Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SBU35-012
FCCC Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SBU54-056
Freightliner Custom Chassis Service Bulletin for When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeterÃÂî is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
19TL-15
Tool Letter for ICC5 Programming Cable
17TL26
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
17TL27 Injector Cup Tool DSN930E17001
17TL28
17TL28 Fuel Injector Removal Tool DSN930E17004
14CSA23
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Instructions for CSC Diagnostic Support
0903-17
Engine Manufacturer Diagnostics
0409-17
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0202-17
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
0120-17
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0114-17
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
1213-16
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
18SP718
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
FL702
FCCC XCP Chassis Power Steering Hoses.
15TS3
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
16TS9 DD Platform High Pressure Fuel Lines
16TS8
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-011
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
16-009R_OWL Enhancements
16_TL-2
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
0307-16 SPN 723 (MCM) March
16-007
Canadian Warranty Parts Return Address Change
16TS5
16TS5 Release of the DD Platform Bearing Failure Guide
0302-16
Contaminated Fluids
0301-16 SPN 625
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Hydrocarbon Doser Coolant Lines
1210-14
1210-14 Cylinder Head
1207-15
1207-15 Updated procedures with adding EPA10 to the GHG14 title
15TL24
15TL24 OTC 1750 Revolver Engine Stand
15TS4
15TS4_Rev2_ EPA07 DD15 Piston Kits
15TS16
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
1201-15 Crankshaft and Bearings
18SP729
18SP729 ? EPA07 10 Three-Filter Fuel
18SP730
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service Kit
15-028A
15-028 New Detroit Coolant Line SRTs
15-029
_Warranty Recognition Program - Coming Soon
15TS17
GHG14 DD Platform Engines With Code SPN: 3216 FMI: 18, SCR Inlet NOx Sensor Drift Low
711-15
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
708-15
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
15-017
15-017 Detroit: Updated Fuel Injector SDTs
15-015
15-015 Warranty Exclusions Reminder
15-016
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15CSA10
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
15-009 - Detroit
15-009_Detroit_New_SDTs
15TL5
15TL5 DAVCO Shop Pro® FXP 95
15TL4
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
14TL8
14TL8 TorcUP? Non-Impacting Torque Tool.
14-036
14-036-DLR DTNA & JAD Highlights - Q3
14-038
14-038 Additional Detroit Standard Repair Times
14-038A
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
14-039 New Detroit Standard Diagnostic Times
14-039A
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
14TL9 Special Tool Warranty Program.
14TS30
14TS30 Aftertreatment Harness Diagnostics
14TL7
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
14TS28
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1007-14
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
1005-14 Oil Coolant Module
1003-14
1003-14 Rough Running or Stalling.
18SP684REV4
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
sb2080 Australian CST M1400 Isolated Radiator Retrofit
920-14
920-14 Additional Cleaning and Preparing
14TS26
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
917-14
917-14 Installation and Removal of the Oil Filter Stand Pipe
916-14
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
915-14
915-14 Backwards Running Engine Detecte
913-14
913-14 Checking for Poor Engine Brake Performance
912-14
912-14 Coolant in Oil
910-14
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
909-14
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
905-14
905-14 Coolant Level Circuit Failed
18SP687
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP706
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
813-14
813-14 Installation of the One & Two-Piece Fuel Injector Wiring Harness - Two & Three-Filter System
14TS21
14TS21 HDEP Camshaft Position Sensor Change
812-14
812-14 FMI 3, 4: Engine Aux. Shutdown Input Failed High and Low
14-017R
14-017R Revised: Detroit Addition of Admin Time
811-14
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
810-14
810-14 Clutch Position Sensor
809-14
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
808-14
808-14 FMI 1, 18: Selective Catalyst Reduction NOx Conversion Very Low
14TS20
14TS20 GHG14 Auto-Elevate Feature
807-14
807-14 FMI 8 SCR Inlet Temperature Signal Spike
14-029
14-029 New Detroit Standard Diagnostic Times
804-14
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
802-14
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
18SP703
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TL2
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
14-028 Remy Extended Coverage Direct File
14TS18
14TS18 GHG14 DD Engine EGR System Fault Code
14TS19
14TS19 DD Platform High Pressure Fuel Lines
14-027
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
14-026-DLR SelecTruck Warranty Enhancements
719-14
719-14 SPN 84 (CPC) (GHG14)
716-14
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
715-14
715-14 Symptom Diagnostics - Coolant Los
14-022
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
14-023 Detroit Axles Pre-Approval Changes
14-024
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
714-14 Symptom Diagnostics - Low Engine Compression
713-14
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
712-14 Engine Coolant Temperature
711-14
711-14 SPN 107 (CPC) (GHG14
710-14
710-14 SPN 96 (CPC) (GHG14)
709-14
709-14 SPN 3216 (MCM) (GHG14)
707-14
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
706-14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
705-14
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
704-14
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
703-14
703-14 SPN 3556 (ACM) (EPA10)
702-14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
18SP701
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
701-14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
512-14
512-14 FMI 0: DPF Outlet Temperature Very High
18SP684
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
0228-14
0228-14 Engine Oil Leaks - Oil Dye Method
0224-14
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
0219-14 Metal in Fuel
0215-14
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0202-14
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
0233-14 SPN 51 FMI 2 - All Years
0237-14
0237-14 Engine Brake Solenoid
13TS22
Rev DD Platform Fuel Injector Cup Seal
13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
13M2-02
13m2- Equipment Owner Field Service Campaign - 13M2
13-TL-13
13-TL-13 W470589013300 - DD Platform Fuel Injector Remover
13TS-24
13TS-24 DD Platform High Pressure Fuel Lines
18SP697
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
18SP698
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
712-13
712-13 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
711-13
711-13 SPN 100-FMI 4 - ALL YEARS
710-13
710-13 Metal in the Fuel System - Three-Filter Fuel System
707-13
707-13 Description and Operation of the HC Doser Fuel Supply Pressure Control Valve - Two Filter System
705-13
705-13 Test-E Three-Filter Fuel System
702-13
702-13 Test E Two-Filter Fuel System
608-13
608-13 High Pressure Fuel Flange-Two-Filter System
603-13
603-13 SPN 84 -FMI 6 - EPA07-GHG14
525-13
525-13 SPN 2791-FMI 7 ? ALL YEARS
18SP694
18SP694 EPA07 DD Platform High Pressure Fuel Flange Service Kit (P-N- A4720785844)
307-13
307-13 SPN 652-FMI 14 - EPA07
13TS6
13TS6 DD Platform Engine Oil Filter.pdf
13TS5
13TS5 DD Platform Fuel Filter Module
207-13
207-13 Removal and Installation of the Camshaft Housing
13WO-2
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
18SP693
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
12-039
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
12-040-DLR Roof Fairing Removal Program
12-038
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
12TL8
12TL8 W470589149100 - Filter Cap with Test Port
12TL9
12TL9 W470589169100 - DD Platform APT gearbox pressure test tool
954-12
954-12 Installation of the Fuel Injector.pdf
12-022
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.