Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 51909
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB T2007-02
ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND THE BACKLIGHTS ON THE LED DISPLAY PANELS WILL NOT ILLUMINATE.
19728
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19621
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
19527
HEADLIGHT ADJUSTMENT NEEDED. *KB
19375
WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
19247
OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
TSB T2006-01
GTWY501-AI MODULE REPEATEDLY RESETS DUE TO EXCESSIVE AMBIENT TEMPERATURE OF 150 F OR HIGHER, MODULE WILL NOT FUNCTION AND ALL LED'S FLASH REPEATEDLY.
04194
WATER-IN-FUEL (WIF) LAMP. *TT
05254
EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS -- 6.0L. *TT
052623
COOLANT DEGAS BOTTLE OVERFLOW - 6.0L. *TT
052625
MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE OR CRANK/NO START. *TT
06310
WATER-IN-FUEL (WIF) LAMP ON. *TT
0646
HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L FOR A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *TT
19015
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
19019
LOW BATTERY VOLTAGE - 6.0L DIESEL WITH SINGLE ALTERNATOR. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
05215
BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT
051713
COOLANT DEGAS BOTTLE OVERFLOW. *TT
18884
HARD START, NO START AND/OR OTHER SYMPTOMS CAUSED BY A HIGH PRESSURE OIL SYSTEM LEAK - SERVICE TIP. *TT
18822
TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK. MULTIPLE VEHICLES. FORD OASIS. TO INCLUDE 2006 FORD F-53. *TT
18845
FLUTTER NOISE ON DECELERATION. *TT
18735
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
18749
HIGH PRESSURE OIL LEAK AT AN INJECTOR. A HARD START, OR NO START CONDITION WITH LOW OR NO INJECTION CONTROL PRESSURE (ICP) - SERVICE TIP. *TT
0582
DAYTIME RUNNING LIGHTS INOPERATIVE AND A/C NOT COOLING. *TT
18694
LACK OF POWER AND/OR DTC P2263 OR P0299 AFTER TURBOCHARGER REPLACEMENT - SERVICE TIP. *TT
18525
BUCK/JERK, LACKS POWER, BLACK SMOKE, ROLLING IDLE, SURGE, MIL ON, AND DIAGNOSTIC TROUBLE CODES P2263, P0299, OR P0401. *TT
0531
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT
18397
LACK OF POWER, SURGE, AND/OR DIAGNOSTIC TROUBLE CODES P2263 OR P0299. *TT
05121
ENGINE QUITS UPON DRIVE OR REVERSE ENGAGEMENT, OR WHEN COMING TO A STOP-TORQSHIFT TRANSMISSION. *SC
05139
DIESEL EXHAUST SMELL IN CAB-6.0L ENGINE. *SC
05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
05249
COOLANT DEGAS BOTTLE OVERFLOW. *TT
17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
042518
CRANK NO START, HARD START, RUNS ROUGH AT IDLE - 6.0L ENGINE. *TT *SC
18293
HARD START/LONG CRANK WITH LOW ICP, NO START, OR A ROUGH IDLE. *TT
18069
LOW POWER AND/OR DIAGNOSTIC TROUBLE CODE P0299 OR P2263 - TURBOCHARGER DIAGNOSTIC SERVICE TIP. *TT
18101
INSUFFICIENT CHARGING SYSTEM OUTPUT FOR MODIFIED VEHICLE USE. *TT
18115
VARIOUS DRIVEABILITY CONCERNS SUCH AS HARD START, NO START, HESITATION, RUNS ROUGH, ERRATIC SHIFTS, AND THE MALFUNCTION INDICATOR LAMP ON WITH A VARIETY OF DIAGNOSTIC TROUBLE CODES. WIRING HARNESS CHAFING. *TT
061611
DTC P0172/P0175 AND/OR DOWNHILL ENGINE SURGE WITH 5.4L ENGINE - HARSH TRANSMISSION ENGAGEMENT, SHUDDER ON ACCELERATION IN REVERSE AND/OR SHIFT BUSYNESS WITH 5.45L ENGINE AND TORQSHIFT TRANSMISSION. *KB
06176
HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
06189
MIL ON WITH P0172 OR P0175 - 6.8L ENGINE - VEHICLES BUILT BEFORE 08-22-06. *KB
06213
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L. *TT
06227
UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. *KB
062318
SLOW FUEL FILL ON VEHICLES WITH A 4.6L OR 5.4L ENGINE AND MID-SHIP FUEL TANK. *KB
071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
19082
LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS. *TT
19099
P0404 SERVICE TIP. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.