Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB 20-2233
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
DOR-L2Q6V-10
This SKU is a Radiator Fan. The customer communication requested return of unsold inventory to inspect the electrical connections. An electrical connection issue may lead to the fan not working potentially throwing a check engine light for overheating.
TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
16-0072
For 2005-2012 Crown Victoria, 2005-2011 Grand Marquis and Town Car vehicles, Regional Program 13R01 applies to vehicles not registered in corrosion states and not included in Safety Recall 13S08, where operation in high corrosion areas for an extended period may lead to corrosion in the lower intermediate steering shaft swing link. This may result in a compressed upper intermediate steering shaft and separation from the steering column, which can result in a loss of steering control. Vehicles covered under 13R01 that were inspected or repaired without replacement of the lower intermediate shaft, and have relocated to high corrosion areas, may experience subsequent corrosion of the lower intermediate steering shaft swing link.
TSB160072
Inpected or repaired under 13R01 - Requests for recall service action under 13S08
RP-13R01
FORD: THE LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION OF SWING LINK JOINTS, COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, RESULTING IN STEERING COLUMN SEPARATION AND LOSS OF STEERING CONTROL. MODEL 2005-2011 CROWN VICTORIA, GRAND MARQUIS, TOWN CAR. *PE UPDATED 04/23/14 *LJ UPDATED 07/10/15 *TA UPDATED 7/15/15 *TA
RP-13-R-01
FORD: SWING LINK JOINTS ON LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION, AND COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, ON SOME VEHICLES, CAUSES STEERING COLUMN TO SEPARATE, LEADING TO STEERING CONTROL LOSS. MODEL 2005-2011 CROWN VICTORIA, GRAND MARQUIS, TOWN CAR. *PE
TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
CSP-09N02
FORD: PERFORMANCE WHITE OR VIBRANT WHITE PAINT PEELING. IN SOME AFFECTED VEHICLES, THE PERFORMANCE WHITE OR VIBRANT WHITE PAINT MAY NOT HAVE BEEN APPLIED PROPERLY AND MAY PEEL ON THE UPPER HORIZONTAL SURFACES DUE TO THE EXCESSIVE HEAT AND SUNLIGHT EXPOSURE EXPERIENCED IN POLICE OR LAW ENFORCEMENT SERVICE. *PE
TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
07226
MALFUNCTION INDICATOR LAMP (MIL) ON--DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P061B--POLICE INTERCEPTOR BUILT BEFORE 10/19/2007. *NJ
07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
0606
EXTENDED COVERAGE PROGRAM FOR FORWARD CLUTCH CYLINDER IN THE TRANSMISSION MAY CRACK AT THE SNAP RING GROOVE LOCATION CAUSING A LOSS OF CLUTCH CAPACITY AND THE EVENTUAL LOSS OF FORWARD GEARS. *TT SUPPLEMENT #2, OWNER NOTIFICATION. *TT SUPPLEMENT #4. *KB
19522
AIR BAG INDICATOR LIGHT ILLUMINATED. *KB
0636
THE FORWARD CLUTCH CYLINDER IN THE TRANSMISSION MAY CRACK AT THE SNAP RING GROOVE LOCATION CAUSING LOSS OF CLUTCH CAPACITY AND THE EVENTUAL LOSS OF FORWARD GEARS. CUSTOMER SATISFACTION PROGRAM 06B36. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *KB SUPPLEMENT #3. *KB
06391
TRANSMISSION OIL COOLER BYPASS VALVE INSPECTION - PROGRAM EXPIRATION EXTENSION. *KB
19299
ENGINE COOLING FAN (8C607) INOPERATIVE. *KB
06B39
TRANSMISSION OIL COOLER (TOC) BYPASS VALVE THAT MAY STICK IN THE CLOSED POSITION, INHIBITING TRANSMISSION COOLING AND POTENTIALLY CAUSING THE TRANSMISSION TO OVERHEAT. CUSTOMER SATISFACTION PROGRAM 06B39. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
051310
HIGH EFFORT TO ACTIVATE HORN - VEHICLES BUILT BEFORE 5/6/2005. *TT OASIS. *TT
052214
DRIVER'S SEAT CUSHION SAGGING. *TT
05247
PARKING BRAKE CONTROL SLOW TO RELEASE, VEHICLES BUILT FROM 12/06/2004 THROUGH 11/21/2005. *TT
052613
LIGHT STEERING EFFORTS AT HIGHWAY SPEEDS. *TT
06203
ENGINE COOLING FAN INOPERATIVE - ENGINE OVERHEATING - POOR A/C PERFORMANCE. *KB
06227
UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. *KB
062512
REDUCTION IN POWER AT WIDE OPEN THROTTLE. *KB
0795
ENGINE OVERHEATING-POOR A/C PERFORMANCE. *KB
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.