Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB 20-2233
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
06216
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
042421
SAFETY BELT RETRACTION SPEED. *TT
020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
05310
SAFETY BELT WEB STOP BUTTON SERVICE. *EH
0522
MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0420 AND OR P0430. *EH
18426
AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE . *EH
042407
NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222. *TT
18383
AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP. *TT
04136
DIAGNOSTIC TROUBLE CODE B1342 (RESTRAINTS CONTROL MODULE (RCM) FAULT. *TT UPDATE. *TT
04251
ALUMINUM CORROSION - SERVICE TIP. *TT
04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT
042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04247
NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS). *TT
18351
CHARGING SYSTEM LIMITATIONS. *EH
04174
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
041514
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT
031501
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT
04111
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT
02M01
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6. *TT
17871
MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL. *TT
17810
TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT
17757
INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
0441
CRACKS IN THE REAR OF THE FRAME SIDE MEMBER BETWEEN THE UPPER AND LOWER TRAILING ARM BRACKETS. *TT
03223
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT
17468
COSMETIC CRACKING OF THE CENTER FLOOR PAN. *TT
17502
SLOW OR BINDING SIDE DOOR GLASS OPERATION. *TT
03256
ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ
03228
LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT
02B02
INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT. *TT UPDATE PART 2. EXPIRATION DATE REMOVED. *TT
03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, PLUGGED CATALYTIC CONVERTER AND NO START CONDITION. *TT
03193
EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT
03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
03164
SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT
03157
GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA. *TT
03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
16996
POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE. *TT
0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
16770
SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE. *TT
0361
MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB
0349
A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES. *TT *JB
0322
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT MIL. *TT
030409
POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY. *TT
03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
16378
IDLE MISS OR SURGE AT HIGHWAY SPEEDS. PREMATURE IGNITION COIL-ON-PLUG (COP) REPLACEMENT / UNDER INVESTIGATION (QSF). *TT
16380
SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS. *TT
16401
BRAKE BOOSTER PUSH ROD ADJUSTMENT. BRAKE PEDAL FEEL CONDITION. *MJ
16412
SULPHUR SMELL FROM EXHAUST UNDER INVESTIGATION (QSF). *MJ
02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
02175
RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ
02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02155
SOME POLICE PACKAGE EQUIPPED VEHICLES MAY EXHIBIT A LOSS OF 4TH GEAR (OVERDRIVE). *TT
16102
SOME CNG VEHICLES, EQUIPPED WITH AN EXTENDED RANGE REAR TANK, MAY EXHIBIT A REAR RIDE HEIGHT THAT IS BELOW SPECIFICATION. *TT
02136
ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT
16068
SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT 1100-1500 RPM. *TT
0297
SOME VEHICLES PRODUCED BEFORE 3/5/2002 MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
15875
SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY. *TT
15881
SUBJECT REGARDING ENGINE STUMBLE / HESITATION COLD ONLY CONDITION. *TT
15893
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ENGINE COOLING FAN. *TT
0274
SOME VEHICLES MAY EXHBIT A SQUEAK / CREAK NOISE COMING FROM THE LEFT FRONT OR RIGHT FRONT DOOR HINGE AREA. *TT
15802
ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED. *TT
15808
SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT
15812
OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH. *TT
0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
0254
ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT
0256
THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT
0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
15761
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
15668
CONCERNS WITH HESITATION/STUMBLE , COLD ONLY , WHEN SHIFTING FROM PARK TO DRIVE OR PARK TO REVERSE. *TT
0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
15415
SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION BETWEEN 1100-1300 RPM WHEN THE TRANSMISSION IS PLACED IN EITHER PARK OR NEUTRAL. *TT
15444
INFORMATION ON CLOCK FUNCTION IN RADIO. *TT
012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT
01213
VEHICLES MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01181
BRAKE SHIFT INTERLOCK.*JB
15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15158
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH
15171
INFORMATION REGARDING POLICE OPTION-REAR WINDOW DISABLE-TAMPER RESISTANCE. *YD
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.