Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
2304702
INTERIOR FRONT DOOR HANDLE/BEZEL REPLACEMENT. *MJ
0900204
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN
0900503
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT
0802203
HEADLAMP/INSTRUMENT PANEL ILLUMINATION. 2004 MODELS INCLUDED. *TT
0703
THE ENGINE COMPARTMENT IN THE FRAME & BUMPERS - FRAME - SPECIFICATIONS - FRAME DIMENSIONS SECTION HAS BEEN UPDATED. *TT
2301103
SAG OR RATTLE AT REAR OF HEADLINER. *TT
0900203
ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
1400103
FUEL TANK SLOW TO FILL. INCLUDING MY2004. *TT
0200103
SQUEAKING SOUND FROM REAR STRUT(S). *TT
2300203
WIND NOISE FROM SUNROOF OR B-PILLAR WHILE DRIVING. *TT
2500102A
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2302802
SUBJECT REGARDING AN INOPERATIVE OR INTERMITTENT SUN ROOF. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
2200102
CHROME WHEEL CARE. *SLC
0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
2301901
SOME VEHICLES MAY HAVE A POWER SEAT ADJUSTER LOOSE FORE/AFT.*SLC
1801801
VEHICLES MAY EXPERIENCE INFREQUENT ERRATIC IDLE . *SLC
2400901
SUBJECT PERTAINING TO A/C HEATER PERFORMANCE.*SLC
01014
INSTRUMENT PANEL END CAP INSTALLATION. ADVANCE SERVICE INFORMATION *TT
2600701
INFORMATION REGARDING SERVICE/DIAGNOSTIC MANUAL REVISIONS. *SLC
2600601
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES REQUIRING HAND WRITTEN CHANGES TO EXISTING PAGES. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
1400301
A CONDITION MAY EXIST WHERE THE FUEL TANK IS SLOW TO FILL BECAUSE OF LACK OF VENTING. THIS BULLETIN INVOLVES CORRECTING KINKED / PLUGGED FUEL TANK VENT LINES AND / OR REPLACING THE FUEL TANK CONTROL VALVE AND / OR REPLACING THE LEAK DETECTION PUMP (LDP) FILTER AND / OR UNPLUGGING OR REPLACING THE FUEL TANK FILL TUBE ASSEMGLY. *TT
0900301
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES. *TT
2600501
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES. *TT
0800701
SOME LH-VEHICLES MAY HAVE THE INSTRUMENT CLUSTER ILLUMINATION GO TO FULL BRIGHT AND / OR THE FUEL GAUGE DROP TO THE E POSITION AND LOW FUEL INDICATOR ILLUMINATE. *TT
2600401
SUBJECT REGARDING SERVICE / DIAGNOSTIC MANUAL REVISIONS. *TT
1900101
SOME OWNERS MAY EXPERIENCE LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
2300301
THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201. *TT
01001
SOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE. *JB
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0804200
SUBJECT REGARDING REMOTE KEYLESS ENTRY TRANSMITTER PROGRAMMING. *JB
0200800
THIS BULLETIN COVERS THE DIAGNOSIS AND REPAIR INFORMATION FOR VEHICLES THAT HAVE A CONSTANT PULL OR LEAD CONDITION. *TT
0803800
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
2601200
INFORMATION ON SERVICE PUBLICATION UPDATES. *JB
0803600
SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE. *TT
0803300
SOME VEHICLES MAY EXHIBIT A FAULT CODE IN THE RADIO WHEN PERFORMING DIAGNOSTIC USING THE DRB III. THE CODE READS COLD CD. THE FAULT CODE IS NOT DISPLAYED TO THE CUSTOMER AND IS ONLY DISPLAYED WHEN PERFORMING DIAGNOSTICS. *TT
0803100
A CONDITION MAY EXIST WHERE THE WINDOW STICKS IN THE UP POSITION. THIS CONDITION MAY BE INTERMITTENT. *TT
2303900
INFORMATION ON DOOR GLASS LIFT PLATE SERVICE. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
070200
SOME VEHICLES MAY EXHIBIT ENGINE OVERHEATING AND / OR COOLANT BOTTLE FAILURES AFTER SERVICE HAS BEEN PERFORMED ON THE ENGINE COOLING SYSTEM. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.