030508
Service Bulletin/Repair Instructions
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT
Vehicle report
1997 FORD EXPLORER
Service bulletins
355 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
02138
Service Bulletin/Repair Instructions
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
03181
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
16935
Service Bulletin/Repair Instructions
AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT
0398
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
16735
Service Bulletin/Repair Instructions
VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT
0358
Service Bulletin/Repair Instructions
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB
03261
Service Bulletin/Repair Instructions
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
02221
Service Bulletin/Repair Instructions
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
16385
Service Bulletin/Repair Instructions
AIR RIDE CONTROL LAMP ON AFTER SHOCK ABSORBER REPLACEMENT / CONTACT REQUEST. *TT
870197
Service Bulletin/Repair Instructions
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
16040
Service Bulletin/Repair Instructions
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
15887
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
15910
Service Bulletin/Repair Instructions
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
0282
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
0242
Service Bulletin/Repair Instructions
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
15692
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
0232
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT
0214
Service Bulletin/Repair Instructions
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
15040
Service Bulletin/Repair Instructions
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
15532
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT
15563
Service Bulletin/Repair Instructions
INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01205
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01197
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
01B77
Service Bulletin/Repair Instructions
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
15249
Service Bulletin/Repair Instructions
CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15168
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH
070101
Service Bulletin/Repair Instructions
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM
15006
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
0186
Service Bulletin/Repair Instructions
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
01M01
Service Bulletin/Repair Instructions
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT
14819
Service Bulletin/Repair Instructions
SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
14847
Service Bulletin/Repair Instructions
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
14868
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT
13154
Service Bulletin/Repair Instructions
SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT
13752
Service Bulletin/Repair Instructions
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
13879
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT
00E11
Service Bulletin/Repair Instructions
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
14560
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB
14583
Service Bulletin/Repair Instructions
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB
14617
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB
00M12
Service Bulletin/Repair Instructions
SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT
RCDNN-00V402-817
Service Bulletin/Repair Instructions
This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year Explorer and Mountaineer vehicles. Under certain conditions, predominantly in cold weather areas, a front stabilizer bar link stud can fracture from bending fatigue. Bushing load/deflection testing indicates that the stiffness of the bushing urethane material increases as the temperature is lowered, which could increase the bending fatigue load on the stud from the bushing material.
RCDNN00V4028174
Service Bulletin/Repair Instructions
Letter Pursuant to Part 573 of Title 49 of the Code fof Federal Regulations, Defect and Noncompliance Reports, Ford Motor Company submits the following information concerning a safety-related recall action that it is initiating.
00243
Service Bulletin/Repair Instructions
ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELERATOR PEDAL BRACKET. *TT
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
00213
Service Bulletin/Repair Instructions
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB
00201
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
00M11
Service Bulletin/Repair Instructions
SUBJECT REGARDING ADDITIONAL COVERAGE PROGRAM FOR SWAY BAR LINKS. *JB
00L09
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB
14371
Service Bulletin/Repair Instructions
SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB
0083
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR
981613
Service Bulletin/Repair Instructions
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
981617
Service Bulletin/Repair Instructions
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
98165
Service Bulletin/Repair Instructions
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
14048
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
14056
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
14061
Service Bulletin/Repair Instructions
SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR
8164
Service Bulletin/Repair Instructions
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
8493
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
8512
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
13857
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
8119
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
8149
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
13723
Service Bulletin/Repair Instructions
SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS
13745
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
14265
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT
7918
Service Bulletin/Repair Instructions
FRONT AXLE PINION LIL SEAL LEAKS.
99234
Service Bulletin/Repair Instructions
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
99238
Service Bulletin/Repair Instructions
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
99242
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
13440
Service Bulletin/Repair Instructions
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
13482
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT
13484
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
13504
Service Bulletin/Repair Instructions
CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT
13505
Service Bulletin/Repair Instructions
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
13527
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE VEHICLES. *TT
7353
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
7360
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT
7366
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
7367
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS (PIDS) WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH WHEN VIEWED USING THE NEW GENERATION STAR (NGS) TESTER. *TT
7468
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF.
7471
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
7494
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99223
Service Bulletin/Repair Instructions
A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT
99203
Service Bulletin/Repair Instructions
INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT
99206
Service Bulletin/Repair Instructions
CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT
13300
Service Bulletin/Repair Instructions
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
13388
Service Bulletin/Repair Instructions
VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT
13404
Service Bulletin/Repair Instructions
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
13412
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
13415
Service Bulletin/Repair Instructions
EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT
13424
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI LOCK BRAKES MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH. *TT
13426
Service Bulletin/Repair Instructions
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
7138
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
7270
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
7316
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
99194
Service Bulletin/Repair Instructions
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99185
Service Bulletin/Repair Instructions
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
13170
Service Bulletin/Repair Instructions
INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS
13171
Service Bulletin/Repair Instructions
INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
13172
Service Bulletin/Repair Instructions
INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
13177
Service Bulletin/Repair Instructions
INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
13218
Service Bulletin/Repair Instructions
INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS
13222
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS
13260
Service Bulletin/Repair Instructions
SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT
13261
Service Bulletin/Repair Instructions
SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
6926
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT
6980
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT
6986
Service Bulletin/Repair Instructions
INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT
6987
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT
6993
Service Bulletin/Repair Instructions
SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
7079
Service Bulletin/Repair Instructions
INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS
7083
Service Bulletin/Repair Instructions
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS
13049
Service Bulletin/Repair Instructions
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
13118
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
6896
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
9913035
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
996777
Service Bulletin/Repair Instructions
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT
99142
Service Bulletin/Repair Instructions
VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT
6574
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
6603
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
6640
Service Bulletin/Repair Instructions
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
Service Bulletin/Repair Instructions
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
991210
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
060199
Service Bulletin/Repair Instructions
CUSTOMER MAY COMPLAIN OF AN INTERMITTENT STUMBLE / BUCK / JERK AT 38 MPH WHILE IN HIGH GEAR AND AT VERY LIGHT THROTTLE APPLICATION. *TT
12852
Service Bulletin/Repair Instructions
USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
12905
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
6429
Service Bulletin/Repair Instructions
INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
98R03
Service Bulletin/Repair Instructions
SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT
99104
Service Bulletin/Repair Instructions
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. *TT
9987
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT
9996
Service Bulletin/Repair Instructions
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
9988
Service Bulletin/Repair Instructions
CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT
12710
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
6203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
995157
Service Bulletin/Repair Instructions
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
99S09
Service Bulletin/Repair Instructions
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
9943
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
9946
Service Bulletin/Repair Instructions
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
12512
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T
12518
Service Bulletin/Repair Instructions
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT
12529
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
12571
Service Bulletin/Repair Instructions
EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT
12624
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT
5652
Service Bulletin/Repair Instructions
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT
5814
Service Bulletin/Repair Instructions
SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT
5852
Service Bulletin/Repair Instructions
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
982511
Service Bulletin/Repair Instructions
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
982515
Service Bulletin/Repair Instructions
CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC
98259
Service Bulletin/Repair Instructions
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
12227
Service Bulletin/Repair Instructions
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12230
Service Bulletin/Repair Instructions
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
12298
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
5128
Service Bulletin/Repair Instructions
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
5203
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
5249
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
5256
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT
5272
Service Bulletin/Repair Instructions
BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
982312
Service Bulletin/Repair Instructions
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
982320
Service Bulletin/Repair Instructions
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
982323
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
98234
Service Bulletin/Repair Instructions
AIR INTAKE TUBE CONTACTING HOOD INSULATOR CAUSING INSULATOR WEAR. *YC
98238
Service Bulletin/Repair Instructions
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
12115
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE TIRE INFLATION PRESSURE FOR ALL MODELS DURING PREDELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *MJS
12150
Service Bulletin/Repair Instructions
INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS
12154
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
12174
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
5049
Service Bulletin/Repair Instructions
BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT
982122
Service Bulletin/Repair Instructions
SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES. *YC
985045
Service Bulletin/Repair Instructions
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
985064
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING ENGINE STALLING *TT
985128
Service Bulletin/Repair Instructions
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
985144
Service Bulletin/Repair Instructions
ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. *TT
985157
Service Bulletin/Repair Instructions
INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT
98211
Service Bulletin/Repair Instructions
EXPERIENCING A NOISE AND VIBRATION DURING IDLE.
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
982019
Service Bulletin/Repair Instructions
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
98-4732
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
98-4817
Service Bulletin/Repair Instructions
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
98163
Service Bulletin/Repair Instructions
LOCKS FAILED. YD
981512
Service Bulletin/Repair Instructions
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
981514
Service Bulletin/Repair Instructions
A VEHICLE VIBRATES DURING A HOT OR COLD IDLE CONDITION.
11759
Service Bulletin/Repair Instructions
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
11811
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
4619
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
4623
Service Bulletin/Repair Instructions
BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT
4634
Service Bulletin/Repair Instructions
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
4642
Service Bulletin/Repair Instructions
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
4703
Service Bulletin/Repair Instructions
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
98021698311
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9889
Service Bulletin/Repair Instructions
SOME CUSTOMERS NOTICE A GRINDING, WHINING, PULSING, OR FLUTTERING AT THE BRAKE PEDAL AT SPEEDS BELOW 19 KM/H (12 MPH). *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
9873
Service Bulletin/Repair Instructions
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
11512
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT
980313
Service Bulletin/Repair Instructions
EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC
980318
Service Bulletin/Repair Instructions
CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC
980319
Service Bulletin/Repair Instructions
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC
982540
Service Bulletin/Repair Instructions
CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A5
Service Bulletin/Repair Instructions
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
98514
Service Bulletin/Repair Instructions
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983074
Service Bulletin/Repair Instructions
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
983109
Service Bulletin/Repair Instructions
INFORMATION REGARDING ENGINES ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
9831
Service Bulletin/Repair Instructions
REPAIRS TO VINYL COVERED SURFACES. *YC
9833
Service Bulletin/Repair Instructions
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
98112
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
98113
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
98117
Service Bulletin/Repair Instructions
SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT
98118
Service Bulletin/Repair Instructions
EXPERIENCING AN AUDIBLE NOISE IN ENGINE.
98124
Service Bulletin/Repair Instructions
SUBJECT REGARDING AN OVERHEATING CONDITION OCCURRING TO THE LAMP OUTAGE MODULE (LOM-2) WITH THE INSTALLATION OF CERTAIN AFTERMARKET TRAILER KITS THAT IMPROPERLY CONNECT TO THE TAIL AND BRAKE LAMPS CIRCUITS. *TT
98126
Service Bulletin/Repair Instructions
SUBJECT REGARDING LAMP OUTAGE MODULE HOUSING AND SURROUNDING PLASTIC COMPONENTS MELTED - EDDIE BAUER AND LIMITED EDITION MODELS EQUIPPED WITH MESSAGE CENTERS AND IMPROPERLY CONNECTED TOW WIRING KITS (VEHICLES BEING TOWED). *TT
9814
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
090308
Service Bulletin/Repair Instructions
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
980324
Service Bulletin/Repair Instructions
COLD ENGINE UPPER KNOCK/TICK. *AK
983092
Service Bulletin/Repair Instructions
REAR CRANKSHAFT SEAL OIL LEAK. *AK
971110972312
Service Bulletin/Repair Instructions
CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC
976011
Service Bulletin/Repair Instructions
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
97090297183
Service Bulletin/Repair Instructions
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
97090297189
Service Bulletin/Repair Instructions
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
97050110611
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK. *TW
97050110613
Service Bulletin/Repair Instructions
WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW
97050110634
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING CONCERNS OF BROKEN LIFTGATE GLASS. *YC
BC105609705
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 AUTO MODE. *TW
BC105789705
Service Bulletin/Repair Instructions
VEHICLES WITH DTC P0402 IN MEMORY ARE UNDER INVESTIGATION BY ENGINEERING DEPARTMENT. *TW
BC105829705
Service Bulletin/Repair Instructions
SOME RUNNING BOARD PADS MAY BE WARPED. *TW
BC105979705
Service Bulletin/Repair Instructions
UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
BC106049705
Service Bulletin/Repair Instructions
VEHICLES BUILT AFTER 4/14/97 NO LONGER HAVE A REAR WASHER BOTTLE - REDESIGNED FRONT WASHER BOTTLE WILL SERVICE THE FRONT AND REAR WASHERS. *TW
BC2236970501
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK OR RATTLE. *TW
BC2237970501
Service Bulletin/Repair Instructions
RECALL 97S67 - MODIFICATION OF THE PCV VALVE REQUIRES A SPECIAL TOOL WHICL WILL SENT TO LISTED PARTS MANAGERS. *TW
BC2246970501
Service Bulletin/Repair Instructions
VEHICLES BUILT ON OR AFTER 4/14/97 WILL NO LONGER HAVE A REAR WASHER BOTTLE - A REDESIGNED FRONT WASHER BOTTLE WILL SUPPLY THE FLUID TO BOTH WASHERS. *TW
BC2301970501
Service Bulletin/Repair Instructions
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
BC2302970501
Service Bulletin/Repair Instructions
DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW
BC2306970501
Service Bulletin/Repair Instructions
SOME RUNNING BOARD PADS MAY WARPED. *TW
BC2313970501
Service Bulletin/Repair Instructions
MAY 1997 GEM SOFTWARE HAS ERRORS - JUNE SOFTWARE IS CORRECT. *TW
BC2383970501
Service Bulletin/Repair Instructions
SERVICE FIX FOR VEHICLES WHICH EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 MODE.
BC2384970501
Service Bulletin/Repair Instructions
LIFTGATE LOCK CONCERNS ON VEHICLES BUILT THROUGH 12/96. *TW
BC2440970501
Service Bulletin/Repair Instructions
1997 4.0L SOHC 4X4 EXPLORERS AND 1997 5.0L AWD EXPLORERS/MOUNTAINEERS SHOULD NOT BE EQUIPPED WITH A VIBRATION DAMPER ON THE TRANSFER CASE. *TW
BC2442970501
Service Bulletin/Repair Instructions
LIFTGATE LOCKS WILL NOT LOCK/UNLOCK WHEN ACTUATED BY THE POWER SWITCHES. *TW
BC3092970501
Service Bulletin/Repair Instructions
ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW
9776
Service Bulletin/Repair Instructions
IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L SOHC ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
9751
Service Bulletin/Repair Instructions
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
97511
Service Bulletin/Repair Instructions
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
97513
Service Bulletin/Repair Instructions
IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD
97514
Service Bulletin/Repair Instructions
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD
9755
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD
96E57
Service Bulletin/Repair Instructions
EMISSIONS RECALL 96E57 - CERTAIN 1996 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT ON 11/18/95 AND CERTAIN 1997 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT FROM START OF 1997 PRODUCTION THROUGH 8/14/96 WERE BUILT AND SHIPPED WITH INCORRECT VAPOR MANAGEMENT VALVES INSTALLED IN THE EVAPORATIVE EMISSIONS CONTROL SYSTEM - INCORRECT VALVES MAY CAUSE THE VEHICLES TO EXCEED EVAPORATIVE EMISSIONS STANDARDS - TO CORRECT THIS CONDITION, OWNERS WILL BE NOTIFIED TO RETURN THEIR EXPLORERS FOR REPLACEMENT OF THE VAPOR MANAGEMENT VALVE. *TW
BC3092970225
Service Bulletin/Repair Instructions
REAR CRANKSHAFT SEAL OIL LEAKS. *TW
BC3132970221
Service Bulletin/Repair Instructions
INCORRECT OIL VISCOSITY LABEL IN ENGINE COMPARTMENT. *TW
BC3134970221
Service Bulletin/Repair Instructions
OEM SPARK PLUGS MAY EXHIBIT A CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *TW
BC3155970219
Service Bulletin/Repair Instructions
4.0L SHOC ENGINE QUITS WHILE DRIVING AND WILL NOT RESTART. *TW
BC3156970219
Service Bulletin/Repair Instructions
EXPLORERS EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP IN. *TW
9747
Service Bulletin/Repair Instructions
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
BC3274970207
Service Bulletin/Repair Instructions
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS AND CAN RESULT IN ACTUATION OF THE SHOR CIRCUIT PROTECTION FEATURE. *TW
BC3282970206
Service Bulletin/Repair Instructions
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
BC3283970206
Service Bulletin/Repair Instructions
DOOR LATCH SWITCH IS CAUSING THE DOOR AJAR LIGHT/CHIME NOT TO WORK PROPERLY. *TW
97312
Service Bulletin/Repair Instructions
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD
97314
Service Bulletin/Repair Instructions
TRANSFER CASE- BINDING OR SHUDDER- DIAGNOSTICS- VEHICLES WITH 4.0L ENGINE- SERVICE TIP. *JD
9735
Service Bulletin/Repair Instructions
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
9738
Service Bulletin/Repair Instructions
REMOTE KEYLESS ENTRY- RKE INOPERATIVE- VEHICLES BUILT THROUGH 10/30/96. *JD
BC0317A97020
Service Bulletin/Repair Instructions
DRIVELINE WIND-UP IN 4-AUTO MODE. *TW
BC1028397020
Service Bulletin/Repair Instructions
THE 1997 EXPLORER 4.0L SOHC IS THE ONLY VEHICLE EQUIPPED WITH A NEW STYLE (BLACK PLASTIC) DPFE SENSOR. *JD
BC1030297020
Service Bulletin/Repair Instructions
ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP-IN FROM THE THROTTLE BODY/IAC AREA OF THE ENGINE. *JD
BC1031297020
Service Bulletin/Repair Instructions
SOME VEHICLE ENGINE COMPARTMENT DECALS MAY INCORRECTLY LIST 10W30 FOR OIL VISCOSITY. *JD
BC1033197020
Service Bulletin/Repair Instructions
VEHICLES WITH REAR CRANKSHAFT SEAL OIL LEAKS. *JD
BC1035497020
Service Bulletin/Repair Instructions
4.0L SOHC ENGINE COMES FROM THE FACTORY WITH SINGLE PLATINUM PLUGS. *JD
BC1035597020
Service Bulletin/Repair Instructions
RADIATORS MAY EXHIBIT A COOLANT LEAK AT THE END TANK SEALS IN COLD TEMPERATURES. *JD
BC0012972301
Service Bulletin/Repair Instructions
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. *JD
BC0050972301
Service Bulletin/Repair Instructions
WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON A VEHICLE PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
BC0317972301
Service Bulletin/Repair Instructions
DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD
BC1018997230
Service Bulletin/Repair Instructions
BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
BC1019197230
Service Bulletin/Repair Instructions
EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
BC1019297230
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM. *JD
BC1019497230
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT REVERSE OPERATING CHARACTERISTICS WHEN SWITCHING THE AIR SUSPENSION SWITCH FROM NORMAL TO OFF ROAD. *JD
BC1019597230
Service Bulletin/Repair Instructions
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT A TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD
BC1019797230
Service Bulletin/Repair Instructions
THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD
BC1019897230
Service Bulletin/Repair Instructions
PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE.
BC1019997230
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC1022797230
Service Bulletin/Repair Instructions
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
BC1024097230
Service Bulletin/Repair Instructions
INCREASED THROTTLE EFFORTS MAY BE NOTED ON SOME 4.0L SOHC EQUIPPED VEHICLES DUE TO THROTTLE PLATE ALIGNMENT. *JD
BC1025297230
Service Bulletin/Repair Instructions
FRONT AXLE VENT LEAKS ON 1997 EXSPLORERS BUILT BEFORE 11/1/06. *JD
BC3363972301
Service Bulletin/Repair Instructions
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
BC3441972301
Service Bulletin/Repair Instructions
AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD
BC3481972301
Service Bulletin/Repair Instructions
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT AT TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD
BC3483972301
Service Bulletin/Repair Instructions
THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD
BC3484972301
Service Bulletin/Repair Instructions
WHEN PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. *JD
BC3485972301
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC3491972301
Service Bulletin/Repair Instructions
SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
BC3493972301
Service Bulletin/Repair Instructions
VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
BC3494972301
Service Bulletin/Repair Instructions
VARIOUS VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM- TO FIX, REMOVE EXISTING MUFFLER AND REPLACE WITH SAME PART. *JD
97116
Service Bulletin/Repair Instructions
TRANSFER CASE- WATER INGESTION THROUGH VENT TUBE. *JD
BC0012970201
Service Bulletin/Repair Instructions
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD
BC0050970201
Service Bulletin/Repair Instructions
WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON THE ABOVE VEHICLES PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
BC0133970201
Service Bulletin/Repair Instructions
REVISED VENT TUBE FOR 1995-97 EXPLORERS & MOUNTAINEERS WITH WATER INGESTION INTO TRANSFER CASE. *JD
BC0184970201
Service Bulletin/Repair Instructions
PROCEDURE TO PURGE POTENTIAL WATER CONTAMINATION FROM TRANSFER CASE. *JD
BC0190970201
Service Bulletin/Repair Instructions
VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEMP GAUGE SYSTEM PARTS. *JD
BC0206970201
Service Bulletin/Repair Instructions
TRANSFER CASE BIND OR SHUDDER. *JD
BC0225970201
Service Bulletin/Repair Instructions
BINDING/AXLE WIND-UP AT LOW SPEED. *JD
BC0257970201
Service Bulletin/Repair Instructions
POWER LOCKS CYCLE BY THEMSELVES REMOVE EACH POWER LOCK SWITCH AND MEASURE THE OPEN RESISTANCE. *JD
BC0317970201
Service Bulletin/Repair Instructions
DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD
BC0324970201
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *JD
BC1011297020
Service Bulletin/Repair Instructions
4.0L OHV/SOHC 4X4 EXPLORERS WITH TRANSFER CASE BIND OR SHUDDER. *JD
BC1012797020
Service Bulletin/Repair Instructions
REVISED VENT TUBE FOR VEHICLES WITH WATER INGESTION INTO TRANSFER CASE. *JD
BC1015097020
Service Bulletin/Repair Instructions
LAMP OUTAGE MODULE (LOM) ON THE VEHICLES- PLEASE VERIFY IF THE VEHICLE HAS: 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
BC1016497020
Service Bulletin/Repair Instructions
INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD
962612
Service Bulletin/Repair Instructions
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962511
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
BC0342961127
Service Bulletin/Repair Instructions
WHEN A REAR HEGO (CMS) CONCERN IS NOTED, PLEASE CHECK THE REAR CMS HEGO FOR WIRE CHAFING/DAMAGE AND LOOSE HEGO WIRE. *TW
962410
Service Bulletin/Repair Instructions
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
Service Bulletin/Repair Instructions
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0481961113
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW
BC0533961108
Service Bulletin/Repair Instructions
INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW
BC0534961108
Service Bulletin/Repair Instructions
DRIVESHAFT DESIGN MAY CAUSE FLOORPAN VIBRATION WHILE AT HIGHWAY SPEEDS OR WITH THROTTLE WIDE OPEN. *TW
BC0069961101
Service Bulletin/Repair Instructions
CONCERN OF BINDING/AXLE WIND-UP AT LOW SPEED. *TW
BC0324961101
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *TW
BC5231961101
Service Bulletin/Repair Instructions
VEHICLE LEAN. *TW
BC5238961101
Service Bulletin/Repair Instructions
VEHICLE MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW
96221
Service Bulletin/Repair Instructions
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
96222
Service Bulletin/Repair Instructions
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96225
Service Bulletin/Repair Instructions
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96226
Service Bulletin/Repair Instructions
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0744961018
Service Bulletin/Repair Instructions
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC0755961017
Service Bulletin/Repair Instructions
TENSIONER RATTLE . INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT
BC0881961004
Service Bulletin/Repair Instructions
THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT
BC0882961004
Service Bulletin/Repair Instructions
INFORMATION FOR ALL BASE ENGINE CONCERNS OF 4.0L SOHC ENGINES. *TT
BC5180961001
Service Bulletin/Repair Instructions
OWNERS GUIDE ADVISES TO USE A FL-1A OIL FILTER, FL-1A IS INCORRECT. THE CORRECT FILTER IS FL-820. *TT
BC5188961001
Service Bulletin/Repair Instructions
CONCERN OF A TENSIONER RATTLE W/ 4.0L SOHC, INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT
BC5195961001
Service Bulletin/Repair Instructions
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC5197961001
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
BC5225961001
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.