Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 54808
Service Bulletin/Repair Instructions
The instrument panel cluster (IPC) in 2023-2026 Escape and 2025-2026 Maverick hybrid vehicles has a power gauge section on the left side of the display. This power gauge section has a white or gray engine icon that is specifically used to indicate when the vehicle is operating in a specific hybrid mode. The white or gray engine icons are a normal function of the vehicles hybrid display and do not indicate that there is a malfunction and no service actions are necessary to address it. The Owners Manual and Workshop Manual, Section 413-01 > Description and Operation are expected to be updated by the end of Q2 2026.
SSM 54631
Service Bulletin/Repair Instructions
Some 2020-2026 Escape and 2022-2026 Maverick 2.5L Duratec hybrid vehicles may require various repairs on the exhaust system. This may require removal of the exhaust heat exchanger. WSM, Section 309-00 Exhaust System > 2.5L Duratec hybrid > Removal and Installation > Exhaust Heat Exchanger has been revised to eliminate the need to remove the muffler assembly. The procedure steps and labor times have been updated to reflect this adjustment.
SSM 54250
Service Bulletin/Repair Instructions
Some 2024-2025 Escape Hybrid/Maverick Hybrid/Nautilus Hybrid/F-150 non-Lightning/F-Super Duty/Bronco and 2025 Expedition/Navigator/Ranger vehicles where customers have installed an aftermarket supplemental braking system may experience a discharged 12-volt battery after recreational towing. This may be due to the supplemental braking system keeping the vehicle awake during brake applications. Advise customers that while recreational towing the vehicle with a supplemental braking system installed, it is recommended to use a 12-volt battery charger connected to a power source external to the vehicle being towed. The Owners Manual is in process of being updated with this information.
24N19
Other
Certain 2020-2024 Model Year Escape and 2021-2024 Model Year Corsair Plug-in Hybrid Electric Vehicles (PHEV) – High Voltage Battery Replacement
SSM 53352
Service Bulletin/Repair Instructions
When replacing the 12V battery on 2022-2025 Escape hybrid vehicles, download and run the Battery Type Configuration application using the latest version of the Ford Diagnostic and Repair System (FDRS) scan tool.
24B26
Service Bulletin/Repair Instructions
In all of the affected vehicles, the transmission sun gear bearing was incorrectly installed and may cause premature failure of the transmission.
SSM 52773
Service Bulletin/Repair Instructions
2023-2024 F-150/Escape/Explorer/Maverick and 2024 Nautilus vehicles equipped with a full hybrid electric vehicle (FHEV) powertrain may exhibit diagnostic trouble codes (DTCs) P0A7D and/or P0DE6 and the vehicle identification number (VIN) is not recognized by the Midtronics xRC-3363 High Voltage Battery Rescue Charger. This may be due to the software level of the Midtronics xRC-3363 High Voltage Battery Rescue Charger.
TSB 24-2078
Service Bulletin/Repair Instructions
This article supersedes TSB 23-2244 to add 2024 model year. Some 2020-2024 Escape hybrid vehicles equipped with a 2.5L (FHEV) full hybrid electric vehicle powertrain and 4-wheel drive (4WD) may exhibit a grinding or rubbing noise while braking at or below 10 mph (16 km/h) from the front of the vehicle. This may be due to an inadequate gap between the driveshaft and the heat shield. To correct this condition, follow the Service Procedure to diagnose and position the heat shield away from the driveshaft.