Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 51909
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
DOR-T7F8K-08
These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer brakes properly.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB-10-23-5
FORD: THERE MAY BE A LACK OF RPM, HESITATION, OR ROUGH RUNNING CONCERNS WHEN THE VEHICLE IS IN IDLE. THERE MAY BE TWO TROUBLE CODES STORED. THE PROBLEM MAY BE CAUSED BY AFTERMARKET GENERATORS INSTALLED OR MODIFICATIONS TO THE FRONT END DRIVE. E-350/450. *RM
TSB-10-12-6
FORD: RUNS ROUGH, LACKS POWER, HARD START, NO START. SOME VEHICLES AND TRUCKS EQUIPPED WITH 6.0L ENGINE MAY EXHIBIT A RUNS ROUGH, LACKS POWER, HARD TO START, NO START CONCERN WITH OR WITHOUT DIAGNOSTIC TROUBLE CODE (DTC) P0611 CODE OR VARIOUS INJECTOR CIRCUIT CODES. *PE
TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
TSB-08-26-3
FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
TSB-08-16-13
FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
TSB-08-20-1
FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
TSB-08-18-6
FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
08-2-11
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
07219
6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
TSB T2007-02
ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND THE BACKLIGHTS ON THE LED DISPLAY PANELS WILL NOT ILLUMINATE.
19728
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19621
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
19527
HEADLIGHT ADJUSTMENT NEEDED. *KB
19375
WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
TSB T2006-02
GTWY401-A1 REV 1.0 AND 2.0 WHEN MODULE TRANSITIONS FROM POWER DOWN (IGNITION OFF) TO ITS POWER UP (IGNITION ON) THE MODULE MAY INTERMITTENTLY MAY NOT WAKE UP. THE MODULE LED PANELS WILL NOT PROVE OUT AND THE BACKLIGHTS ON THE LED DISPLAY PANELS WILL NOT ILLUMINATE.
19244
RUNS ROUGH OR MISFIRE DUE TO A STUCK VALVE. *KB
19247
OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
TSB T2006-01
GTWY501-AI MODULE REPEATEDLY RESETS DUE TO EXCESSIVE AMBIENT TEMPERATURE OF 150 F OR HIGHER, MODULE WILL NOT FUNCTION AND ALL LED'S FLASH REPEATEDLY.
05254
EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS -- 6.0L. *TT
052623
COOLANT DEGAS BOTTLE OVERFLOW - 6.0L. *TT
052625
MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE OR CRANK/NO START. *TT
05B35
CUSTOMER SATISFACTION PROGRAM 05B35 - THE ENGINE CONTROL MODULES MAY NOT BE CALIBRATED TO THE LATEST SOFTWARE LEVELS, ADVERSELY AFFECTING THE PERFORMANCE AND RELIABILITY OF THE ENGINE. *TT
06111
6.0L - MIL ON WITH DTC P2138, P2139, P2140. *TT
0646
HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L FOR A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *TT
06510
6.0L - MIL ON WITH DTC P0460. *TT
0677
ABS LIGHT ON CONCERN - 6.0L DIESEL. *TT
19015
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
19020
PART CHANGES ON VEHICLES BUILT AFTER JANUARY, 2006. CASTING AND MACHINING CHANGES. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
0511
CRACKS IN THE LEFT OR RIGHT SPRING TOWER FLANGE. *TT SPRING TOWER WELD REPAIR AND REPLACEMENT PROCEDURE. *TT
8
FORD-INSTALLED ALTERNATORS. THOMAS BUILT BUSES. *TT
05215
BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT
051713
COOLANT DEGAS BOTTLE OVERFLOW. *TT
18884
HARD START, NO START AND/OR OTHER SYMPTOMS CAUSED BY A HIGH PRESSURE OIL SYSTEM LEAK - SERVICE TIP. *TT
18822
TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK. MULTIPLE VEHICLES. FORD OASIS. TO INCLUDE 2006 FORD F-53. *TT
18845
FLUTTER NOISE ON DECELERATION. *TT
042421
SAFETY BELT RETRACTION SPEED. *TT
0582
DAYTIME RUNNING LIGHTS INOPERATIVE AND A/C NOT COOLING. *TT
18694
LACK OF POWER AND/OR DTC P2263 OR P0299 AFTER TURBOCHARGER REPLACEMENT - SERVICE TIP. *TT
04233
MISFIRE LACK OF POWER BUCK JERK EXCESSIVE SMOKE CRANK NO START 6.0L ENGINE DIAGNOSTICS FOR FUEL SYSTEM . *EH SERVICE TIPS. *TT
04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
05139
DIESEL EXHAUST SMELL IN CAB-6.0L ENGINE. *SC
05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
05249
COOLANT DEGAS BOTTLE OVERFLOW. *TT
061611
DTC P0172/P0175 AND/OR DOWNHILL ENGINE SURGE WITH 5.4L ENGINE - HARSH TRANSMISSION ENGAGEMENT, SHUDDER ON ACCELERATION IN REVERSE AND/OR SHIFT BUSYNESS WITH 5.45L ENGINE AND TORQSHIFT TRANSMISSION. *KB
061612
SERVICE CALIBRATION UPDATE - LOSS OF RPM ON DECELERATION - 6.8L. *KB
06171
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
06176
HIGH PRESSURE SYSTEM DIAGNOSTICS - 6.0L ENGINES. *KB
061811
SERVICE CALIBRATION UPDATE - LOSS OF RPM ON DECELERATION - 6.8L. *KB UPDATED 07-25-07. *KB
06189
MIL ON WITH P0172 OR P0175 - 6.8L ENGINE - VEHICLES BUILT BEFORE 08-22-06. *KB
06213
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L. *TT
06229
6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB
071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
0714
LACK OF COOLING FAN OPERATION. *KB
0754
COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
19082
LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS. *TT
19092
INTERMITTENT DTC P0316. *TT
19099
P0404 SERVICE TIP. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.