Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB 24-2188
Service Bulletin/Repair Instructions
This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
SSM 51909
Service Bulletin/Repair Instructions
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
SSM 51536
Service Bulletin/Repair Instructions
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
TSB 22-2219
Service Bulletin/Repair Instructions
Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.
TSB 20-2307
Service Bulletin/Repair Instructions
Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply line.
TSB 20-2233
Service Bulletin/Repair Instructions
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
TSB 19-2026
Service Bulletin/Repair Instructions
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
SSM 47331
Service Bulletin/Repair Instructions
Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
SSM 46542
Service Bulletin/Repair Instructions
When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The updated 'brown' spark plug boots are longer than the black boots to accommodate a running change in the spark plug length. The ignition coil bodies and spring/resistor are transferable and only the rubber boots require replacement. Failure to install the spark plug boots provided with the replacement engine could lead to drivability concerns.
SSM 46085
Service Bulletin/Repair Instructions
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
ASI-44669
Service Bulletin/Repair Instructions
FORD/LINCOLN: THERE WILL BE 2 NEW PIECE RECEIVER DRYER DESICCANT BAG THAT WILL REPLACE 1 PIECE RECEIVER DRY CARTRIDGE, WHICH ARE INTERCHANGABLE, FULLY, DO NOT AFFECT FORM, FIT, OR FUNCTION. MODEL 2011-14 F-SUPER DUTY, 2009-14 F150, 2007-14 EXPEDITION/NAVIGATOR. *PE
TSB-14-0114
Service Bulletin/Repair Instructions
LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
AS-21769
Service Bulletin/Repair Instructions
FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
TSB-10-18-1
Service Bulletin/Repair Instructions
FORD: SOME EXPEDITION/NAVIGATOR/F150 VEHICLES MAY HAVE A DELAYED FORWARD/REVERSE ENGAGEMENT WITH STORED TROUBLE CODES. *RM
TSB-09-19-12
Service Bulletin/Repair Instructions
FORD: SOME HYBRID VEHICLES MAY EXHIBIT AN INTERMITTENT RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE DISPLAYED ON THE MESSAGE CENTER, ACCOMPANIED BY A SUDDEN RPM LOSS/NO START WITH A DIAGNOSTIC TROUBLE CODE (DTC) P1A0C. *PE
TSB-08-19-3
Service Bulletin/Repair Instructions
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
TSB-18-16-14
Service Bulletin/Repair Instructions
FORD: SOME EXPEDITION AND NAVIGATOR VEHICLES MAY EXHIBIT THE MALFUNCTION INDICATOR LIGHT (MIL) ON WITH DTC P0345 AND/OR P0349 WITHOUT ANY DRIVEABILITY SYMPTOMS. *PE
20554
Service Bulletin/Repair Instructions
FORD: VEHICLES WITH ANTI-LOCK BRAKE CONTROL SYSTEM DTC C2777. MAY EXHIBIT AN ANTI-LOCK BRAKE CONTROL SYSTEM (ABS) LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE DTC C2777. PINPOINT TEST G IN WORK SHOP MANUAL SECION 206-09. *PE
TSB-08-9-1
Service Bulletin/Repair Instructions
FORD/LINCOLN: EATC BLOWER INTERMITTENTLY INOPERATIVE-STUCK ON HIGH/OFF. BLOWER MOTOR IS INOPERATIVE NO MATTER WHAT SPEED OR TEMP SETTING OR THE BLOWER MOTOR IS STUCK ON HIGH SPEED OR OFF. *PE
TSB-08-14-2
Service Bulletin/Repair Instructions
FORD/LINCOLN: STABILITY/TRACTION CONTROL INDICATOR; SLIDING CAR ICON: ON OR FLASHING; DTC C1996 OR SENSITIVE ESC/RSC ACTIVATION NO CODES. AFFECT SOME 2007-2008 EXPEDITIONS AND NAVIGATORS. *PE
TSB-08-20-8
Service Bulletin/Repair Instructions
FORD: STEERING WHEEL ANGLE CIRCUIT AND/OR SIGNAL FAILURE-C1277-C1278-BUILT ON OR BEFORE 4/10/08. VEHICLES MAY EXHIBIT A TRACTION CONTROL LIGHT (TCL) ON WITH DIAGNOSTIC TROUBLE CODES. *PE
07256
Service Bulletin/Repair Instructions
ABS LIGHT ON--VEHICLES BUILT BEFORE 2/15/2007. *NJ
SI-20002
Service Bulletin/Repair Instructions
FORD: VARIOUS TRANSMISSION SHIFT QUALITY SYMPTOMS- 6R75 TRANSMISSION- TEMPORARY DO NOT ATTEMPT TO REPAIR. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% SYNCHRONOUS DESIGN OF THE 6R75. *PE
SI-20008
Service Bulletin/Repair Instructions
FORD: WATER LEAKS, WIND NOISE AND/OR NOISE ON OPENING/CLOSING THE MOON ROOF/ROOF OPENING PANEL. THE 2004-07 WSM MANUAL PROVIDES TWO SEPARATE PROCEDURES FOR MOON ROOF HEIGHT A HORIZONTAL ADJUSTMENTS. HEIGHT AND HORIZONTAL PROCEDURES NEED TO DONE TOGETHER. MANUAL PROCEDURES IS IN THE PROCESS OF BEING UPDATED. *PE
SI-20010
Service Bulletin/Repair Instructions
FORD: SOME MULTIPLES VEHICLES REPLACEMENTS MAY REQUIRE REVISED AS BUILT DATA. THE NEW LEVEL SJB SERVICE PART INTRODUCED BETWEEN 10/07 AND 02/08 WILL REQUIRE ENTRY OF AS BUILT DATA. *PE
19843
Service Bulletin/Repair Instructions
2007 EXPEDITION - PCM RUNNING CHANGE *NJ
19778
Service Bulletin/Repair Instructions
BUCK/JERK/HESITATION - LESS THAN 1/4 TANK OF FUEL. *KB
19715
Service Bulletin/Repair Instructions
INSTRUMENT PANEL LIGHTS DIM - SPDJB MUST LEARN RESISTANCE VALUES OF DIMMER. *KB
19615
Service Bulletin/Repair Instructions
REAR WHEEL SPEED SENSOR REPAIR RECOMMENDATION. *KB
0755
Service Bulletin/Repair Instructions
6R75 TRANSMISSION 2 - 3 AND / OR 4 - 5 SHIFT FLARE, POSSIBLE WRENCH LAMP ILLUMINATED WITH DTC P0782 AND / OR P0784. *KB
07811
Service Bulletin/Repair Instructions
HARSH 1-2 AND/OR 2-1 SHIFTS, TIP-IN HESITATION OR SURGE, AND/OR LONG ENGAGEMENT TIME. *KB