Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
68332810A
Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only.
R2118796A
Valve Body. These may cause over drive cycling.
9002688
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom and/or connector in the valve cover gasket is not the root cause to your concern. In addition, make sure that the wiring attaching nuts are torqued to their proper value.~
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
1801702
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR INJECTOR CIRCUIT FAULT. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
1800402
SUBJECT REGARDING 1999 MY ENGINE SPARK KNOCK. *TT
1800202
ONWERS OF CERTAIN VEHICLES EQUIPPED WITH 9.25 AXLE MAY COMPLAIN THAT VEHICLE SPEED IS INACCURATE. *TT
1803001
SUBJECT REGARDING 46RE SHIFT QUALITY AND DURABILITY IMPROVEMENTS. *TT
1900201A
THIS BULLETIN PROVIDES A DIAGNOSTIC PROCEDURE FOR STEERING SENSITIVITY. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
1900201
SUBJECT REGARDING STEERING WANDER DIAGNOSIS. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2500401
SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT
976
ON SOME VEHICLES THE ON-BOARD DIAGNOSTIC (OBD) SYSTEM MAY NOT DETECT A CATALYST FAILURE AS REQUIRED BY CALIFORNIA EMISSIONS REGULATION. AS A RESULT, THE OBD SYSTEM MAY NOT ILLUMINATE THE CHECK ENGINE LIGHT IF A CATALYST FAILS. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
00067
ADVANCE SERVICE INFORMATION REGARDING REVISED ALIGNMENT SPECIFICATIONS. *TT
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
180600C
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT TO MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
190700
SUBJECT REGARDING STEERING WANDER DIAGNOSIS. *TT
233400
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
030800
;SUBJECT REGARDING RTV USE ON CORPORATE AXLE. *TT
180600B
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
082400
ON SOME VEHICLES THE ENGINE CRANKS BUT DOES NOT START OR STARTS AND STALLS. *TT
180600A
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
180600
SUBJECT REGARDING 1999 MODEL YEAR ENGINE SPARK KNOCK. *TT
231500
CUSTOMER MAY COMMENT THAT THE SLIDING DOOR WILL NOT OPEN AND / OR CLOSE / LATCH. *TT
020400
SOME CUSTOMERS MAY COMMENT ON A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT
030200
SUBJECT PERTAINS TO 9.25 AXLE GEAR MARKING COMPOUND CAUSING A MILKY-LIFE APPEARANCE TO THE AXLE FLUID. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
230900
CONCERNS WITH THE SIDE / REAR CARGO DOOR(S) OPENING PAST THE NORMAL 90 DEGREE OPENING. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
182599
INFORMATION ON ERRONEOUS ENGINE MISS WHILE PERFORMING DIAGNOSTICS WITH THE DIAGNOSTIC SCAN TOOL (DRB III). *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
021399
EXPERIENCING SQUEAKING NOISE FROM REAR LEAF SPRINGS. *TT
090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
181999
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION DUE TO DIAGNOSTIC TROUBLE CODE P0740 - TORQUE CONVERTER CLUTCH, NO RPM DROP AT LOCKUP. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
180999
INFORMATION PERTAINING TO COMMON DIAGNOSTIC TROUBLE CODES CAUSED BY AN OPEN FUSE. *TT
9923
CONDITIONS MAY EXIST WHERE OIL SEEPAGE PAST THE ENGINE OIL FILTER ADAPTER PLATE GASKET. *TT
240999
INFORMATION ON THE REMOVAL OF HEATER / AIR CONDITIONER RECIRCULATION OPENING COVER DURING NEW VEHICLE PREPARATION. *TT
180799
EXHIBITING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $A8 (P1763) GOVERNOR PRESSURE SENSOR VOLTS TOO HIGH. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
070998
SUBJECT ON VISCOUS FAN DRIVE SERVICE. *YC
183598
EXHIBITING MIL ILLUMINATION WITH DTC $ 12 (P0443) - EVAPORATIVE PURGE SOLENOID CIRCUIT FAILURE, CAN BE CAUSED BY ELECTRICAL NOISE GENERATED THROUGH THE IGNITION SWITCH. *AK
183698
SOME VEHICLES MAY EXHIBIT AN IDLE UNDERSHOOT OR DIE OUT DURING ENGINE STARTING AND MAY BE CAUSED BY IAC LOST STEPS. *AK
183798
SOME CONSUMERS THAT INADVERTENTLY FLOOD THEIR ENGINES DURING STARTING MAY TRY TO PERFORM A CLEAR FLOOD PROCEDURE TO HELP START THEIR VEHICLES. *AK
030798
SOME VEHICLES MAY EXHIBIT AXLE NOISE IN THE 35 TO 55 MILE PER HOUR RANGE. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
234598
APPROVAL OF USING OF IN- TRANSIT PROTECTIVE FILM. ON ALL VEHICLES AT ALL ASSEMBLY PLANTS. *AK
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
234398
THIS BULLETIN IS INTENDED TO ASSIST IN IDENTIFYING WATER LEAK ENTRY POINTS PAST THE DUAL CARGO DOOR SEALS BY HIGHLIGHTING AREAS WHERE LEAKS ARE LIKELY TO OCCUR BASED ON THE EXPERIENCE GAINED DURING THE DEVELOPMENT OF THE VEHICLE. *YC
234298
HISS OR WHISTLE TYPE WINDNOISE CAN BE HEARD COMING FROM THE A-PILLAR AREA. *YC
070598
EXPERIENCING ENGINE COOLING FAN NOISES. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.