Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB-08-26-3
FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
TSB-08-20-1
FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
04194
WATER-IN-FUEL (WIF) LAMP. *TT
052623
COOLANT DEGAS BOTTLE OVERFLOW - 6.0L. *TT
052625
MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE OR CRANK/NO START. *TT
06310
WATER-IN-FUEL (WIF) LAMP ON. *TT
19015
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
19019
LOW BATTERY VOLTAGE - 6.0L DIESEL WITH SINGLE ALTERNATOR. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
05215
BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005. *TT
051713
COOLANT DEGAS BOTTLE OVERFLOW. *TT
05185
RPM SURGE AT IDLE - AUDIBLE EGR SURGE - LOW POWER/EXHAUST SMOKE/ROUGH IDLE FOLLOWING COLD START - HIGH RPM IN BATTERY CHARGE PROTECTION MODE - DIAGNOSTIC TROUBLE CODE P0488 AND P1334 - 6.0L ENGINE. *TT
18822
TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK. MULTIPLE VEHICLES. FORD OASIS. TO INCLUDE 2006 FORD F-53. *TT
18845
FLUTTER NOISE ON DECELERATION. *TT
04B24
LOW/REVERSE GEAR SET PINION SHAFT(S) THAT MAY WALK OUT, CAUSING METALLIC PARTICLE CONTAMINATION. CUSTOMER SATISFACTION PROGRAM 04B24. TRANSMISSION REVERSE PLANET REPLACEMENT. *TT SUPPLEMENT #1 AND #2. *TT SUPPLEMENT #3. *TT
18734
DIAGNOSTIC TROUBLE CODE P0488 SET AFTER REFLASH. *TT
0582
DAYTIME RUNNING LIGHTS INOPERATIVE AND A/C NOT COOLING. *TT
18694
LACK OF POWER AND/OR DTC P2263 OR P0299 AFTER TURBOCHARGER REPLACEMENT - SERVICE TIP. *TT
18598
INTERMITTENT CRANK NO START DUE TO AN EGR THROTTLE PLATE THAT IS STUCK CLOSED. THE ENGINE MAY SEEM LIKE IT HAS NO COMPRESSION DUE TO A FASTER THAN NORMAL CRANKING SPEED OF GREATER THAN 200 RPM. DTC P0488 OR P1334 MAY OR MAY NOT BE PRESENT. *TT
18525
BUCK/JERK, LACKS POWER, BLACK SMOKE, ROLLING IDLE, SURGE, MIL ON, AND DIAGNOSTIC TROUBLE CODES P2263, P0299, OR P0401. *TT
18397
LACK OF POWER, SURGE, AND/OR DIAGNOSTIC TROUBLE CODES P2263 OR P0299. *TT
05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
05249
COOLANT DEGAS BOTTLE OVERFLOW. *TT
18362
LACK OF POWER OR RUNS ROUGH CONDITION, AND/OR THE MALFUNCTION INDICATOR LIGHT ON WITH EGR RELATED DIAGNOSTIC TROUBLE CODES (P0401, P0402, P0403, P0404, P0405, OR P0406). *TT
18376
A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT
042516
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0756, P0761 OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005 TORQSHIFT TRANSMISSION. *TT
042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04N03
CUSTOMER SATISFACTION PROGRAM 04N03. ADDITIONAL WARRANTY COVERAGE FOR ANTI-LOCK BRAKE SYSTEM MODULE. *TT
18250
INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT
04174
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
18051
DELAYED/HARSH FORWARD OR REVERSE ENGAGEMENTS. *TT
18069
LOW POWER AND/OR DIAGNOSTIC TROUBLE CODE P0299 OR P2263 - TURBOCHARGER DIAGNOSTIC SERVICE TIP. *TT
18101
INSUFFICIENT CHARGING SYSTEM OUTPUT FOR MODIFIED VEHICLE USE. *TT
18115
VARIOUS DRIVEABILITY CONCERNS SUCH AS HARD START, NO START, HESITATION, RUNS ROUGH, ERRATIC SHIFTS, AND THE MALFUNCTION INDICATOR LAMP ON WITH A VARIETY OF DIAGNOSTIC TROUBLE CODES. WIRING HARNESS CHAFING. *TT
17905
MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT
17949
MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P2195, P2916, P2197 AND/OR P2198. *TT
06213
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L. *TT
19082
LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS. *TT
19099
P0404 SERVICE TIP. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.