Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9003215
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
18-042-14
Generic Powertrain Control Module (PCM) Procedure This bulletin involves programming a generic PCM with software.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
1802907
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *KB
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
12
THE FRONT HEATED SEAT CONTROL MODULES MAY CAUSE THE SEAT ELEMENTS TO OVERHEAT UNDER CERTAIN OPERATING CONDITIONS. CUSTOMER SATISFACTION NOTIFICATION E12 - HEATED SEAT CONTROL MODULES. *TT
0900105
CYLINDER HEAD BOLT RE-TORQUE PROCEDURE. GPOP - ISSUE REVIEW SYSTEM. *TT
2100305
TRANSFER GEAR WHINE SOUND BETWEEN 68 MPH AND 84 MPH EITHER ACCELERATING OR DECELERATING. *EH
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
1801405
FLASH: MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC/DIAGNOSTIC TROUBLE CODE) P0300, P0301, P0302, P0302, P0303, P0304, P0305, P0306-COLD START MISFIRE. *SC
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
0801405
MOPAR ACCESSORY REMOTE STARTER INOPERATIVE DUE TO HOOD SWITCH. *TT
2400105
BLOWER MOTOR DOES NOT RUN ON EVERY SPEED. *TT
1901004
POWER STEERING FLUID CONTAMINATION. *TT
0800303A
SENTRY KEY - KEY IMMOBILIZER SECURITY SYSTEM. *TT THIS BULLETIN REPLACES 08-003-03 REV A. *TT
1804004
DRIVEABILITY IMPROVEMENTS. ENGINE STUMBLES, RUNS ROUGH, IDLE FLUCTIONATION, OR SURGE WHEN AT IDLE OR COMING TO A STOP. *EH
10182004
DOWN STREAM FUEL SYSTEM. *EH
2301203
POP/CLUNK SOUND FROM FRONT OF VEHICLE. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-012-03 DATED 05/23/2004. *TT
2303204
POWER SEAT WILL NOT ADJUST. *TT
1900304
STEERING COLUMN CLICK SOUND. *TT
0802804
INTERMITTENT LOSS OF ACCESSORIES (IG1 CIRCUIT) ON INITIAL VEHICLE START. *TT
2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
1802404
IDLE FLUCTUATION AND OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION DIAGNOSTIC TROUBLE CODES P0300, P0301, P0302, P0303 OR P0304. *TT
2100503
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT *MJ
0901104
INCORRECT OIL FILTER USAGE. ALSO INCLUDES 2005 SEBRING AND STRATUS. *TT
1800604A
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT *MJ THIS BULLETIN SUPERSEDES BULLETIN 18-006-04A DATED 04/06/2004. *TT
0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
2100104
TRANSMISSION SOLENOID REPLACEMENT. *TT
30
POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTOR SEAL CUSTOMER SATISFACTION NOTIFICATION NO. C30. *TT
C37
EMISSION RECALL NO. C37 - VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *TT
03014
SERVICE ACTION 03014 - POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTOR SEAL INSPECTION/REPAIR PROCEDURE. *TT
1800703C
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
0200203
REVISED REAR SUSPENSION LATERAL CONTROL LINKS. *TT
2100503A
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT
2100603A
TRANSMISSION HARSH 4-3 DOWNSHIFT. *TT
1800703B
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
2100603
TRANSMISSION HARSH 4-3 DOWNSHIFT ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING, INTREPID AND 2003 SX2.0. *TT
2301403
WHEN CYCLING DOOR GLASS UP AND DOWN, A CLICKING NOISE CAN BE HEARD WHEN THE WINDOW TRAVEL CHANGES DIRECTION ON VARIOUS MODELS INCLUDING THE 2004 SEBRING SEDAN AND SEBRING CONVERTIBLE. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
0800603
TRIP COMPUTER INDICATES LOWER FUEL MILEAGE THAN ACTUAL. *TT
2400103
WINDOWS MAY BEGIN TO FOG WHEN THE HVAC IS IN FLOOR MODE. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.