Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
2304702
INTERIOR FRONT DOOR HANDLE/BEZEL REPLACEMENT. *MJ
0900204
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN
0900503
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT
2301103
SAG OR RATTLE AT REAR OF HEADLINER. *TT
0900203
ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
2500102A
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT
1802302
CONCERNS WITH MALFUNCTION INDICATOR LAMP ILLUMINATION WITH A CATALYST EFFICIENCY FAILURE DIAGNOSTIC TROUBLE CODE (DTC P0420) RECORDED IN THE POWER TRAIN CONTROL MODULE (PCM). *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2200102
CHROME WHEEL CARE. *SLC
0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
2301901
SOME VEHICLES MAY HAVE A POWER SEAT ADJUSTER LOOSE FORE/AFT.*SLC
2400901
SUBJECT PERTAINING TO A/C HEATER PERFORMANCE.*SLC
01015
ADVANCE SERVICE INFORMATION REGARDING A NO-START CONDITION WHICH MAY EXIST FOLLOWING A HOT SOAK. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
1900101
SOME OWNERS MAY EXPERIENCE LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
0803100
A CONDITION MAY EXIST WHERE THE WINDOW STICKS IN THE UP POSITION. THIS CONDITION MAY BE INTERMITTENT. *TT
2303900
INFORMATION ON DOOR GLASS LIFT PLATE SERVICE. *TT
1802100
SOME VEHICLES MAY EXHIBIT A VEHICLE THEFT ALARM (VTA) SECURITY LIGHT INTERMITTENTLY NOT BLINKING AFTER LOCKING ALL DOORS AND / OR THE OUTSIDE TEMPERATURE DISPLAY WILL BE SLOW TO UPDATE AND / OR POOR A/C PERFORMANCE IS EXPERIENCED AFTER VEHICLE START UP. *TT
1900300B
SOME VEHICLES MAY EXPERIENCE LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
0042
ADVANCE SERVICE INFORMATION FOR LOOSE STEERING. *TT
190300A
EXPERIENCING LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT
070200
SOME VEHICLES MAY EXHIBIT ENGINE OVERHEATING AND / OR COOLANT BOTTLE FAILURES AFTER SERVICE HAS BEEN PERFORMED ON THE ENGINE COOLING SYSTEM. *TT
190300
A CONDITION MAY EXIST WHERE A LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT
070100
A CONDITION MAY EXIST WHERE A LOW TONE GROWL SOUND CAN BE HEARD COMING FROM THE ENGINE FOLLOWING A COLD START WHILE IN DRIVE OR REVERSE WITH ENGINE RPM BETWEEN 1000 AND 1300 RPM. *TT
240200
SOME VEHICLES MAY EXHIBIT ERRATIC OPERATION OF THE A/C AND HEATER SYSTEMS INCLUDING: LACK OF COLD AIR, LACK OF HOT AIR, UNREQUESTED MODE CHANGE (ATC ONLY), NO CONTROL OF MODE OR TEMPERATURE CONTROL OR DITHERING / TAPPING BLEND DOOR NOISE. *TT
080800
CONCERNS WITH AN INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
230700
EXPERIENCING WIND NOISE HEARD FROM THE SUNROOF OR B-PILLAR FORWARD IN THE VEHICLE WHILE DRIVING AT HIGHWAY SPEEDS ABOVE 55 MPH OR AT LOWER SPEEDS INTO A HEADWIND. *TT
020100
CONCERNS WITH A SQUEAKING NOISE FROM FRONT STRUT(S) DURING SUSPENSION JOUNCE. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
230200
DAIMLERCHRYSLER CORPORATION IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTION VEHICLES. *TT
230400
CONCERNS WITH THE DOOR TRIM PANEL CRACKING AT LOWER ATTACHING SCREW BOSSES. *TT
190100
SOME VEHICLES MAY EXHIBIT RATTLE SOUND COMING FROM FRONT OF VEHICLES. *TT
021699
SOME VEHICLES MAY EXHIBIT A CONSTANT LEAD OR PULL ON A FLAT NON-CROWNED ROAD. *TT
190899
INFORMATION WHEN SERVICING THE INNER TIE ROD END TO STEERING GEAR ATTACHMENTS. *TT
084099
DISCUSSION STATING THAT CURRENTLY, WINDOW MOTORS ARE BEING SERVICED SEPARATELY FROM THE WINDOW REGULATOR. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
220499
SUBJECT CONCERNING THE STEERING WHEEL VIBRATION. *MJS
083699
SUBJECT ON THE ENGINE OIL PRESSURE LIGHT FLICKER, VEHICLES EQUIPPED WITH A 2.7L ENGINE. *MJS
083599
SUBJECT ON THE MIL ILLUMINATION, LEAK DETECTION PUMP DTC AND/OR FUEL GAUGE INACCURATE. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
082999
CONCERNS WITH INADVERTENT DOOR LOCK OPERATION. *TT
232099A
DAIMLER CHRYSLER IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTED VEHICLES. *TT
211099
SUBJECT REGARDING AUXILIARY DIFFERENTIAL VENT. *TT
232099
DIAMLER CHRYSLER CORPORATION IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTED VEHICLES. *TT
9926
INFORMATION PERTAINING TO INTERNAL EMERGENCY TRUNK RELEASE DEALER REIMBURSEMENT. *TT
140299
EXPERIENCING HISS NOISE FROM ENGINE WHEN IDLING. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
081699A
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
081999
SUBJECT REGARDING POSITIVE BATTERY TERMINAL CORROSION. *TT
9925
SUBJECT REGARDING THE INTERNAL EMERGENCY TRUNK RELEASE. *TT
081699
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
081199
EXPERIENCING BUZZING OF THE FRONT DOOR TRIM PANEL INDUCED BY THE AUDIO SYSTEM. *TT
080999A
INTERIOR LIGHTS WILL NOT ILLUMINATE OR LIGHTS STAYING ON. *TT
090299
SUBJECT ON OIL FILTER ADAPTER COMING OUT OF ENGINE BLOCK DURING REMOVAL OF OIL FILTER. *TT
814
CALIFORNIA EMISSIONS RECALL ON REPROGRAMMING POWERTRAIN CONTROL MODULE. *TT
080999
INTERIOR LIGHTS WILL NOT ILLUMINATE. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
230599
SUBJECT REGARDING REAR DOOR TRIM PANEL LOOSE AT UPPER REAR CORNER. *TT
240399
A CONDITION MAY EXIST WHERE NO WARM OR HOT AIR COMES FROM THE CLIMATE CONTROL SYSTEM WHEN THE ENGINE IS WARM AND THE CLIMATE CONTROL TEMPERATURE KNOB IS SET TO WARM OR HOT. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
#9867
COMPLAINTS OF WINDOW MOTORS WIRED INCORRECTLY. *YC
236098
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNSHADE FABRIC DELAMINATES FROM THE SUBSTRATE ALONG THE EDEGES OF THE SUNSHADE. *YC
084698
CONCERNS WITH WINDOW STICKS IN THE UP POSITION. *AK
233398
EXPERIENCING A SQUEAK NOISE IN WINDOW REGULATOR. *YC
084598
LACK OF RANGE USING REMOTE KEYLESS ENTRY ( RKE ). *AK
021298
CONCERNS WITH SQUEAKING NOISE COMING FROM FRONT STRUT( S ). *YC
183398
SUBJECT REGARDING ROUGH IDLEAN DPOOR DRIVEABILITY CAUSED BY EGR VALVE BEING IN PARTIALLY OPEN POSITION. *AK
235298
EXCESSIVE ROAD NOISE HEARD INSIDE VEHICLE WHILE DRIVING ON ROUGH ROAD SURFACE; MORE PRONOUNCED IN REAR SEAT. *AK
241498
COMPLAINTS OF POOR HEATER PERFORMANCE AT IDLE OR SLOW ENGINE WARM UP. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
084198
INOPERATIVE REMOTE KEYLESS ENTRY ( RKE ) KEY FOB/ TRANSMITTER DUE TO DISCHARGED BATTERY ( LESS THAN 3.2 VOLTS ). *YC
190798
INFORMATION ON STEERING GEAR MOUNTING BUSHING SERVICE. *AK
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
081798 REV B
SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC
241398
LACK OF COLD AIR FROM THE CLIMATE CONTROL SYSTEM AND THE SCAN TOOL. *AK
083898
EXPERIENCING A BUZZ NOISE COMING FROM THE FLAG SPEAKER. *YC
241298
EXPERIENCING A HISSING SOUND FROM A/C DURING CLUTCH CYCLE. *YC
9828
LISTS CORRECT CHARGE LEVEL FOR AIR CONDITIONING SYSTEM R134A REFIGERANT. CORRECT CHARGE LEVEL IS 0.71KG (25 OZ. OR 1.56 LBS). *AK
182998
MALFUNCTION INDICATOR LAMP (MIL)ILLUMINATED WITH A CATALYST EFFICIENCY FAILURE. *YC
980612180998
SOME VEHICLES MAY EXHIBIT A HOT ENGINE NO START, HOT ENGINE RESTART WITH A ROUGH IDLE, OR HOT ENGINE RESTART / DIE-OUT. *YC
232998
WATER LEAK ON TOP AND/OR UNDER FLOOR CARPETS. *YC
08!798
DISCUSSION ON AIRBAG ON- OFF SWITCHES FOR SELECTED VEHICLES *AK
233098
WIND NOISE HEARD FROM THE B-PILLAR FORWARD IN THE VEHICLE WHILE DRIVING AT HIGHWAY SPEEDS ABOVE 55 MPH OR AT LOWER SPEEDS DRIVING INTO A HEADWIND. *YC
241098
INFORMATION ON AUTOMATIC TEMPERATURE CONTROL ( ATC ) / MANUAL SYSTEM ERRATIC OPERATION. *YC
232898
WATER AND / OR DUST COLLECTION IN THE SPARE TIRE WELL OR AT THE TRUNK FLOOR TO QUARTER PANEL SEAM. *YC
083098
SUBJECT REGARDING BATTERY POSITIVE POST / TERMINAL SERVICE. *YC
240998
CONDITION WITH A/C COMPRESSOR MOAN. *YC
190398
POWER STEERING SYSTEM NOISE FOLLOWING COLD ENGINE STARTS IN LOW AMBIENT TEMPERATURES. *YC
020398
VEHICLE LEADS OR PULLS ON FLAT NON-CROWNED ROAD. *YC
082598
LACK OF BASS OR OVERALL SOUND QUALITY. *YC
081898
INADVERTENT DOOR LOCK OPERATION. *YC
082298
INFORMATION REGARDING HORN SERVICE. *YC
082498
SUBJECT ON CUSTOMER PREFERENCE CIGAR LIGHTER / POWER OUTLET. *YC
210898
N 4 - 3 COAST DOWN SHIFT POINT WA SMOVED TO A HIGHER SPEED (30 MPH).*AK
240698
AUTOMATIC TEMPERATURE CONTROL (ATC) SYSTEM, IF LEFT IN "AUTO" MODE WHEN THE IGNITION IS TURNE DOFF, OCCASIONALLY REVERS TO "MANUAL" MODE WHEN THE IGNITION IS TURNED BACK ON. *AK
232098
CONDITION CONCERNING THE GLOVE BOX NOT CLOSING OR REQUIRES EXCESSIVE EFFORT TO LATCH. *YC
321998
CONCERNS WITH THE INSTRUMENT PANEL END COVER ATTACHING CLIPS MAY BECOME DAMAGED DURING ROUTINE FUSE OR INSTRUMENT PANEL SERVICE. *YC
321198
CONCERNS OF A WAVY ROOF SHEET METAL OR DENTS IN THE APPROXIMATE AREA OF THE STRUCTURAL HEADLINER MEMBRANE. *YC
210798
SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK
081598
EXPERIENCING A SLOW OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) SYSTEM. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
090298
SUBJECT ON ENGINE TO TRANSMISSION DOWEL SERVICE. *YC
180998
SOME VEHICLES MAY EXHIBIT A HOT ENGINE NO START, HOT ENGINE RESTART WITH A ROUGH IDLE, OR HOT ENGINE RESTART/DIE-OUT. *AK
181398
SUBJECT ON INCORRECT MISFIRE DETECTION/FLASHING MIL ILLUMINATION. *YC
181498
SOME VEHICLES MAY EXHIBIT FUEL VAPOR LOCK, PARTICULARLY WHEN USING ALCOHOL BLENDED FUELS. *YC
220198
INFORMATION ON VEHICLE ALUMINUM WHEELS HAVING A UNIQUE BALANCE WEIGHT RETENTION FLANGE. *YC
231098
CLICKING SOUND ON RIGHT SIDE TOP OF INSTRUMENT PANEL. *YC
231198
CONDITION WITH WAVY ROOF SHEET METAL OR DENTS IN THE APPROXIMATE AREA OF THE STRUCTURAL HEADLINER MEMBRANE. *YC
9812
SOME VEHICLES MAY EXHIBIT FUEL VAPOR LOCK, PARTICULARLY WHEN USING ALCOHOL BLENDED FUELS. *YC
070298
EXPERIENCING NOISE FROM THE A/C BELT. *YC
070198
EXPERIENCING POOR HEATER PERFORMANCE. *YC
210198
SUBJECT ON SHIFT SCHEDULE CHANGES/ENHANCEMENTS. *YC
210398
SUBJECT ON TRANSAXLE DESENSITIZATION TO INTERMITTENT FAULTS / DRIVEABILITY IMPROVEMENTS. *YC
180398
SUBJECT ON POWER STEERING SWITCH ELIMINATION AND/OR MIL ILLUMINATION WITH HEX CODE $73. *YC
230798
PROVIDED INFORMATION ON BOTH TRADITIONAL AND NON-TRADITIONAL BODY GAPS AND FLUSHNESS SPECIFICATIONS. *YC
110198
EXHAUST DRONE AND/OR VIBRATION FELT AT 1600-2000 RPM UNDER A LOAD. *AK
230298
SNAPPING NOISE WHEN EITHER FRONT DOOR IS OPENED.*AK
084197
INFORMATION ON ERRONEOUS DTC WIPER" ON/OFF RELAY OPEN OR SHORTED LOW"
090997
INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM
241597
SOME VEHICLES MAY EXHIBIT A SHORT CYCLICAL NOISE AS THE HVAC UNIT TEMPERATURE DOOR CYCLES AGAINST THE STOP WHEN OPERATING ONLY IN FULL COLD POSITION OR FULL HOT POSITION.
241597A
THIS BULLETIN INVOLVES HVAC UNIT TEMPERATURE DOOR CYCLICAL TAPPING NOISE. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
083797
INFORMATION ON INSTRUMENT CLUSTER SERVICE. *NLM
241497
INFORMATION ON ERRONEOUS DTC 45 "A/C CONTROL BLEND DOOR INPUT OPEN OR SHORTED TO GROUND. *NLM
020897
CONDITIONS WITH VEHICLE LEADS OR PULLS ON A FLAT NON-CROWNED ROAD. *YC
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.