Vehicle report

2003 FORD E SERIES

Service bulletins

63 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

SSM 51536

Service Bulletin/Repair Instructions

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

TSB-11-11-21

Service Bulletin/Repair Instructions

FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE

SB-09M02

Service Bulletin/Repair Instructions

FORD: CERTAIN VEHICLES WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT; SPECIFIC COMPONENT WARRANTY EXTENSION. AWARENESS COMMUNICATION, DATED 4/20/09. *PE

SB-09M03

Service Bulletin/Repair Instructions

FORD: CERTAIN VEHICLES, E SERIES AND F SUPER DUTY, WITH AMBULANCE PREP PACKAGE AMBULANCE CLASS ACTION SETTLEMENT-6.0L DIESEL ENGINE REPLACEMENT WARRANTY EXTENSION. AWARENESS COMMUNICATION DATED 4/20/09. *PE

SB-20937

Service Bulletin/Repair Instructions

FORD: MULTIPLE VEHICLES WITH A TORQ SHIFT TRANSMISSION INTERMITTENT CLUNK WHEN SHIFTING BETWEEN DRIVE, REVERSE AND PARK AND/OR DURING 2-3 UPSHIFT. MODELS F SUPER DUTY; E SERIES; EXCURSION; F53 MOTORHOME CHASSIS AND LOW CAB FORWARD. *PE

07212

Service Bulletin/Repair Instructions

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

19015

Service Bulletin/Repair Instructions

FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT

041601

Service Bulletin/Repair Instructions

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

042421

Service Bulletin/Repair Instructions

SAFETY BELT RETRACTION SPEED. *TT

020503

Service Bulletin/Repair Instructions

GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT

0554

Service Bulletin/Repair Instructions

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT

05417

Service Bulletin/Repair Instructions

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT

04266

Service Bulletin/Repair Instructions

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT

18376

Service Bulletin/Repair Instructions

A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT

04228

Service Bulletin/Repair Instructions

HARD START OR NO START. *EH

042107

Service Bulletin/Repair Instructions

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

032151

Service Bulletin/Repair Instructions

SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT

031404

Service Bulletin/Repair Instructions

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.

17905

Service Bulletin/Repair Instructions

MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT

17885

Service Bulletin/Repair Instructions

LACK OF POWER AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P2263 AFTER TURBOCHARGER REPLACEMENT. *TT

0484

Service Bulletin/Repair Instructions

CHASSIS COMPONENT TORQUE UPDATE FOR E-COATED FRAMES. *TT

17777

Service Bulletin/Repair Instructions

REAR LEAF SPRING NOISE. *TT

17695

Service Bulletin/Repair Instructions

STEERING WHEEL NIBBLE 50-65 MPH. *TT

032150

Service Bulletin/Repair Instructions

HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT

16515

Service Bulletin/Repair Instructions

OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT

17508

Service Bulletin/Repair Instructions

FALSE DIAGNOSTIC TROUBLE CODES (DTC'S SET DURING USE OF ACTIVE COMMANDS WITH WDS. *TT

17520

Service Bulletin/Repair Instructions

CLUNK FROM FRONT SUSPENSION. *TT

03256

Service Bulletin/Repair Instructions

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ

03236

Service Bulletin/Repair Instructions

DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT

17320

Service Bulletin/Repair Instructions

BROKEN EXHAUST MANIFOLD STUDS. *TT

17385

Service Bulletin/Repair Instructions

AIR BAG LAMP ILLUMINATED. *TT

032145

Service Bulletin/Repair Instructions

EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT

032146

Service Bulletin/Repair Instructions

ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT

16589

Service Bulletin/Repair Instructions

GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT

17023

Service Bulletin/Repair Instructions

NO TURBINE SHAFT SPEED (TSS) DISPLAYED USING NGS OR WDS. *TT

03206

Service Bulletin/Repair Instructions

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, PLUGGED CATALYTIC CONVERTER AND NO START CONDITION. *TT

17244

Service Bulletin/Repair Instructions

IGNITION SWITCH LOCK CYLINDERS BINDS IN OFF AND LOCK POSITIONS. *TT

17245

Service Bulletin/Repair Instructions

ENGINE REMAINING AT IDLE EVEN WHEN THE ACCELERATOR PEDAL IS DEPRESSED. *TT

17254

Service Bulletin/Repair Instructions

CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT

17259

Service Bulletin/Repair Instructions

ROUGH IDLE AND/OR MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0316 AFTER AN OVERNIGHT SOAK IN EXTREME COLD AND HIGH HUMIDITY CONDITIONS. *TT

03192

Service Bulletin/Repair Instructions

LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT

03181

Service Bulletin/Repair Instructions

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT

03183

Service Bulletin/Repair Instructions

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT

03171

Service Bulletin/Repair Instructions

7.3L DIESEL HIGH PRESSURE OIL PUMP LEAK. *TT

03164

Service Bulletin/Repair Instructions

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT

17079

Service Bulletin/Repair Instructions

WATER PUMP PULLEY BOLTS LOOSENING. *TT

031410

Service Bulletin/Repair Instructions

TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT

03144

Service Bulletin/Repair Instructions

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT

16916

Service Bulletin/Repair Instructions

REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT

0398

Service Bulletin/Repair Instructions

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

16818

Service Bulletin/Repair Instructions

THROTTLE CONTROL SPLASH SHIELD INSTALLATION REQUIREMENTS. *TT

0342

Service Bulletin/Repair Instructions

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB

030402

Service Bulletin/Repair Instructions

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT

03261

Service Bulletin/Repair Instructions

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT

3C2414A411AA

Service Bulletin/Repair Instructions

E-SERIES CHASSIS CAB AND CUTAWAY 12A581 BACK-UP CIRCUIT REPAIR PROCEDURE. *TT

02221

Service Bulletin/Repair Instructions

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ

02227

Service Bulletin/Repair Instructions

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ

16403

Service Bulletin/Repair Instructions

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ

16407

Service Bulletin/Repair Instructions

WATER PUMP PULLEY BOLTS LOOSE. *MJ

870197

Service Bulletin/Repair Instructions

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT

16309

Service Bulletin/Repair Instructions

HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT

02176

Service Bulletin/Repair Instructions

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

02168

Service Bulletin/Repair Instructions

REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.