Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
1801405
FLASH: MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC/DIAGNOSTIC TROUBLE CODE) P0300, P0301, P0302, P0302, P0303, P0304, P0305, P0306-COLD START MISFIRE. *SC
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
2400105
BLOWER MOTOR DOES NOT RUN ON EVERY SPEED. *TT
0800303A
SENTRY KEY - KEY IMMOBILIZER SECURITY SYSTEM. *TT THIS BULLETIN REPLACES 08-003-03 REV A. *TT
2301203
POP/CLUNK SOUND FROM FRONT OF VEHICLE. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-012-03 DATED 05/23/2004. *TT
2303204
POWER SEAT WILL NOT ADJUST. *TT
1900304
STEERING COLUMN CLICK SOUND. *TT
0802804
INTERMITTENT LOSS OF ACCESSORIES (IG1 CIRCUIT) ON INITIAL VEHICLE START. *TT
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
0901104
INCORRECT OIL FILTER USAGE. ALSO INCLUDES 2005 SEBRING AND STRATUS. *TT
0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
080403
CONTROL SOLENOIDS FAILURE IN VACUUM HARNESS TURBOCHARGED ENGINES DUE TO OPEN CIRCUIT. 2001 - 2003 CIRRUS ALSO INCLUDED. *TT
2301403
WHEN CYCLING DOOR GLASS UP AND DOWN, A CLICKING NOISE CAN BE HEARD WHEN THE WINDOW TRAVEL CHANGES DIRECTION ON VARIOUS MODELS INCLUDING THE 2004 SEBRING SEDAN AND SEBRING CONVERTIBLE. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
2400103
WINDOWS MAY BEGIN TO FOG WHEN THE HVAC IS IN FLOOR MODE. *TT
06
ENGINE VACUUM HOSE ROUTING LABEL REPLACEMENT. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
0700402
VEHICLES MAY EXPERIENCE AN INTERIOR GURGLING SOUND, OVERHEATING AND/OR POOR INTERIOR HEATING AT IDLE. *SLC
2302302
SOME VEHICLES MAY EXPERIENCE THE VINYL SURFACE OF THE INSTRUMENT PANEL BEING DAMAGED OR BLEMISHED. *SLC
1900402
SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
2200102
CHROME WHEEL CARE. *SLC
0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
2300102
SUBJECT REGARDING FRONT DOOR TRIM PANEL RETENTION/WARPED ALONG BELT LINE CONDITION. *TT
0802601
SOME VEHICLES MAY EXHIBIT A FLICKERING TRIP COMPUTER AND/OR RADIO DISPLAY, INSTRUMENT PANEL ILLUMINATION, AND/OR OVERHEAD/DOME LIGHTS. *TT
1802701
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT
1802801
SOME VEHICLES MAY EXHIBIT ENGINE IDLE ROUGHNESS FOLLOWING A COLD START, ENGINE SPEED FLARE OR ROUGH IDLE WHILE SLOWING TO A STOP. *TT
1900601A
EXPERIENCING STEERING COLUMN CLICK SOUND WHEN THE STEERING WHEEL IS TURNED. *TT
2302801A
ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING. *TT
899
ON SOME VEHICLES THE TRAVELER MODULE MAY TRANSMIT AN ERRONEOUS SECURITY SYSTEM SIGNAL IF THE VEHICLE IS FACING WEST WHEN STARTED, PREVENTING THE ENGINE FROM STARTING. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
1900601
SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *TT
2401001
EXPERIENCING HONK OR FOG HORN SOUND COMING FROM THE A/C EXPANSION VALVE. *TT
01017
ADVANCE SERVICE INFORMATION REGARDING STEERING COLUMN CLICK SOUND. *TT
2301701
SUBJECT REGARDING WATER LEAK INFORMATION. *TT
01008
WHEEL ALIGNMENT OUT OF SPECIFICATION. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
0900301
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
974
ON CERTAIN VEHICLES, THE TRANSMISSION CONTROL (EATX) RELAY MAY NOT OPERATE PROPERLY IN COLD TEMPERATURES. *TT
2300301
THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201. *TT
01001
SOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE. *JB
0700400
INFORMATION REGARDING TRANSAXLE COOLER LINE SPLICE KIT. *JB
0200900
CONCERNS WITH POPPING OR SQUAWKING NOISE FROM REAR SUSPENSION WHILE DRIVING VEHICLE. *JB
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0804200
SUBJECT REGARDING REMOTE KEYLESS ENTRY TRANSMITTER PROGRAMMING. *JB
0803800
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
0803600
SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE. *TT
2400800
SOME VEHICLES MAY EXHIBIT FOG HORN SOUND COMING FROM THE A/C. *TT
0803300
SOME VEHICLES MAY EXHIBIT A FAULT CODE IN THE RADIO WHEN PERFORMING DIAGNOSTIC USING THE DRB III. THE CODE READS COLD CD. THE FAULT CODE IS NOT DISPLAYED TO THE CUSTOMER AND IS ONLY DISPLAYED WHEN PERFORMING DIAGNOSTICS. *TT
00061
ADVANCE SERVICE INFORMATION REGRADING SHOCK TOWER WELD ISSUES. *TT
00060
ADVANCE SERVICE INFORMATION REGARDING AUTOMATIC TRANSAXLE MISS MACHINED CASE. *TT
0052
THIS ADVANCE SERVICE BULLETIN STATES THAT SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT REDUCTION OF POWER STEERING ASSIST DUE TO A STICKING FLOW CONTROL VALVE IN THE POWER STEERING PUMP. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.