Vehicle report

1997 FORD E SERIES

Compare every FORD E SERIES yearNHTSA and EPA records

Service bulletins

120 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

TSB-11-11-21

Service Bulletin/Repair Instructions

FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE

07212

Service Bulletin/Repair Instructions

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

041601

Service Bulletin/Repair Instructions

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

020503

Service Bulletin/Repair Instructions

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT

05417

Service Bulletin/Repair Instructions

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT

032306

Service Bulletin/Repair Instructions

DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT

04266

Service Bulletin/Repair Instructions

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT

042107

Service Bulletin/Repair Instructions

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

031404

Service Bulletin/Repair Instructions

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.

17777

Service Bulletin/Repair Instructions

REAR LEAF SPRING NOISE. *TT

16515

Service Bulletin/Repair Instructions

OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT

03236

Service Bulletin/Repair Instructions

DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT

17320

Service Bulletin/Repair Instructions

BROKEN EXHAUST MANIFOLD STUDS. *TT

17385

Service Bulletin/Repair Instructions

AIR BAG LAMP ILLUMINATED. *TT

032122

Service Bulletin/Repair Instructions

ROLLING IDLE, SURGE ON VEHICLES BUILT 8/96 THROUGH 12/96 WITH 7.3L ENGINE. *TT

032145

Service Bulletin/Repair Instructions

EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT

03206

Service Bulletin/Repair Instructions

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, PLUGGED CATALYTIC CONVERTER AND NO START CONDITION. *TT

17254

Service Bulletin/Repair Instructions

CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT

03181

Service Bulletin/Repair Instructions

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT

03183

Service Bulletin/Repair Instructions

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT

03144

Service Bulletin/Repair Instructions

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT

16916

Service Bulletin/Repair Instructions

REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT

0398

Service Bulletin/Repair Instructions

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

0342

Service Bulletin/Repair Instructions

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB

030402

Service Bulletin/Repair Instructions

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT

03261

Service Bulletin/Repair Instructions

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT

02221

Service Bulletin/Repair Instructions

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ

870197

Service Bulletin/Repair Instructions

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT

02176

Service Bulletin/Repair Instructions

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

02168

Service Bulletin/Repair Instructions

REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT

16040

Service Bulletin/Repair Instructions

EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT

15901

Service Bulletin/Repair Instructions

THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT

0253

Service Bulletin/Repair Instructions

SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT

0214

Service Bulletin/Repair Instructions

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT

01246

Service Bulletin/Repair Instructions

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT

01233

Service Bulletin/Repair Instructions

SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA. *TT

01234

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT

01221

Service Bulletin/Repair Instructions

SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT

15373

Service Bulletin/Repair Instructions

SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT

15397

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT

01205

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT

15355

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT

01181

Service Bulletin/Repair Instructions

BRAKE SHIFT INTERLOCK.*JB

15218

Service Bulletin/Repair Instructions

INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR. *TT

01157

Service Bulletin/Repair Instructions

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

15150

Service Bulletin/Repair Instructions

SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR. *ET

15161

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE. *YH

15099

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP.

01119

Service Bulletin/Repair Instructions

SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT

14943

Service Bulletin/Repair Instructions

SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT PEDESTAL (OPTION 21Z), BUT MANUFACTURED WITHOUT A SEAT, MAY HAVE A CONDITION OF REPEAT POWE SEAT TRACK FAILURE. *TT

14735

Service Bulletin/Repair Instructions

SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM UNDER HEAVY ACCELERATION (WOT) OR A LOADED DRIVE MODE. *TT

14514

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT

14455

Service Bulletin/Repair Instructions

OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT

14374

Service Bulletin/Repair Instructions

SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES. *JB

8058

Service Bulletin/Repair Instructions

SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR

13934

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT

8260

Service Bulletin/Repair Instructions

13832

Service Bulletin/Repair Instructions

SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT

13870

Service Bulletin/Repair Instructions

CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT

8138

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT

14240

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS EXPERIENCED BEST IN A SLIGHT TURN, AT SPEEDS NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. ENGINEERING IS ADDRESSING THE CONCERN AND RELEASING AN IMPROVED DESIGN FOR THE LOWER INTERMEDIATE STEERING SHAFT AND UPPER STEERING JOINT. *TT

13322

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT

13331

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT

13285

Service Bulletin/Repair Instructions

EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT

13117

Service Bulletin/Repair Instructions

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT

996890

Service Bulletin/Repair Instructions

SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT

991411

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT

6350

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT

6538

Service Bulletin/Repair Instructions

SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT

6599

Service Bulletin/Repair Instructions

SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.

12870

Service Bulletin/Repair Instructions

SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT

12915

Service Bulletin/Repair Instructions

CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT

6417

Service Bulletin/Repair Instructions

ADDRESSING TIRE BALANCE HINTS. *TT

6461

Service Bulletin/Repair Instructions

CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T

12741

Service Bulletin/Repair Instructions

SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT

12743

Service Bulletin/Repair Instructions

EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT

12744

Service Bulletin/Repair Instructions

SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT

12798

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT

6290

Service Bulletin/Repair Instructions

INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT

996130

Service Bulletin/Repair Instructions

INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT

12556

Service Bulletin/Repair Instructions

SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT

12593

Service Bulletin/Repair Instructions

CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT

12298

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT

5203

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT

12070

Service Bulletin/Repair Instructions

VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS

12123

Service Bulletin/Repair Instructions

VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS

12162

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS

12174

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS

985072

Service Bulletin/Repair Instructions

SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT

985153

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT

985199

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS

11776

Service Bulletin/Repair Instructions

SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT

11796

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT

4658

Service Bulletin/Repair Instructions

SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT

4684

Service Bulletin/Repair Instructions

SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT

980301

Service Bulletin/Repair Instructions

CONDITION WITH ROUGH IDLE. *YC

980302

Service Bulletin/Repair Instructions

SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC

980303

Service Bulletin/Repair Instructions

SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK

980304

Service Bulletin/Repair Instructions

COMPLAINTS REGARDING THE FUEL ECONOMY. *YC

980307

Service Bulletin/Repair Instructions

CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC

980323

Service Bulletin/Repair Instructions

CONCERNS WITH EXTERNAL OIL LEAKS. *YC

982733

Service Bulletin/Repair Instructions

VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC

980317

Service Bulletin/Repair Instructions

PARK BRAKE CABLE DRAG, CAUSING REAR BRAKE VIBRATION. *AK

976007

Service Bulletin/Repair Instructions

BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT

BC0053970201

Service Bulletin/Repair Instructions

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

BC0255970201

Service Bulletin/Repair Instructions

4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD

BC0256970201

Service Bulletin/Repair Instructions

A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD

BC0693961023

Service Bulletin/Repair Instructions

INVESTIGATING 7.3L IRREGULAR IDLE. *TT

BC0695961023

Service Bulletin/Repair Instructions

'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON 4.2L ENGINES. *TT

BC0696961023

Service Bulletin/Repair Instructions

CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT

BC0750961017

Service Bulletin/Repair Instructions

SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT

BC0782961014

Service Bulletin/Repair Instructions

CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT

BC0844961008

Service Bulletin/Repair Instructions

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT

BC0853961007

Service Bulletin/Repair Instructions

AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT

BC0883961004

Service Bulletin/Repair Instructions

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT

BC0884961004

Service Bulletin/Repair Instructions

FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT

BC5195961001

Service Bulletin/Repair Instructions

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT

BC5197961001

Service Bulletin/Repair Instructions

SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT

BC5201961001

Service Bulletin/Repair Instructions

INVESTIGATING 7.3L IRREGULAR IDLE. *TT

BC5219961001

Service Bulletin/Repair Instructions

INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.