Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 51909
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
RFI20210210_624-
This SKU is a Transmission Line. The customer communication requested return of unsold inventory to inspect the connector. The transmission line connector may have an incorrect thread size, which will prevent it from being installed.
DOR-C2C6H-02
This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
DOR-U2J7Y-02
This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.
SSM 48157
Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the upper left corner. Select the utility knife in the bottom left corner. Select Update/Special Function and enter 53061 in the blue box then press the tick mark. The screen will go back to the system utilities page. Navigate to the toolbox tab and run the Programmable Module Installation (PMI) on the VSM. The procedure will prompt you to manually enter the as-built into the VSM. Obtain the as-built data from PTS > OASIS > As-Built.
DOR-B8H4Z-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in steering effort.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
ASI-44408
FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE
LP-09L02
FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SUPER DUTY 4X4. *PE UPDATED 7/22/09. CSC LETTER WAS RECEIVED. *PE
20228
1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ
08-2-11
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
07312
WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ
20052
1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ
07219
6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
19728
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19614
AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
19621
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
19356
DRIVEABILITY ISSUES AND/OR DTC P132B, P006A IMMEDIATELY AFTER REPROGRAMMING. *KB
19375
WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP. VEHICLES EQUIPPED WITH A 6.0L DIESEL ENGINE. *KB
19245
REPEAT TURBOCHARGER OR VGT REPLACEMENT. *TT
19247
OIL FLOW FROM THE BASE ENGINE OIL PUMP. *KB
0617
VOLUNTARY EMISSION RECALL 06E17 SUPPLEMENT #1: CONTROL MODULE RECALIBRATION. CORROSION MAY EXIST AT THE ELECTRODE SURFACE ON THE EXHAUST PRESSURE (EP) SENSOR; FUEL DELIVERY TIMING DURING COLD WEATHER MAY NOT BE OPTIMAL; AND/OR EXHAUST GAS RECIRCULATION (EGR) SYSTEM OPERATION AT IDLE MAY NOT BE OPTIMAL. *TT
04194
WATER-IN-FUEL (WIF) LAMP. *TT
051511
DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS OR NO POWER DUE TO OPEN FUSE. *TT
05252
NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS. *TT
052623
COOLANT DEGAS BOTTLE OVERFLOW - 6.0L. *TT
052625
MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE OR CRANK/NO START. *TT
06310
WATER-IN-FUEL (WIF) LAMP ON. *TT
0645
NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS. *TT
19015
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
04227
DRIVE AWAY SHUDDER OR VIBRATION. *EH
051713
COOLANT DEGAS BOTTLE OVERFLOW. *TT
05174
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT
05176
DIAGNOSTIC TROUBLE CODE P0488 AND/OR P1334 WITH NO DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION ENGAGEMENTS. *TT
05188
SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT
18822
TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK. MULTIPLE VEHICLES. FORD OASIS. TO INCLUDE 2006 FORD F-53. *TT
05E15
VOLUNTARY EMISSION RECALL 05E15 - SUPPLEMENT #2. EXHAUST PRESSURE SENSOR REPLACEMENT, ON-BOARD DIAGNOSTIC SYSTEM AND ENGINE CONTROL MODULE RECALIBRATIONS. *TT
18734
DIAGNOSTIC TROUBLE CODE P0488 SET AFTER REFLASH. *TT
18735
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
04221
MALFUNCTION INDICATOR LAMP ON WITH MISFIRE DTC'S SPARK KNOCK PISTON SCUFFING. *EH VEHICLES BUILT THROUGH 4/25/2005 - 5.4L 3V ENGINE. *TT
18694
LACK OF POWER AND/OR DTC P2263 OR P0299 AFTER TURBOCHARGER REPLACEMENT - SERVICE TIP. *TT
18598
INTERMITTENT CRANK NO START DUE TO AN EGR THROTTLE PLATE THAT IS STUCK CLOSED. THE ENGINE MAY SEEM LIKE IT HAS NO COMPRESSION DUE TO A FASTER THAN NORMAL CRANKING SPEED OF GREATER THAN 200 RPM. DTC P0488 OR P1334 MAY OR MAY NOT BE PRESENT. *TT
18607
DTC'S P0488 (EGR THROTTLE POSITION RANGE/PERFORMANCE) AND/OR P1334 (EGR THROTTLE POSITION SENSOR MINIMUM STOP PERFORMANCE) SETTING AFTER PCM REPROGRAMMING. *TT
18525
BUCK/JERK, LACKS POWER, BLACK SMOKE, ROLLING IDLE, SURGE, MIL ON, AND DIAGNOSTIC TROUBLE CODES P2263, P0299, OR P0401. *TT
18554
RPM SURGE AT IDLE; AUDIBLE EGR SURGE; LOW POWER/SMOKE/ROUGH IDLE FOLLOWING A COLD START THAT CORRECTS AFTER ENGINE IS WARM; SURGE ON RESUME WITH SPEED CONTROL; INTAKE FLUTTER SOUND AT STEADY STATE THROTTLE, JUST BEFORE DOWNSHIFT, ON AUTOMATIC TRANSMISSION VEHICLES; BUCK/JERK SURGE ON MANUAL TRANS VEHICLES. *TT
05139
DIESEL EXHAUST SMELL IN CAB-6.0L ENGINE. *SC
05148
LOW POWER-COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED-OIL LEAK AT CAC CONNECTIONS-6.0L-VEHICLES BUILT 4/1/2004 THROUGH 2/15/2005. *SC
05249
COOLANT DEGAS BOTTLE OVERFLOW. *TT
052624
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT
06171
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263. *KB
06177
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
06213
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L. *TT
062401
6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
06246
DTC'S P006A OR P132B - LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17. *KB
071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
0714
LACK OF COOLING FAN OPERATION. *KB
07515
6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
0754
COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
19082
LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS. *TT
19090
EXHAUST PRESSURE SENSOR INPUT NO LONGER USED IF PCM IS REPROGRAMMED - SERVICE TIP. *TT
19099
P0404 SERVICE TIP. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.