Vehicle report
24V760000
E-One Incorporated (E-One) is recalling certain 2020-2024 Cyclone 2, Typhoon N, 2021- 2024 Cyclone N, and 2021 Quest 2 vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.
Remedy: Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact E-One Customer Service at 1-352-237-1122.
24V646000
E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, 2022-2024 Cyclone N, and Typhoon N vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.
Remedy: Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.
24V016000
E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, Cyclone N, Typhoon N, and 2023 Cyclone E vehicles. The steering assist bracket may have been machined incorrectly.
Remedy: Dealers will inspect and replace the steering assist bracket, free of charge. Owner notification letters were mailed February 7, 2024. Owners may contact E-One customer service at 1-352-237-1122.
24V006000
E-One Incorporated (E-One) is recalling certain 2021-2023 ARFF, Cyclone N, 2020-2024 Commercial, 2020, 2022-2023 Cyclone 2, 2023 Cyclone E, 2022 Typhoon, and 2020-2023 Typhoon N vehicles. In the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits.
Remedy: The equipment manufacturer, Weldon, will update the firmware, free of charge. Owner notification letters were mailed January 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.
23V459000
E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, Cyclone N, and Typhoon N vehicles. The transmission cooler may be insufficiently welded, which can result in engine coolant contaminating the transmission fluid.
Remedy: Dealers will replace the transmission cooler and fluids, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact E-ONE customer service at 1-352-237-1122.
23V332000
E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone N and Typhoon N vehicles. The electronic sensor for the aerial device may fail and not display accurate data on the angle of inclination.
Remedy: Dealers will update the electronic sensor software, or install a new electronic sensor, as necessary, free of charge. Owner notification letters were mailed July 11, 2023. Owners may contact E-One customer service at 1-352-237-1122.
22V788000
E-One Incorporated (E-One) is recalling certain 2022 Cyclone 2, Cyclone N, and Typhoon N vehicles. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.
Remedy: Dealers will replace the tie rod clamps, free of charge. Owner notification letters are expected to be mailed November 30, 2022. Owners may contact E-One customer service at 1-352-237-1122.
22V561000
E-One Incorporated (E-One) is recalling certain 2021-2022 Cyclone N and Typhoon N vehicles. The steering gears may have been assembled incorrectly, which can cause the gears to fracture.
Remedy: Dealers will inspect and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One customer service at 1-352-237-1122.
22V538000
E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, 2020 Commercial, Quest 2, 2020-2021 Typhoon, 2021 Cyclone N, and 2020-2022 Typhoon N fire trucks. The neutral screw connection within the QO Plug-On Neutral Load Center may be loose. If that connection is loose, the affected load center can overheat.
Remedy: Dealers will inspect and repair, or replace the load center, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One's customer service at 1-352-237-1122.
22V372000
E-One Incorporated is recalling certain 2022 Commercial, Cyclone 2, Cyclone N, and Typhoon N fire trucks. An additional resistor was incorrectly installed on the printed circuit board, which can disrupt CAN network communication and cause vehicle lighting to fail.
Remedy: E-One Incorporated will replace the modules, free of charge. Owner notification letters were mailed on July 22, 2022. Owners may contact E-One Incorporated's customer service at 1-352-237-1122.
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.