17571
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Vehicle report
1994 FORD F-350
Service bulletins
156 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
03211
Service Bulletin/Repair Instructions
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
032110
Service Bulletin/Repair Instructions
HARD OR NO START, HESITATION, IDLE ROUGH, LOW POWER, MISSES, STALLS. *TT
032111
Service Bulletin/Repair Instructions
NO START/HARD START AND/OR LONG CRANK TIME FOR VEHICLES WITH 7.3L DI TURBO DIESEL. *TT
032117
Service Bulletin/Repair Instructions
THE AIR CLEANER ELEMENT MAY ALLOW DUST TO BYPASS DUE TO THE AIR CLEANER ELEMENT COLLAPSING/DISTORTING UNDER SEVERE DUST CONDITIONS. *TT
03212
Service Bulletin/Repair Instructions
HESITATION, STUMBLE, LACK OF POWER, ROUGH IDLE AND POOR PERFORMANCE ON VEHICLES WITH 7.3L DI TURBO DIESEL BUILT FROM 2/9/94. *TT
032121
Service Bulletin/Repair Instructions
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
032123
Service Bulletin/Repair Instructions
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
032127
Service Bulletin/Repair Instructions
LACK OF POWER AND/OR LOW PERFORMANCE CONDITION CAUSED BY NO RETURN FUEL FLOW TO THE FUEL TANK. *TT
03213
Service Bulletin/Repair Instructions
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
032131
Service Bulletin/Repair Instructions
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
03214
Service Bulletin/Repair Instructions
POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO IDLE SPEED. *TT
03215
Service Bulletin/Repair Instructions
HARD STARTING AFTER THE FUEL INJECTORS HAVE BEEN REPLACED. *TT
03216
Service Bulletin/Repair Instructions
A LACK OF ACCELERATOR CONTROL WHEN MOVING OFF OF THE IDLE POSITION. *TT
03217
Service Bulletin/Repair Instructions
REAR OF ENGINE OIL PAN, NEAR THE CRANKSHAFT, MAY LEAK OIL. *TT
03218
Service Bulletin/Repair Instructions
THE WATER-IN-FUEL LAMP MAY STAY ON AND THE FUEL MAY BE SLOW TO DRAIN OR NOT DRAIN AT ALL WHEN THE FUEL DRAIN VALVE IS OPENED. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
01194
Service Bulletin/Repair Instructions
THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
14455
Service Bulletin/Repair Instructions
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
98167
Service Bulletin/Repair Instructions
TRANSMISSION-E40D-NO 2-3 UPSHIFT. SOME VEHICLES MAY EXHIBIT A NO 2-3 UPSHIFT CONDITION. *AK
98168
Service Bulletin/Repair Instructions
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
0038
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
0011
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE PARKING BRAKE PEDAL WHICH GOES TO THE FLOOR WITH MINIMAL EFFORT- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/94.
0012
Service Bulletin/Repair Instructions
INFORMATION REGARDING PARKING BRAKE CONTROL ASSEMBLY CONCERNS- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS
0013
Service Bulletin/Repair Instructions
PROCEDURE FOR SERVICING PARKING BRAKE- SERVICE TIP- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
99236
Service Bulletin/Repair Instructions
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
5047
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
9811335
Service Bulletin/Repair Instructions
EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
12905
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
9943
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
5250
Service Bulletin/Repair Instructions
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
5251
Service Bulletin/Repair Instructions
SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT
5254
Service Bulletin/Repair Instructions
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
5262
Service Bulletin/Repair Instructions
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
982313
Service Bulletin/Repair Instructions
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. *YC
5046
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
985042
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
985058
Service Bulletin/Repair Instructions
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
98205
Service Bulletin/Repair Instructions
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
98-4722
Service Bulletin/Repair Instructions
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
98-4726
Service Bulletin/Repair Instructions
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
98-4734
Service Bulletin/Repair Instructions
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
98-4742
Service Bulletin/Repair Instructions
VEHICLE STALLS UPON ACCELERATION. *AK
98156
Service Bulletin/Repair Instructions
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
98158
Service Bulletin/Repair Instructions
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK
4614
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
4616
Service Bulletin/Repair Instructions
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
4617
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
4625
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
4629
Service Bulletin/Repair Instructions
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
4633
Service Bulletin/Repair Instructions
REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
980312
Service Bulletin/Repair Instructions
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
980323
Service Bulletin/Repair Instructions
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
980325
Service Bulletin/Repair Instructions
COLD ENGINE UPPER KNOCK/TICK. *YC
982740
Service Bulletin/Repair Instructions
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A12
Service Bulletin/Repair Instructions
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
985A13
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A25
Service Bulletin/Repair Instructions
A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC
985A29
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT EXCESSIVE BRAKE PEDAL TRAVEL, IRREGULAR FRONT LINING WEAR, AND BRAKE PULL. *YC
985A35
Service Bulletin/Repair Instructions
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC
985A37
Service Bulletin/Repair Instructions
THE PARKING BRAKE PEDAL MAY GO TO THE FOOR WITH LITTLE OR NO EFFORT DURING APPLICATION. *YC
985A5
Service Bulletin/Repair Instructions
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
98419
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983074
Service Bulletin/Repair Instructions
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
98113
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
98115
Service Bulletin/Repair Instructions
INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT
98122
Service Bulletin/Repair Instructions
PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT
98123
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
9814
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
010198
Service Bulletin/Repair Instructions
SOME VEHICLES MAY DEVELOP "CAVITATION" EROSION IN THE CYLINDER WALL OF THE ENGINE. *TT
980307
Service Bulletin/Repair Instructions
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
97111097238
Service Bulletin/Repair Instructions
SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC
97050110621
Service Bulletin/Repair Instructions
PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW
BC2301970501
Service Bulletin/Repair Instructions
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
9778
Service Bulletin/Repair Instructions
HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
97618
Service Bulletin/Repair Instructions
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
97511
Service Bulletin/Repair Instructions
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
BC3130970221
Service Bulletin/Repair Instructions
DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW
9747
Service Bulletin/Repair Instructions
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
9748
Service Bulletin/Repair Instructions
ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD
BC3241970210
Service Bulletin/Repair Instructions
EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW
BC3287970206
Service Bulletin/Repair Instructions
THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW
97310
Service Bulletin/Repair Instructions
NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
BC0321972301
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
97215
Service Bulletin/Repair Instructions
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
97216
Service Bulletin/Repair Instructions
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
BC0321970201
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
962612
Service Bulletin/Repair Instructions
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962511
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
962412
Service Bulletin/Repair Instructions
BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW
962415
Service Bulletin/Repair Instructions
VIBRATION - DRIVELINE VIBRATION AND/OR DRIVELINE NOISE - REGULAR CAB 4X4 VEHICLES EQUIPPED WITH 7.5L ENGINE AND MANUAL TRANSMISSION. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
Service Bulletin/Repair Instructions
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0321961101
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
BC0678961025
Service Bulletin/Repair Instructions
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
BC0682961024
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION OR NOISE WHILE DRIVING AT HIGHWAY SPEEDS ON STEADY CRUISE OR DECEL. *TT
96221
Service Bulletin/Repair Instructions
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
962211
Service Bulletin/Repair Instructions
AIR CLEANER - DAMAGED AIR FILTER IN SEVERE DUSTY CONDITIONS - VEHICLES WITH 7.3L DIT DIESEL ENGINE BUILT THROUGH 5/8/96 - SERVICE TIP. *TW
962213
Service Bulletin/Repair Instructions
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
96222
Service Bulletin/Repair Instructions
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96226
Service Bulletin/Repair Instructions
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0820961010
Service Bulletin/Repair Instructions
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. *TT
BC0883961004
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
96720
Service Bulletin/Repair Instructions
EXPERIENCING FRONT END SHIMMY OCCURRING AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. *TT
96728
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT
BC0131960102
Service Bulletin/Repair Instructions
4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
95212
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC1351950906
Service Bulletin/Repair Instructions
ROUGH IDLE OR MISS MAY BE DUE TO LOOSE INJECTOR HOLD DOWN BOLT. *TW
BC1432995090
Service Bulletin/Repair Instructions
ENGINE MOAN AT APPROXIMATELY 1900 RPM DUE TO THE FLYWHEEL DAMPENING OF ENGINE PULSES. *TW
951616
Service Bulletin/Repair Instructions
AIR CONDITIONING-LACK OF COOLING AT IDLE-A/C SYSTEM SHUTS OFF DUE TO HIGH SYSTEM PRESSURES-7.3L DI TURBO F-SERIES BUILT BEFORE 4/14/95 AND 7.3L DI TURBO ECONOLINES BUILT BEFORE 4/21/95. *SD
951713
Service Bulletin/Repair Instructions
GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD
951714
Service Bulletin/Repair Instructions
ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE
951112
Service Bulletin/Repair Instructions
REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW
951113
Service Bulletin/Repair Instructions
DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE. *TW
951010
Service Bulletin/Repair Instructions
LACK OF ACCELERATOR CONTROL WHEN MOVING OFF THE IDLE POSITION. *TW
951015
Service Bulletin/Repair Instructions
HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER. *TW
95107
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT A POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO IDLE SPEED. *TW
95108
Service Bulletin/Repair Instructions
VEHICLES MAY BE HARD TO START AFTER THE FUEL INJECTORS HAVE BEEN REPLACED. *TW
95522
Service Bulletin/Repair Instructions
ACCESSORY DRIVE BELTS - ALL 7.3 IDI DIESELS COME OFF ACCESSORY DRIVE PULLEYS - VEHICLES BUILT AFTER 2/15/92. *TW
95912
Service Bulletin/Repair Instructions
UNKNOWN
9597
Service Bulletin/Repair Instructions
UNKNOWN
95710
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO THE IDLE SPEED. *TW
9579
Service Bulletin/Repair Instructions
VEHICLES WITH 7.3L DIRECT INJECTION DIESEL ENGINES MAY EXPERIENCE ONE OR MORE OF THE FOLLOWING CONDITIONS: ROUGH IDLE, STALLING HESITATION/STUMBLE, LOSS/LACK OF POWER, POOR FUEL ECONOMY EXCESSIVE OIL CONSUMPTION. *TW
9585
Service Bulletin/Repair Instructions
A RATTLE FROM THE SPLIT SEAT BENCH MAY BE DUE TO A LOOSE OR MISSING SEAT BUSHING. *TW
9588
Service Bulletin/Repair Instructions
KNOCKING NOISE ON INITIAL START-UP. *TW
BC2922950401
Service Bulletin/Repair Instructions
REVISED MOUNTING TORQUE FOR BUMPERS. *TW
BC4225
Service Bulletin/Repair Instructions
UNKNOWN
95514
Service Bulletin/Repair Instructions
REVISED OIL FILL PROCEDURES. *TW
95519
Service Bulletin/Repair Instructions
IMPROPER OIL DIPSTICK CAUSES DRIVEABILITY CONCERNS. *TW
95521
Service Bulletin/Repair Instructions
UNDER HOOD WIRE HARNESS MAY BECOME CHAFED. *TW
95524
Service Bulletin/Repair Instructions
THERE MAY BE A CONCERN OF POOR PERFORMANCE, COOLANT IN THE OIL AND ENGINE KNOCKING AND/OR HYDRAULIC LOCK ON SOME VEHICLES. *TW
95613
Service Bulletin/Repair Instructions
A NO START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY ON SOME VEHICLES. *TW
95617
Service Bulletin/Repair Instructions
EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES. *TW
95619
Service Bulletin/Repair Instructions
NEW DESIGN TRANSMISSION RANGE SENSOR. *TW
95712
Service Bulletin/Repair Instructions
DURING HIGHWAY DECELERATION OR ENGINE START-UP, THERE MAY BE A HOOTING NOISE COMING FROM THE ENGINE COMPARTMENT. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.