25E09
Emissions
NEW VEHICLE DEMONSTRATION / DELIVERY HOLD Emissions Recall 25E09 Certain 2022 Model Year F-250 - F-600 Vehicles with 6.7L Engines Powertrain Control Module Programming and Particulate Matter Sensor Installation
Vehicle report
2002 FORD F-350 SD
Service bulletins
42 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
24L05
Other
Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles
DOR-C2C6H-02
Service Bulletin/Repair Instructions
This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
DOR-U2J7Y-02
Service Bulletin/Repair Instructions
This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
SSM 48157
Service Bulletin/Repair Instructions
Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the upper left corner. Select the utility knife in the bottom left corner. Select Update/Special Function and enter 53061 in the blue box then press the tick mark. The screen will go back to the system utilities page. Navigate to the toolbox tab and run the Programmable Module Installation (PMI) on the VSM. The procedure will prompt you to manually enter the as-built into the VSM. Obtain the as-built data from PTS > OASIS > As-Built.
DOR-B8H4Z-11
Service Bulletin/Repair Instructions
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in steering effort.
ASI-44408
Service Bulletin/Repair Instructions
FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE
LP-09L02
Service Bulletin/Repair Instructions
FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SUPER DUTY 4X4. *PE UPDATED 7/22/09. CSC LETTER WAS RECEIVED. *PE
20228
Service Bulletin/Repair Instructions
1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
07312
Service Bulletin/Repair Instructions
WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ
20052
Service Bulletin/Repair Instructions
1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
19728
Service Bulletin/Repair Instructions
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19621
Service Bulletin/Repair Instructions
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
04227
Service Bulletin/Repair Instructions
DRIVE AWAY SHUDDER OR VIBRATION. *EH
05174
Service Bulletin/Repair Instructions
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT
05188
Service Bulletin/Repair Instructions
SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT
18735
Service Bulletin/Repair Instructions
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
042421
Service Bulletin/Repair Instructions
SAFETY BELT RETRACTION SPEED. *TT
042107
Service Bulletin/Repair Instructions
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
04174
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
17406
Service Bulletin/Repair Instructions
LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT
17784
Service Bulletin/Repair Instructions
DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT
17822
Service Bulletin/Repair Instructions
MANUAL TRANSMISSION FLUID LEAK. *TT
17829
Service Bulletin/Repair Instructions
TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT
17571
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
04185
Service Bulletin/Repair Instructions
FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT
17316
Service Bulletin/Repair Instructions
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT
16136
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT
15798
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT
15810
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT
15825
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT ONE OR BOTH HEADLAMPS CRACKED AT THE FRONT SIDE OF THE HEADLAMP LENS AREA. *TT
15827
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT THE TWO FUEL GAUGES DISPLAYING DIFFERENT FUEL LEVELS. *TT
15843
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT
15849
Service Bulletin/Repair Instructions
SOME VEHICLES BUILT FROM 12/01/2001 TO 02/08/2002 MAY EXHIBIT A BROKEN DOOR HANDLE RIVET. *TT
15607
Service Bulletin/Repair Instructions
CONCERNS WITH TR4050 MANUAL TRANSMISSION EXHIBITING A NO ENGAGEMENT FROM 1ST TO 2ND GEAR. *TT
15661
Service Bulletin/Repair Instructions
CONCERNS WITH RATTLE NOISES COMING FROM FRONT BRAKE CALIPERS. *TT
15525
Service Bulletin/Repair Instructions
INFORMATION REGARDING A RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPER.*YD
15579
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT CALIPER PIN RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT
15328
Service Bulletin/Repair Instructions
CONCERNS WITH RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT
15109
Service Bulletin/Repair Instructions
A COLD WEATHER REVERSE ENGAGEMENT STALL. *YD
06177
Service Bulletin/Repair Instructions
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
071110
Service Bulletin/Repair Instructions
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.