Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
DOR-N3Z7B-03
This SKU is an Oil Dipstick. The customer communication requested return of unsold inventory to inspect the dipstick tube. The dipstick tube inner diameter may be small enough that it prevents installation of the OE dipstick.
16-0073
For 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250 Light Duty, or 2002-2003 Blackwood vehicles Safety Recall 11S21 has been issued for vehicles that are operated in high corrosion areas for an extended period, where one or both fuel tank straps could potentially fracture. Strap fracture may result in the fuel tank contacting the ground. If the fuel tank contacts the ground and develops a leak while driving, there is a potential for fire.
TSB160073
Safety recall 11S21 - Fuel tank strap fracture - requests for recall service action
TSB-14-0164
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE, 2002-03 BLACKWOOD. *PE
TSB-14-0147
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKWOOD. *PE
CSP-08B01
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. *PE
20228
1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
042421
SAFETY BELT RETRACTION SPEED. *TT
05618
REAR AXLE NOISE REPAIR. *TT
020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
18466
AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH
04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
050618
REAR AXLE NOISE REPAIR. *SC
04251
ALUMINUM CORROSION - SERVICE TIP. *TT
042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
18217
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT
18250
INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT
04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
0483
SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS. SERVICE PROCEDURE. *TT
17777
REAR LEAF SPRING NOISE. *TT
17823
POWER STEERING LEAK - SERVICE TIP. *TT
17731
WHINE FROM POWER STEERING. *TT
0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
17655
EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM. *TT
0422
WINDNOISE AND/OR A WATER LEAK FROM THE SLIDING BACK GLASS AREA. *TT
0416
DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING. *TT
99263
CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP. *TT
17316
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT
17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, PLUGGED CATALYTIC CONVERTER AND NO START CONDITION. *TT
03207
A VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED 32 KM/H (20 MPH). *TT
03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
031513
TIE ROD END INSPECTION PROCEDURE. *TT
17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
17063
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171, OR P0174. F150 LIGHTING AND F150 HARLEY DAVIDSON SUPERCREW. *TT
03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
16969
DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT
16928
VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES. *TT
03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
03910
VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED (20 MPH, 32 KM/H). *TT
0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
0399
TIE ROD END INSPECTION PROCEDURE. *TT
16835
TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT
03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
0324
DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT
030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
16602
LOCKING TAILGATE LOCKS ITSELF. *TT
16605
REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT
0258
INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT
02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
02227
ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ
16416
NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED. *MJ
870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
16172
SOME VEHICLES WITH 4-WHEEL DISC BRAKES MAY EXHIBIT A MOAN FROM THE REAR BRAKES ON LIGHT BRAKE APPLICATIONS. *TT
16019
SOME LIGHTNING AND HARLEY DAVIDSON SUPERCREWS MAY EXHIBIT CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0171 OR P0174. *TT
16033
SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING. *TT
02121
WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED. *TT
02105
SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
02108
SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT
15913
SOME VEHICLES EQUIPPED WITH 5.4L V8 ENGINE MAY EXHIBIT AIR INDUCTION SYSTEM CONDITIONS AS WELL AS ENGINE HESITATION / SURGE AND / OR A MALFUNCTION INDICATOR LAMP ILLUMINATED. *TT
15932
SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION. *TT
0271
SOME VEHICLES BUILT AT THE CUAUTITLAN ASSEMBLY PLANT EQUIPPED WITH THE 4.2L ENGINE AND AUTOMATIC TRANSMISSION, MAY EXHIBIT A VIBRATION CONDITION WHEN THE ENGINE IS AT IDLE IN DRIVE AND / OR REVERSE WITH THE AIR CONDITIONER TURNED ON. *TT
15793
SOME VEHICLES MAY EXHIBIT A SLIGHT OIL LEAK AT THE CYLINDER HEAD TO BLOCK JOINT. *TT
15817
SOME VEHICLES EQUIPPED WITH BI-FUEL (CNG/LPG) ALTERNATE FUEL ENGINES MAY EXHIBIT HARD / NO START, RUNS ROUGH OR MISSES AFTER STARTING, AND OR HESITATION ON ACCELERATION WHEN OPERATED IN THE BI-FUEL MODE. *TT
0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
0241
SUBJECT REGARDING IDLER ARM REPLACEMENT SPECIFICATIONS. *TT
0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
02E17
SUBJECT REGARDING HEATER HOSE TO FUEL RAIL FLEX LINE INSPECTION. *JG
15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
15707
INFORMATION ON VEHICLE EXHIBITING EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM. *TT
15711
SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR. *TT
15742
INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT
15758
SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT
15645
SOME VEHICLES MAY EXHIBIT A CRANK NO START CONDITION WHILE OPERATING IN BI-FUEL MODE, VEHICLE WILL START ON GASOLINE. *TT
0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
15570
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
01253
CONCERNS WITH WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED. *TT
01255
SOME LIGHTNING MODEL VEHICLES MAY EXHIBIT A REDUCED POWER ASSIST AFTER THE FIRST TWO OR THREE BRAKE APPLICATIONS DURING OPERATING IN FREEZING AMBIENT TEMPERATURES. *TT
01243
SOME BI-FUEL EQUIPPED VEHICLES MAY EXHIBIT REDUCED ENGINE POWER, RPM DIP OR IDLE SURGE GREATER THAN 200 RPM IMMEDIATELY FOLLOWING TIP-IN FROM A STOP OPERATING IN ALTERNATIVE FUEL MODE. *TT
01244
SOME CNG BI-FUEL VEHICLES MAY EXHIBIT A NO START, LONG CRANK, HESITATION OR REDUCED ENGINE POWER WHILE OPERATING IN BI-FUEL MODE ONLY. *TT
01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01E15
FIELD ACTION TO REPLACE THE HEATED EXHAUST GAS OXYGEN (HEGO) SENSOR. *TT
01E16
EMISSIONS RECALL 01E16 TO REPLACE INCORRECT HEGO SENSOR, THE INCORRECT HEGO SENSOR MAY CAUSE APPLICABLE EXHAUST EMISSIONS STANDARDS TO BE EXCEEDED DUE TO THE POTENTIAL FOR INCORRECT FUEL/AIR RATIOS. *TT
15502
CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS. *TT
01231
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
15431
EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES. *TT
012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT
01214
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
01218
SOME VEHICLES MAY EXHIBIT A NO CRANK, NO START CONDITION DUE TO CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID. *TT
01201
SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THORUGH 1/24/2000. *TT
01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
01208
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE, 4R70W TRANSMISSION AND 3.31 OR 3.55 AXLE RATIO MAY EXHIBIT AN INTERMITTENT HARSH 1-2 SHIFT DURING LIGHT THROTTLE OR PARKING LOT MANEUVERS. *TT
01192
SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE. *TT
01194
THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT
01B83
SUBJECT REGARDING CUSTOMER SATISFACTION PROGRAM, VEHICLES WITH HEAVY DUTY ELECTRICAL/COOLING GROUP, PUBLICATIONS ERROR. *SLC
15299
SOME VEHICLES MAY EXHIBIT CORROSION AT THE ATTACHMENT POINT OF THE STARTER CABLE B+ TERMINAL, AT THE STARTER SOLENOID. *TT
01181
BRAKE SHIFT INTERLOCK.*JB
01182
SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB
010901
CERTAIN 1999 AND 2000 MODEL YEAR F150 LIGHTNING VEHICLES - INTERCOOLER REPLACEMENT. *NLM
15219
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE ALL THE GUAGES INTHE INSTRUMENT CLUSTER WILL SWEEP AT INITIAL START UP. *TT
15259
CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES. *TT
15260
CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT
15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
01151
SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND M5OD 5 SPEED MANUAL TRANSMISSIONS MAY EXHIBIT HESITATION ON ACCELERATION AND A CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES 90172 AND 90175. *SLC
01165
SOME VEHICLES MAY EXHIBIT NO START, LONG CRANK, OR STALL WHILE OPERATING IN BI-FUEL MODE, VEHICLES WITH 5.4L CNG BI-FUEL ENGINE ONLY. *SLC
01153
SOME VEHICLES EQUIPPED WITH BI-FUEL 5.4 L ENGINES MAY EXHIBIT A STALL, RPM DIP, OR IDLE SURGE GREATER THAN 200 RPM IMMEDIATELY FOLLOWING TIP-IN FROM A STOP, OPERATING IN ALTERNATIVE FUEL MODE. *SLC
01155
SOME VEHICLES, BI FUEL, MAY EXHIBIT A NO START CONDITION IN BOTH THE GASOLINE MODE AND THE ALT FUEL MODE, VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI FUEL ENGINES ONLY. *SLC
01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
15145
SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS OR IS SLAMMED SHUT. *ET
15164
SOME VEHICLES MAY EXHIBIT A LOSS OF COOLANT FROM THE CHARGE AIR COOLER RESERVOIR. *YH
15187
SOME VEHICLES MAY EXHIBIT A LOOSE/DETACHED REAR WINDOW HALO GIMP MOLDING. *ET
01141
SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR VEHICLE STUCK IN 4L AFTER UNCOMMANDED SHIFT. *TT
01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
01137
SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT. *TT
15068
VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN ACCELERATION AND A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODES P0172 AND P0175. *TT
15101
SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE A 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN ACCELERATION AND A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0172 AND P0175. *TT
011112
SOME FLARESIDE AND SUPER CREW MODELS MAY EXHIBIT WATER AND DIRT WHICH CAN MIGRATE INTO THE TAIL LAMP LENS THROUGH THE LENS VENT HOLE. *TT
14990
CONCERNS THAT SOME TRUCKS MAY EXHIBIT A LOOSE / DETACHED REAR WINDOW HALO TRIM GIMP MOULDING. *TT
15022
CONCERNS THAT THE ANTI-LOCK BRAKE SYSTEM (ABS) LAMP IS ON WITH DIAGNOSTIC TROUBLE CODES C1230, C1229, OR C1237. *TT
0193
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE TO EXCESS DRIVESHAFT FLEXING DURING EXTENDED HIGH SPEED OPERATION. *TT
14880
SOME VEHICLES EQUIPPED WITH 5.4L ENGINE MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE (DTC) P0300 IN MEMORY. *TT
14907
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT
14918
THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS REQUIRED DURING POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER (VIC / HEC / ICM) REPLACEMENT. *TT
14942
SOME VEHILCES EQUIPPED WITH 4.6L ROMEO ENGINE AND MANUAL TRANSMISSION ONLY, MAY EXHIBIT A CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE COE P0172 / P0175 STORED IN MEMORY WITH POSSIBLE DRIVEABLTILITY CONDITIONS SUCH AS HESITATION / STUMBLE. *TT
0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
0165
SOME VEHICLES WHEN DRIVING IN THE ALTERNATIVE FUEL MODE MAY EXHIBIT A HARD START, NO START OR START THEN IMMEDIATE STALL, HESITATION OR SURGE AT IDLE, WITH FUEL SELECTOR SWITCH LAMP ON IN BI-FUEL MODE. *TT
0158
SOME VEHICLES EQUIPPED WITH THE 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICKING OR CLICKING TYPE NOISE IN FIRST GEAR. *TT
0142
SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE. *TT
0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
14453
SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION WERE BUILT WITH AND WITHOUT THE #8 THRUST WASHER. *TT
13737
INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR P1639 AFTER A POWERTRAIN CONTROL MODULE (PCM) HAS BEEN REPLACED. *TT
0125
SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS. *TT
0116
SOME VEHICLES MAY PRODUCE A MALFUNCTION INDICATOR LAMP ILLUMINATED, ROUGH IDLE, A CHECK ENGINE LIGHT, AND DIAGNOSTIC TROUBLE CODES (DTCS) P0350 - P0360 STORED IN MEMORY. *TT
14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
00258
SOME VEHICLES MAY EXHIBIT A CLUNKING SOUND ON SOME SVT LIGHTNING VEHCLES DURING PARKING MANEUVERS. *TT
002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
00232
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION OR BUCK WHILE DRIVING IN ANY FUEL MODE (LPG, CNG OR GASOLINE). *TT
00238
SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
00L07
THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB
00192
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS, RADIO AND REAR WIPER IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. *JB
00183
CONCERNS WITH THE INTAKE MANIFOLD LEAKING OR WEEPING COOLANT FROM PASSENGER SIDE GASKET AT RIGHT REAR CORNER OF HEAD-TO-MANIFOLD JOINT. *JB
14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
00142
INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. *JB
14189
CONCERNS WITH SQUEAKING NOISE FROM TIE ROD END. *TT
14191
SOME VEHICLES EQUIPPED WITH A MANUAL TRANSFER CASE MAY EXHBIT AN INOPERATIVE SPEEDOMETER. *TT
14207
CONCERNS WITH THE PREMIUM SOUND SYSTEM CUTTING OUT WHILE DRIVING. *TT
0084
CONCERNS WITH A CHATTERING NOISE FROM THE REAR AXLE HEARD WHEN TURNING OR CORNERNING. **MR
0087
CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL INOPERATIVE IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. *MR
14086
EXHIBITING A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER. *TT
8021
EXHIBITING A CRACKLING / POPPING NOISE FROM THE EXHAUST. **MR
8464
INFORMATION REGARDING ERRACTIC REMOTE ENTRY FUNCTIONS-NEW GEM RELEASED. **MR
8582
SOME VEHICLES MAY EXHIBIT A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER. **MR
00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
13972
SUBJECT REGARDING RUNNING CHANGES FOR VEHICLE QUIETNESS. *TT
14031
CONCERNS WITH ERRATIC REMOTE ENTRY FUNCTIONS. *TT
8329
SUBJECT REGARDING RUNNING CHANGES FOR VEHICLE QUIETNESS. *TT
0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
7816
SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING. *TT
8077
SOME VEHICLES MAY EXHIBIT ANY OF P0350 THROUGH P0358 COIL DIAGNOSTIC TROUBLE CODES, CHECK ENGINE LIGHT ON AND ROUGH IDLE UNDER COLD START CONDITIONS. *TT
8163
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. A ONE-TIME NOISE FROM THE ENGINE MAY BE HEARD, FOLLOWED BY ROUGH RUNNING / MISSES, NO START, LACKS POWER AND A CHECK ENGINE LIGHT (MISFIRE DIAGNOSTIC TROUBLE CODES). *TT
8190
SOME VEHICLES MAY EXHIBIT ANY OF P0350 - P0358 COIL (DIAGNOSTIC TROUBLE CODES), CHECK ENGINE LIGHT, AND ROUGH IDLE. *TT
0014
VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS
0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
13713
VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT DIAGNOSTIC TROUBLE CODE (DTC) PO451. *MJS
13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
13806
SOME VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99 MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST. *MJS
14029
EXHIBITING A POPPING NOISE FROM THE LOWER CONTROL ARM. *TT
14417
SOME LIGHTNING MODELS MAY EXHIBIT A CLUNKING SOUND FROM THE FRONT END AREA DURING PARKING MANEUVERS. *TT
7898
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT DIAGNOSTIC TROULE CODE (DTC) P0451 (EVAPORATIVE EMISSIONS CONTROL SYSTEM PRESSURE SENSOR RANGE/PERFORMANCE).
99243
ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION. *TT
99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
13546
ENGINEERING IS CURRENTLY INVESTIGATING A CONDITION WHERE POPPING / CRACKING SOUNDS CAN BE HEARD FROM THE CATALYTIC CONVERTER DURING HIGHER AMBIENT TEMPERATURES. *TT
13576
INFORMATION ON REVISED WHEEL STUD AND NUT DIAMETERS. *TT
992111
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED 4T100 TRANSMISSIONS. *TT
99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99224
SUBJECT REGARDING FRONT WIPERS OPERATING WHILE SWITCH IS IN OFF POSITION. *TT
13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
13253
(CONTINUED FROM 13251 AND 13252) UNCOMMANDED FRONT WIPER FUNCTION. *MJS
6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
13099
BRIEF INFORMATION REGARDING THE DISCONTINUED TOOL BOX. *TT
13100
SUBJECT REGARDING DISCONTINUE OF THE ENGINE COMPARTMENT BEAUTY SHIELD. *TT
13108
SOME VEHICLES MAY EXHIBIT A FLICKER IN THE DASH LAMPS WHEN SWITCHING FROM THE HEADLAMP TO THE PARK LAMP POSITION. *TT
9913072
VEHICLES MAY EXHIBIT AN OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHT FLUTTER / SHAKE AT HIGHWAY SPEEDS. *TT
996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
996804
CONCERNS WITH OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHTLY FULTTERING / SHAKING AT HIGHWAY SPEEDS. *TT
996870
THIS ONLINE SERVICE BULLETIN MENTIONS THAT LATE BUILT REGULAR CABS WILL NOT OFFER A TOOL BOX TRAY LOCATED BEHIND THE SEAT, THE TOOL BOX TRAY IS DISCONTINUED AND IS NO LONGER AVAILABLE AS AN OPTION. *TT
996871
VEHICLES BUILT AFTER 7/31/99 WILL NO LONGER BE EQUIPPED WITH A SHIELD COVERING THE STARTER RELAY AND C120 / C172 ELECTRICAL CONNECTORS LOCATED ON THE PASSENGER SIDE OF THE ENGINE COMPARTMENT. *TT
996881
CONCERNS WITH VEHICLES EXHIBITING A FLICKER IN THE DASH LAMP WHEN SWITCHING FROM THE HEADLAMP TO THE PARK LAMP POSITION. *TT
99B19
OWNER NOTIFICATION PROGRAM FOR HEADLAMP SWITCH REPLACEMENT. *TT
991412
SERVICE PROCEDURE FOR GREEN SERVICE TAGGED 4R70W TRANSMISSIONS. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.