17467
Service Bulletin/Repair Instructions
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Vehicle report
1995 FORD B SERIES
Service bulletins
53 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
02169
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99205
Service Bulletin/Repair Instructions
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
991413
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
99133
Service Bulletin/Repair Instructions
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
6473
Service Bulletin/Repair Instructions
SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT
9983
Service Bulletin/Repair Instructions
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
12564
Service Bulletin/Repair Instructions
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
5899
Service Bulletin/Repair Instructions
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
981511
Service Bulletin/Repair Instructions
HARD TO START VEHICLE AT COLD TEMPERATURE.*AK
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
98711
Service Bulletin/Repair Instructions
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
98614
Service Bulletin/Repair Instructions
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
985A13
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
BC2312970501
Service Bulletin/Repair Instructions
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
97716
Service Bulletin/Repair Instructions
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
97630
Service Bulletin/Repair Instructions
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
97517
Service Bulletin/Repair Instructions
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
97411
Service Bulletin/Repair Instructions
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
BC3236970211
Service Bulletin/Repair Instructions
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
97315
Service Bulletin/Repair Instructions
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
BC1018797230
Service Bulletin/Repair Instructions
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
BC3505972301
Service Bulletin/Repair Instructions
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
97218
Service Bulletin/Repair Instructions
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW
97117
Service Bulletin/Repair Instructions
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
97118
Service Bulletin/Repair Instructions
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
962529
Service Bulletin/Repair Instructions
FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC0601961101
Service Bulletin/Repair Instructions
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
BC0604961101
Service Bulletin/Repair Instructions
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
962218
Service Bulletin/Repair Instructions
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
96731
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE STOPLAMP DIODE LOCATION AND REPLACEMENT PROCEDURE ON VEHICLES BUILT SINCE 12/90 WITH HYDRAULIC BRAKES. *TT
BC0187960102
Service Bulletin/Repair Instructions
ON F/B SERIES W/ FD 1060 ENGINE THERE MAY BE A CONCERN REGARDING INSUFFI- CIENT IN-CAB HEAT. TO RESOLVE THIS, THE CURRENT THERMOSTAT CAN BE REPLACED WITH A NEW LOW LEAK THERMOSTAT. THE NEEDED PARTS ARE AVAILABLE FROM CUMMIS ENGINE. REFER TO TSB 95-20-12.
BC0203960102
Service Bulletin/Repair Instructions
W/ HYDRAULIC BRAKES & TILT HOOD, HYDRAULIC FLUID MAY LEAK FROM THE BRAKE PUMP RESERVOIR. TSB 95-10-13 PROVIDED A RESERVOIR SUPPORT BRACKET TO MINIMIZE LEAKAGE. IT WAS DETERMINED THAT THIS REPAIR WAS NOT ENTIRELY EFFECTIVE. ENGINEERING IS WORKING ON A PROCESS TO REMOTE MOUNT THE RESERVOIR FROM THE ENGINE ONTO THE RADIATOR SUPPORT BAR.
952010
Service Bulletin/Repair Instructions
HARD STARTING OR A NO START CONCERN MAY OCCUR ON SOME VEHICLES. THIS MAY BE DUE TO DIESEL FUEL DRAINING OUT OF THE FUEL INJECTION SYSTEM BACK INTO THE FUEL TANK. THIS CONDITION CAUSES THE INJECTION SYSTEM TO LOSE ITS PRIME WHICH LEADS TO LONGER STARTER ENGAGEMENT TIMES FOR ENGINE SHUTDOWN PERIOD. INSTALL A DIESEL FUEL CHECK VALVE (F5HZ-9285-AA) ON THE FUEL RETURN LINE AT THE REAR OF THE ENGINE.
952012
Service Bulletin/Repair Instructions
THE ENGINE COOLANT TEMP GAUGE MAY READ ON THE COLD SIDE OF THE NORMAL RANGE, OR MAY STAY BELOW NORMAL EVEN THOUGH THE ENGINE IS AT ITS PROPER OPERATING TEMP ON SOME VEHICLES. THIS IS CAUSED BY THE COOLANT TEMP SENDING UNIT NOT BEING POSITIONED IN THE MAIN STREAM OF COOLANT FLOW. INSTALL A NEW TEMP SENDER FITTING.
95212
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
951115
Service Bulletin/Repair Instructions
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW
951013
Service Bulletin/Repair Instructions
BRAKES - HYDRAULIC - HYDROMAX BRAKE RESEREVOIR MOUNTING BRACKET SEPARATION. *TW
95912
Service Bulletin/Repair Instructions
UNKNOWN
95724
Service Bulletin/Repair Instructions
NEW SERVICE KIT FOR RETAINING THE DIESEL ENGINE PLASTIC AIR CLEANER. *TW
95528
Service Bulletin/Repair Instructions
NEW CATALYTIC CONVERTERS FOR DIESEL ENGINES FD1060 AND FD1460. *TW
95620
Service Bulletin/Repair Instructions
BATTERY COVERS FOR OUTBOARD FRAME-MOUNTED BATTERIES RATTLE OR CRACK. *TW
95621
Service Bulletin/Repair Instructions
UNKNOWN
95325
Service Bulletin/Repair Instructions
STATIONARY ENGINE COVER CRACKS. *TW
95327
Service Bulletin/Repair Instructions
STEERING - REVISED CAMBER SPECIFICATION. *TW
BC3461950201
Service Bulletin/Repair Instructions
THE HYDROMAX BRAKE RESERVOIR MOUNTING BRACKET MAY SEPERATE OR FLUID MAY SLOSH FROM THE RESERVOIR. *TW
942613
Service Bulletin/Repair Instructions
STARTER STAYS ENGAGED AFTER KEY IS RELEASED. *TW
942321
Service Bulletin/Repair Instructions
MULTI-PIECE DRIVESHAFT MISALIGNMENT WITH CENTER BEARING. *TW
942213
Service Bulletin/Repair Instructions
MOUNTING LOCATION OF THE AIR COMPRESSOR GOVERNOR INTERFERING WITH POWER STEERING HOSE. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.