TSB-11-11-21
Service Bulletin/Repair Instructions
FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
Vehicle report
1999 FORD E SERIES
Service bulletins
141 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
07212
Service Bulletin/Repair Instructions
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
19015
Service Bulletin/Repair Instructions
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
041601
Service Bulletin/Repair Instructions
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
020503
Service Bulletin/Repair Instructions
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
0554
Service Bulletin/Repair Instructions
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
05417
Service Bulletin/Repair Instructions
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
032306
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
04266
Service Bulletin/Repair Instructions
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
18376
Service Bulletin/Repair Instructions
A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
032151
Service Bulletin/Repair Instructions
SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT
031404
Service Bulletin/Repair Instructions
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
17777
Service Bulletin/Repair Instructions
REAR LEAF SPRING NOISE. *TT
032150
Service Bulletin/Repair Instructions
HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT
16515
Service Bulletin/Repair Instructions
OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT
17520
Service Bulletin/Repair Instructions
CLUNK FROM FRONT SUSPENSION. *TT
03236
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
17320
Service Bulletin/Repair Instructions
BROKEN EXHAUST MANIFOLD STUDS. *TT
17385
Service Bulletin/Repair Instructions
AIR BAG LAMP ILLUMINATED. *TT
032133
Service Bulletin/Repair Instructions
SIGNIFICANT 1999 7.3L DIESEL ENGINE CONTENT REVISIONS. *TT
032139
Service Bulletin/Repair Instructions
7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS BULLETIN ALSO REPLACES 01146. *TT
032145
Service Bulletin/Repair Instructions
EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
032146
Service Bulletin/Repair Instructions
ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
032149
Service Bulletin/Repair Instructions
A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO. *TT
11672
Service Bulletin/Repair Instructions
7.3L DIT TURBOCHARGER REPLACEMENT UNDER WARRANTY. FORD SPECIAL SERVICE MESSAGE. *TT
16589
Service Bulletin/Repair Instructions
GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
17023
Service Bulletin/Repair Instructions
NO TURBINE SHAFT SPEED (TSS) DISPLAYED USING NGS OR WDS. *TT
03206
Service Bulletin/Repair Instructions
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, PLUGGED CATALYTIC CONVERTER AND NO START CONDITION. *TT
17254
Service Bulletin/Repair Instructions
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
03192
Service Bulletin/Repair Instructions
LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03183
Service Bulletin/Repair Instructions
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
03171
Service Bulletin/Repair Instructions
7.3L DIESEL HIGH PRESSURE OIL PUMP LEAK. *TT
031410
Service Bulletin/Repair Instructions
TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03144
Service Bulletin/Repair Instructions
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03149
Service Bulletin/Repair Instructions
A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO. *TT
16916
Service Bulletin/Repair Instructions
REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT
03102
Service Bulletin/Repair Instructions
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
03103
Service Bulletin/Repair Instructions
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
03104
Service Bulletin/Repair Instructions
BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
0398
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
0342
Service Bulletin/Repair Instructions
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
030402
Service Bulletin/Repair Instructions
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
03261
Service Bulletin/Repair Instructions
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
02221
Service Bulletin/Repair Instructions
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
02227
Service Bulletin/Repair Instructions
ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ
16403
Service Bulletin/Repair Instructions
ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ
870197
Service Bulletin/Repair Instructions
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02168
Service Bulletin/Repair Instructions
REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT
16040
Service Bulletin/Repair Instructions
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
02108
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT
0253
Service Bulletin/Repair Instructions
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
0245
Service Bulletin/Repair Instructions
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
15686
Service Bulletin/Repair Instructions
CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT
15742
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT
15761
Service Bulletin/Repair Instructions
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
0214
Service Bulletin/Repair Instructions
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01231
Service Bulletin/Repair Instructions
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
01233
Service Bulletin/Repair Instructions
SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA. *TT
01234
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT
01221
Service Bulletin/Repair Instructions
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
15373
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
15397
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
012110
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
012113
Service Bulletin/Repair Instructions
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT
01214
Service Bulletin/Repair Instructions
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
01205
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01196
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT FRONT DOOR (DRIVER AND / OR PASSENGER SIDE) DISENGAGEMENT OF THE OUTER DOOR PANEL FROMTHE INNER DOOR PANEL AT THE FRONT EDGE OF THE DOOR. *TT
15355
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
15218
Service Bulletin/Repair Instructions
INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR. *TT
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15150
Service Bulletin/Repair Instructions
SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR. *ET
15161
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE. *YH
01137
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT. *TT
15099
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP.
01119
Service Bulletin/Repair Instructions
SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT
14907
Service Bulletin/Repair Instructions
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT
14943
Service Bulletin/Repair Instructions
SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT PEDESTAL (OPTION 21Z), BUT MANUFACTURED WITHOUT A SEAT, MAY HAVE A CONDITION OF REPEAT POWE SEAT TRACK FAILURE. *TT
14821
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
14864
Service Bulletin/Repair Instructions
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
13846
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA. *TT
14735
Service Bulletin/Repair Instructions
SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM UNDER HEAVY ACCELERATION (WOT) OR A LOADED DRIVE MODE. *TT
14514
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT
14455
Service Bulletin/Repair Instructions
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
14374
Service Bulletin/Repair Instructions
SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES. *JB
8276
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A TRANSMISSION FLUID LEAK FROM THE TRANSMISSION COOLER HOSE AUXILLARY COOLER. **MR
13934
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
13949
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT ON OR AFTER MARCH 1, 1999 MAY EXHIBIT A TRANSMISSION FLUID LEAK FROM THE TRANSMISSION COOLER HOSE TO AUXILIARY COOLER. *TT
8260
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
13870
Service Bulletin/Repair Instructions
CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
8093
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
8138
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
14233
Service Bulletin/Repair Instructions
SOME VEHICLES EQUPPED WITH A 5.4L OR 6.8L ENGINE MAY EXHIBIT A ROLLING / ROUGH IDLE. *TT
14240
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS EXPERIENCED BEST IN A SLIGHT TURN, AT SPEEDS NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. ENGINEERING IS ADDRESSING THE CONCERN AND RELEASING AN IMPROVED DESIGN FOR THE LOWER INTERMEDIATE STEERING SHAFT AND UPPER STEERING JOINT. *TT
13322
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13331
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13398
Service Bulletin/Repair Instructions
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
7310
Service Bulletin/Repair Instructions
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
13285
Service Bulletin/Repair Instructions
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6935
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRAGETY. *TT
13117
Service Bulletin/Repair Instructions
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT
13163
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR STRATEGY. *TT
996701
Service Bulletin/Repair Instructions
VEHICLES WITH 5.4L ENGINES AND 9VZA-AH OR 9VZA-BL CALIBRATIONS MAY SET A MIL LIGHT WITH A DIAGNOSTIC TROUBLE CODE OF P1406 (DPFE DOWNSTREAM HOSE OFF OR PLUGGED). *TT
996890
Service Bulletin/Repair Instructions
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT
991411
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT
13009
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 5.4L ENGINES AND 9VZA-AH OR 9VZA-BL CALIBRATIONS MAY SET A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE OF P1406 (DPFE DOWNSTREAM HOSE OFF OR PLUGGED). *TT
6350
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6538
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
6599
Service Bulletin/Repair Instructions
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
12870
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
12915
Service Bulletin/Repair Instructions
CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
6417
Service Bulletin/Repair Instructions
ADDRESSING TIRE BALANCE HINTS. *TT
6461
Service Bulletin/Repair Instructions
CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T
12741
Service Bulletin/Repair Instructions
SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT
12743
Service Bulletin/Repair Instructions
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12744
Service Bulletin/Repair Instructions
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12798
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6290
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT
12550
Service Bulletin/Repair Instructions
SUBJECT ON ANTI-LOCK BRAKE SYSTEM (ABS) LAMP STRATEGY CHANGE.
12556
Service Bulletin/Repair Instructions
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
12593
Service Bulletin/Repair Instructions
CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT
12243
Service Bulletin/Repair Instructions
SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLE DAUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY. *TT
5225
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING A HARD TO DIAGNOSE SQUEAK / RATTLE NOISE CONCERN. *TT
5311
Service Bulletin/Repair Instructions
SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLED AUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY. *TT
12070
Service Bulletin/Repair Instructions
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS
12123
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS
12134
Service Bulletin/Repair Instructions
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
12144
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A 4R100 TRANSMISSION NORMAL MAINTENANCE SCHEDULE, IS NOT CORRECT. *MJS
12162
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
12187
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD TO DIAGNOSE SQUEAK/RATTLE NOISE CONCERN. *MJS
985072
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
985153
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT
985183
Service Bulletin/Repair Instructions
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
985199
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
11776
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
4658
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
980307
Service Bulletin/Repair Instructions
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.