Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
2500102A
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
1802001
EXHIBITING ROUGH IDLE, HARD START AND START & STALL.*CLS
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0900800
THIS BULLETIN INVOLVES INSTALLATION OF A NEW COMPONENT TO ASSIST CAM SEAL RETENTION. *JB
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
230200
DAIMLERCHRYSLER CORPORATION IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTION VEHICLES. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
190299REVA
VEHICLES MAY EXPERIENCE CLUNKING OR RATTLE IN STEERING WHEEL/STEERING COLUMN. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090799
INFORMATION REGARDING 2.5L V-6 HEAD GASKET APPLICATION. *TT
090899
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
232099A
DAIMLER CHRYSLER IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTED VEHICLES. *TT
233099
SUBJECT PERTAINING TO A MISSING REAR CUP HOLDER SLIDE CLIP. *TT
232099
DIAMLER CHRYSLER CORPORATION IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTED VEHICLES. *TT
9926
INFORMATION PERTAINING TO INTERNAL EMERGENCY TRUNK RELEASE DEALER REIMBURSEMENT. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
9925
SUBJECT REGARDING THE INTERNAL EMERGENCY TRUNK RELEASE. *TT
210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT
210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
803
CALIFORNIA EMISSIONS RECALL ON REPROGRAMMING THE POWERTRAIN CONTROL MODULE. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
090798
SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK. *YC
7931/7932
CATALYTIC CONVERTER MAY HAVE BEEN WELDED WITH INCORRECT WELD WIRE. *AK
241598
INFORMATION ON A/C SYSTEM PERFORMANCE COMPLAINTS AND /0R A/C COMPRESSOR FAILURE IN HIGH AMBIENT TEMPERATURES (90+F). *AK
090598
A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
081798 REV B
SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC
183098
CONDITIONS WITH SAGGING/ HESITATION / AND STUMBLING AFTER A COLD START. *AK
082898
CONCERNS WITH RIGHT HEADLAMP HIGH BEAM BEING INOPERATIVE. *AK
190398
POWER STEERING SYSTEM NOISE FOLLOWING COLD ENGINE STARTS IN LOW AMBIENT TEMPERATURES. *YC
9830
SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT. *YC
020598
INTERMITTENT POPPING SOUND COMING FROM THE FRONT OF THE VEHICLE MAY BE HEARD FROM EITHER SIDE. *YC
210798
SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
240898
CONDITION WITH THE A/C SYSTEM PERFORMANCE. *YC
181898
EXCESSIVE COLD CRANK TIME, START DIE OUT OR WEAK RUN-UP, SAGS/STUMBLE/HESITATION AFTER A COLD START, IDLE RPM CYCLING. *YC
980331
IMPROPERLY WELDED CATALYTIC CONVERTER ASSEMBLIES. *AK
9816
RECALL INFORMATION REGARDING CIRRUS/STRATUS SEAT BELT ANCHOR. *AK
080698
CONDITION WITH INDICATOR BULB DOES NOT LIGHT. *YC
210198
SUBJECT ON SHIFT SCHEDULE CHANGES/ENHANCEMENTS. *YC
210398
SUBJECT ON TRANSAXLE DESENSITIZATION TO INTERMITTENT FAULTS / DRIVEABILITY IMPROVEMENTS. *YC
190198
CONDITION WITH CLUNKING OR RATTLING IN STEERING/WHEEL COLUMN. *YC
320198
SYMPTOM WITH SEAT ADJUSTER RISES WHEN THE SEAT IS UNOCCUPIED. *YC
080298
PREVENTING ANTENNA MASTS FROM BECOMING LOOSE, A CHANGE WAS IMPLEMENTED TO INCORPORATE A TORQUE PREVAILING FEATURE ON THE ANTENNA MAST. *YC
090997
INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
020797
CONCERNS WITH LOW FREQUENCY RUMBLE/ GEAR TYPE NOISE FROM FRONT OF VEHICEL. *NLM
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
083197
CONCERNS WITH NO BUS MESSAGE IN INSTRUMENT CLUSTER V.F. DISPLAY *NLM
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.