Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
05618
REAR AXLE NOISE REPAIR. *TT
0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
050618
REAR AXLE NOISE REPAIR. *SC
042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
0454
AIR SUSPENSION COMPRESSOR NOISE. *TT
0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
17459
COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT
17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
031513
TIE ROD END INSPECTION PROCEDURE. *TT
03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
0392
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
0399
TIE ROD END INSPECTION PROCEDURE. *TT
030709
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
16015
SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT
15897
SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT
15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
15939
CONCERNS WITH SPEED BODY BOOM. *TT
15794
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
15727
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
15749
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT
15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
15648
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT
15651
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT
0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
15526
SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD
15528
SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD
15549
INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH
01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
15480
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT
15362
SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT
01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01181
BRAKE SHIFT INTERLOCK.*JB
14372
INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION. *JB
01166
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC
01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC
15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC
15152
SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET
01128
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. *TT
14905
SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED. *TT
0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
14359
SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB
14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
14197
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION. *TT
981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
0018
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. *MJS
13711
SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS
13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS
13744
SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS
13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS
7896
SERVICING TRAILER HITCH.
7897
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT. THIS INDICATES NO COMMUNICATION BETWEEN RADIO AND DISC PLAYER.
7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.
99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS
99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99157
SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT
99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
6686
SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION. *TT
12994
SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM. *TT
6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
6332
CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES. *TT
9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
12796
ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES. *TT
12797
ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT
12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT
9912778
INFORMATION REGARDING NEW SERVICE STEERING GEAR. *TT
9912792
CONDITIONS ON BROKENT DOOR PULL HANDLES. *TT
996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
12572
VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION. *TT
5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
99B02
INFORMATION ON REPLACING MULTIFUNCTION SWITCH. *TT
982521
CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES. *YC
98254
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC
98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12282
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
4802
REAR WIPER ARM INSTALLATION. *TT
4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
5206
FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION / SPARK KNOCK. *TT
5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
5370
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
98239
EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES. *YC8
12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
12170
INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION/SPARK KNOCK. *MJS
12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
984802
WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92. *YC
985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
985185
COLD START ENGINE NOISE
982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
98-4802
INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM. *TT
98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
98163
LOCKS FAILED. YD
981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
981515
A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK
11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
11806
SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL. *TT
4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT
4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *TT
4698
ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE. *TT
98021698312
SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE. *YC
9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
9874
A NEW SILICONE GASKET AND SEALANT. *YC
11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY AND THE VEHICLE TRANSCEIVER. *TT
980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
982544
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC
982545
IMPORTANT SERVICE INSTRUCTIONS FOR ONP 97-B-17, EXPEDITION ONLY. *YC
982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
982741
SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK
98613
SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC
9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
98417
COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC
98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
9831
REPAIRS TO VINYL COVERED SURFACES. *YC
9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
983284
SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM. *TT
983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
983582
ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT
983592
SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT
090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT
971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
970902971811
CONCERNS WITH "SQUEAKING" AND/OR "RATTLING" NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC
97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
97050110612
RATTLE OR BUZZ IN TAILGATE TRIM PANEL AFTER REMOVAL IF THE RETAINING CLIPS ARE NOT REPLACED AFTER REPAIR. *TW
97050110618
STRESS CRACKS ON WINDSHIELDS. *TW
97050110622
REQUEST FOR INFORMATION ON CONCERNS OF LEATHER SEAT COVERS WRINKLING, FOLDING,LEATHER WEAR OR CRACKING. *TW
97050110632
NEWLY DESIGNED VOLUME KNOB, INCORPORATING A MOMENTARY ON/OFF SWITCH. *TW
BC105819705
SOME EXPEDITIONS MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW
BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW
BC105969705
VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK. *TW
BC106039705
INSTRUCTIONS ON HOW TO ENABLE AND DISABLE THE AUTO LOCK FEATURE. *TW
BC2225970501
RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK. *TW
BC2226970501
SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
BC2245970501
INSTRUCTIONS FOR ENABLING/DISABLING THE AUTOMATIC LOCK FEATURE. *TW
BC2305970501
VEHICLES MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW
BC2307970501
LOSS OF SOME ACCESSORIES SUCH AS DRIVER'S POWER WINDOW FUNCTION WHEN THE TRANSMISSION IS SHIFTED OUT OF PARK OR NEUTRAL. *TW
BC2363970501
THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW
BC2375970501
VEHICLES BUILT BEFORE 3/24/97 MAY EXPERIENCE WIND NOISE AT THE A-PILLAR. *TW
BC2382970501
VEHICLES MAY EXPERIENCE A STAINING OF THE ANODIZED ALUMINUM TRIM WITH THE USE OF SOME CAR WASHES WHICH CONTAIN ULTRA VIOLET PROTECTANTS. *TW
BC3007970501
REVISION TO THE TECHNICAL INSTRUCTIONS WHEN PERFORMING RECALL 96S60. *TW
97713
NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD
97614
STEERING COLUMN- HIGH SPEED VIBRATION- 4X2 VEHICLES EQUIPPED WITH 5.4L ENGINE. *JD
97620
MALFUNCTION INDICATOR LAMP (MIL) - ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN CONTINUOUS MEMORY- VEHICLES BUILT THROUGH 1/17/97. *JD
97626
ENGINE- CHECKING ENGINE OIL LEVEL IN OWNER'S GUIDE INCORRECT. *JD
9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
96S60
REVISED TECHNICAL INSTRUCTIONS CONCERNING RECALL 96S60. *TW
9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
BC3060970228
INSTRUCTIONS FOR RESETTING THE TRIP COMPUTER. *TW
BC3062970228
ILLUMINATION OF CHECK ENGINE LIGHT WITH DTC P0446 MAY BE DUE TO CONTAMINATED CANNISTER, EVAP LINES OR VENT SOLENOID. *TW
BC3070970227
CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW
BC3090970225
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW
BC3140970220
INOPERATIVE CD CHANGER MAY BE DUE TO LOOSE 66 PIN CONNECTOR. *TW
BC3141970220
VEHICLES BUILT WITH RUNNING BOARDS AFTER 1/30/97 WILL NOT HAVE SEALS ON THE LOWER EDGE OF THE FRONT AND REAR DOORS. *TW
BC3153970219
INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW
97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD
BC3270970207
CHECK ENGINE LIGHT - DTC P0446 - CHECK FOR MOLD FLASHING IN THE 90 DEGREE ELBOW EVAP LINE CONMING OUT OF THE CANNISTER. *TW
BC3272970207
VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW
BC3277970207
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH CERTAIN GARAGES/CARPORTS. *TW
BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
BC0318A97020
FRONT DRIVE AXLE FLUID LEAK. *TW
BC1033797020
CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD
BC1034197020
RESETTING OF THE TRIPCOMPUTER ON EXPEDITION & NAVIGATOR WHERE THE INFORMATION IS NOT CONTAINED IN THE OWNERS GUIDE. *JD
BC1034397020
ILLUMINATION OF THE CHECK ENGINE LIGHT. *JD
BC1035197020
THE FUEL GAGE MAY SWING ERRATICALLY ON STEEP SLOPES. *JD
BC1035297020
FUEL PUMP SENDER, IN AREAS WITH STEEP SLOPES, THE LOW FUEL WARNING LIGHT MAY PREMATURELY ACTIVATE. *JD
BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD
BC0318972301
FRONT DRIVE AXLE FLUID LEAK. *JD
BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
BC1006597230
IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT. *JD
BC1017397230
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS BROUGHT INTO THE DEALERSHIP WITH CUSTOMER COMPLAINTS CONCERNING PARKING BRAKE. *JD
BC1017697230
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD
BC1017997230
ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
BC1018197230
ENGINEERING IS LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD
BC1022497230
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
BC1025097230
PASSIVE ANTI-THEFT SYSTEM. *JD
BC1025597230
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH GARAGE/CARPORTS. *JD
BC3360972301
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
BC3500972301
LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD
BC3510972301
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD
BC3513972301
AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
BC3522972301
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS. *JD
BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
BC0056970201
SOME EXPEDITIONS MAY EXPERIENCE SOME BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
BC0121970201
DRIVELINE RATTLE OVER BUMPS. *JD
BC0197970201
ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD
BC0254970201
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD
BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD
BC0318970201
FRONT DRIVE AXLE FLUID LEAK. *JD
BC1011097020
OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.
BC1012997020
DRIVELINE RATTLE OVER BUMPS. *JD
BC1014697020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
BC1014797020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
962518
DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW
962523
RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW
BC0325961129
SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW
BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW
962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0474961114
LONG TRAVEL OF PARKING BRAKE PEDAL. *TW
BC0477961114
ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW
BC0009961101
SOFT PARKING BRAKE PEDAL OR LONG PARKING BRAKE PEDAL FEEL. *TW
BC0054961101
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW
BC0065961101
4X4 FRONT AXLE LEAKING THROUGH VENT TUBE. *TW
BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW
BC0600961101
ACCELERATOR CABLE CONTACTING THE POWER STEERING RESERVOIR MAY CAUSING ACCELERATOR PEDAL VIBRATION. *TW
BC0675961025
VEHICLES MAY EXPERIENCE FLUID LEAKS OUT OF THE FRONT AXLE VENT TUBE. *TT
BC0676961025
INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT
BC0683961024
HIGH OR IRREGULAR GAUGE MOVEMENT OR IRREGULAR LOW FUEL LIGHT BELOW 1/4 FULL. *TT
BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96228
WINDNOISE - FRONT WINDOW RUN LIP HANGING OUT - VEHICLES BUILT THROUGH 8/14/96. *TW
BC0743961018
PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON. *TT
BC0745961018
CONCERN OF STARTER STAYING ENGAGED, LOOK AT CHAFED WIRE AT THE REAR BRACKET FOR THE RIGHT FRONT UPPER CONTROL ARM. *TT
BC0753961017
4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT
BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
BC0843961008
INFORMATION ON REPLACING THE COMPASS ASSY FOR ERRATIC/NON-OPERATION. *TT
BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
BC5168961001
PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
BC5177961001
INFORMATION FOR CONCERNS OS SPEEDOMETER, SPEED CONTROL INOP & VSS (VEHICLE SPEED SENSOR) DTC'S. *TT
BC5194961001
REVISED SWITCH BEZEL IS AVAILABLE THAT WILL MINIMIZE CARGO CONTACT W/ THE SWITCH. *TT
BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC5196961001
CONCERN OF STARTER STAYING ENGAGED. RED WIRE THAT RUNS FROM THE STARTER RELAY TO THE STARTER MAY CHAFE & CAUSE STARTER TO STAY ENGAGED AFTER CRANK. *TT
BC5211961001
INFORMATION FOR HIGH OR IRREGULAR FUEL GAUGE MOVEMENT OR IRREGULAR LOW FUEL FUEL LIGHT BELOW 1/4 FULL. *TT
BC9668961001
CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT
BC9671961001
PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT
BC9672961001
PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT
BC9673961001
PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT
BC9674961001
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT
BC9676961001
IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT
BC9680961001
CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT
BC9682961001
CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT
BC9688961001
INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES. *TT
BC9694961001
INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT
BC9695961001
ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.