Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
68332810A
Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only.
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
9002688
68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom and/or connector in the valve cover gasket is not the root cause to your concern. In addition, make sure that the wiring attaching nuts are torqued to their proper value.~
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
2200102
CHROME WHEEL CARE. *SLC
1900201A
THIS BULLETIN PROVIDES A DIAGNOSTIC PROCEDURE FOR STEERING SENSITIVITY. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
1900201
SUBJECT REGARDING STEERING WANDER DIAGNOSIS. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2600501
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0804100
A CONDITION MAY EXIST WITH THE DOOR LOCKS INTERMITTENTLY LOCKING AND / OR UNLOCKING WITHOUT ANY ACTIVATION OF THE POWER DOOR LOCK SWITCH OR A CLICKING SOUND HEARD COMING FROM THE POWER DOOR LOCKS (REPEATED LOCKING OR REPEATED UNLOCKING). *TT
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
00067
ADVANCE SERVICE INFORMATION REGARDING REVISED ALIGNMENT SPECIFICATIONS. *TT
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082600
SUBJECT REGARDING CENTRAL TIMER MODULE ELECTRICALLY LOCKS-UP. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
190700
SUBJECT REGARDING STEERING WANDER DIAGNOSIS. *TT
233400
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
082400
ON SOME VEHICLES THE ENGINE CRANKS BUT DOES NOT START OR STARTS AND STALLS. *TT
080100A
CONCERNS WITH A NO START (ENGINE WILL NOT CRANK) CONDITION DUE TO A BLOWN STARTER RELAY CIRCUIT FUSE. TT
231500
CUSTOMER MAY COMMENT THAT THE SLIDING DOOR WILL NOT OPEN AND / OR CLOSE / LATCH. *TT
020400
SOME CUSTOMERS MAY COMMENT ON A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT
080800
CONCERNS WITH AN INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
8591/8592
SUBJECT REGARDING THE ON-BOARD DIAGNOSTIC (OBD) SYSTEM ON ABOUT 309,000 VEHICLES LOCATED OUT OF CALIFORNIA AND VEHICLES LOCATED IN CALIFORNIA WILL NOT DETECT A CATALYST FAILURE AS REQUIRED BY FEDERAL AND CALIFORNIA REGULATIONS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
080100
EXPERIENCING A NO START (ENGINE WILL NOT CRANK) DUE TO A BLOWN STARTER RELAY CIRCUIT FUSE. *TT
0001
SOME VEHICLES MAY FAIL TO START (ENGINE WILL NOT CRANK) DUE TO A BLOWN STARTER RELAY FUSE. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
083899
INFORMATION ON THE IGNITION OFF DRAW (IOD) FUSE LOCATION. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.