GOVERNOR PRESSURE SENSOR VOLTS TOO HIGH. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
050399
INFORMATION REGARDING FRONT BRAKE CALIPER MOUNTING TO STEERING KNUCKLE THREAD REPAIR. *TT
231299
CONCERNS WITH CENTER CONSOLE / ARMREST COVER WILL NOT LATCH. *TT
9912
SUBJECT REGARDING INCORRECT AXLE RATIO INFORMATION ON THE MONRONEY LABEL. *TT
240599
SUBJECT REGARDING REAR A/C UNIT BLOWS WARM AIR WHEN AMBIENT TEMPERATURES ARE HIGH. *TT
240499
INFORMATION ON LEAK DETECTION DYE ADDED TO THE AIR CONDITIONING SYSTEM. *TT
230299
CUSTOMER MAY COMMENT THAT THE CENTER ARMREST LID RATTLES. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
184898
SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK
183598
EXHIBITING MIL ILLUMINATION WITH DTC $ 12 (P0443) - EVAPORATIVE PURGE SOLENOID CIRCUIT FAILURE, CAN BE CAUSED BY ELECTRICAL NOISE GENERATED THROUGH THE IGNITION SWITCH. *AK
183698
SOME VEHICLES MAY EXHIBIT AN IDLE UNDERSHOOT OR DIE OUT DURING ENGINE STARTING AND MAY BE CAUSED BY IAC LOST STEPS. *AK
183798
SOME CONSUMERS THAT INADVERTENTLY FLOOD THEIR ENGINES DURING STARTING MAY TRY TO PERFORM A CLEAR FLOOD PROCEDURE TO HELP START THEIR VEHICLES. *AK
085298
INFORMATION REGARDING THE FOG LAMP SERVICE. *YC
211698
REVISED FRONT BAND ADJUSTMENT FOR 42RE TRANSMISSIONS. *YC
070798
ENGINE OVERHEATING IN HIGH AMBIENT TEMPERATURES.*AK
241698
SUBJECT REGARDING REAR OVERHEAD AIR CONDITIONING PERFORMANCE TESTING. *YC
021198
INFORMATION ON ALIGNMENT SPECIFICATIONS. *YC
235198
CONCERNS ABOUT LEFT FRONT LEATHER SEAT SIDE SHIELD CHAFING THE SEAT COVER. *AK
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
050598
BRAKE GRIND OR GROWL SOUND COMING FROM THE FRONT BRAKES DURING LOW SPEED BRAKING. *AK
234598
APPROVAL OF USING OF IN- TRANSIT PROTECTIVE FILM. ON ALL VEHICLES AT ALL ASSEMBLY PLANTS. *AK
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
070598
EXPERIENCING ENGINE COOLING FAN NOISES. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.