Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
1802802
MIL ILLUMINATION - MISFIRE DIAGNOSTIC TROUBLE CODE (DTCS) P0300, P0301, P0302, P0303, P0304. *TT
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
1801405
FLASH: MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC/DIAGNOSTIC TROUBLE CODE) P0300, P0301, P0302, P0302, P0303, P0304, P0305, P0306-COLD START MISFIRE. *SC
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
2400105
BLOWER MOTOR DOES NOT RUN ON EVERY SPEED. *TT
0800303A
SENTRY KEY - KEY IMMOBILIZER SECURITY SYSTEM. *TT THIS BULLETIN REPLACES 08-003-03 REV A. *TT
2301203
POP/CLUNK SOUND FROM FRONT OF VEHICLE. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-012-03 DATED 05/23/2004. *TT
2303204
POWER SEAT WILL NOT ADJUST. *TT
1900304
STEERING COLUMN CLICK SOUND. *TT
0802804
INTERMITTENT LOSS OF ACCESSORIES (IG1 CIRCUIT) ON INITIAL VEHICLE START. *TT
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
0901104
INCORRECT OIL FILTER USAGE. ALSO INCLUDES 2005 SEBRING AND STRATUS. *TT
1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
080403
CONTROL SOLENOIDS FAILURE IN VACUUM HARNESS TURBOCHARGED ENGINES DUE TO OPEN CIRCUIT. 2001 - 2003 CIRRUS ALSO INCLUDED. *TT
2301403
WHEN CYCLING DOOR GLASS UP AND DOWN, A CLICKING NOISE CAN BE HEARD WHEN THE WINDOW TRAVEL CHANGES DIRECTION ON VARIOUS MODELS INCLUDING THE 2004 SEBRING SEDAN AND SEBRING CONVERTIBLE. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
2400103
WINDOWS MAY BEGIN TO FOG WHEN THE HVAC IS IN FLOOR MODE. *TT
06
ENGINE VACUUM HOSE ROUTING LABEL REPLACEMENT. *TT
02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
27
THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT
02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
2100102
SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2302302
SOME VEHICLES MAY EXPERIENCE THE VINYL SURFACE OF THE INSTRUMENT PANEL BEING DAMAGED OR BLEMISHED. *SLC
1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
1900402
SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
2200102
CHROME WHEEL CARE. *SLC
0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
2300102
SUBJECT REGARDING FRONT DOOR TRIM PANEL RETENTION/WARPED ALONG BELT LINE CONDITION. *TT
02001
RAPID RESPONSE TRANSMITAL REGARDING CONSOLE 12V POWER OUTLET INOPERATIVE. *TT
0802601
SOME VEHICLES MAY EXHIBIT A FLICKERING TRIP COMPUTER AND/OR RADIO DISPLAY, INSTRUMENT PANEL ILLUMINATION, AND/OR OVERHEAD/DOME LIGHTS. *TT
1802701
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT
2302801A
ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING. *TT
0802001
SUBJECT REGARDING REMOTE KEYLESS ENTRY AND IMMOBILIZER SYSTEM CHANGES. *SLC
0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
2401001
EXPERIENCING HONK OR FOG HORN SOUND COMING FROM THE A/C EXPANSION VALVE. *TT
0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
2301701
SUBJECT REGARDING WATER LEAK INFORMATION. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.