17571
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Vehicle report
1996 FORD F-350
Service bulletins
169 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
03211
Service Bulletin/Repair Instructions
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
032111
Service Bulletin/Repair Instructions
NO START/HARD START AND/OR LONG CRANK TIME FOR VEHICLES WITH 7.3L DI TURBO DIESEL. *TT
032112
Service Bulletin/Repair Instructions
ON VEHICLES WITH TRANSMISSION BUILD DATES PRIOR TO 9/20/95, THE OVERDRIVE CANCEL LAMP MAY BE ILLUMINATING AND DIAGNOSTIC TROUBLE CODE (DTC) P1728 PRESENT AND/OR ENGINE STALL WHEN REVERSE AND/OR MANUAL LOW IS SELECTED. *TT
032113
Service Bulletin/Repair Instructions
ENGINE NOISE SIMILAR T A ROD KNOCK. *TT
032114
Service Bulletin/Repair Instructions
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR, SHRED AND/OR COME OFF DURING DECELERATION. *TT
032116
Service Bulletin/Repair Instructions
SOME 7.3L DIESEL E40D EQUIPPED VEHICLES BUILT BETWEEN 5/15/96 AND 7/8/96 MAY EXHIBIT HARSH UPSHIFTS. *TT
032117
Service Bulletin/Repair Instructions
THE AIR CLEANER ELEMENT MAY ALLOW DUST TO BYPASS DUE TO THE AIR CLEANER ELEMENT COLLAPSING/DISTORTING UNDER SEVERE DUST CONDITIONS. *TT
032118
Service Bulletin/Repair Instructions
DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH THE TORQUE CONVERTER CLUTCH ENGAGED ON VEHICLES WITH TRANSMISSIONS BUILT PRIOR TO 11/13/95 (5L13). *TT
032119
Service Bulletin/Repair Instructions
AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT
032121
Service Bulletin/Repair Instructions
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
032123
Service Bulletin/Repair Instructions
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
032125
Service Bulletin/Repair Instructions
AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT
032126
Service Bulletin/Repair Instructions
MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT
032128
Service Bulletin/Repair Instructions
COOLANT MAY LEAK AT THE REAR OIL HEADER. *TT
03213
Service Bulletin/Repair Instructions
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
032131
Service Bulletin/Repair Instructions
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
03218
Service Bulletin/Repair Instructions
THE WATER-IN-FUEL LAMP MAY STAY ON AND THE FUEL MAY BE SLOW TO DRAIN OR NOT DRAIN AT ALL WHEN THE FUEL DRAIN VALVE IS OPENED. *TT
03219
Service Bulletin/Repair Instructions
AVAILABILITY OF NEW SEALANT FOR SERVICING 7.3L DI TURBO ENGINE. *TT
03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
14455
Service Bulletin/Repair Instructions
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
98168
Service Bulletin/Repair Instructions
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
0038
Service Bulletin/Repair Instructions
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
99236
Service Bulletin/Repair Instructions
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
5047
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
9811335
Service Bulletin/Repair Instructions
EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99111
Service Bulletin/Repair Instructions
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
991210
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
12905
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
9943
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
BPI9905
Service Bulletin/Repair Instructions
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
5250
Service Bulletin/Repair Instructions
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
5251
Service Bulletin/Repair Instructions
SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT
5254
Service Bulletin/Repair Instructions
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
5262
Service Bulletin/Repair Instructions
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
982313
Service Bulletin/Repair Instructions
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. *YC
982314
Service Bulletin/Repair Instructions
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
982323
Service Bulletin/Repair Instructions
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
5046
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
985042
Service Bulletin/Repair Instructions
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
985058
Service Bulletin/Repair Instructions
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
98205
Service Bulletin/Repair Instructions
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
98-4722
Service Bulletin/Repair Instructions
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
98-4726
Service Bulletin/Repair Instructions
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
98-4734
Service Bulletin/Repair Instructions
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
98-4742
Service Bulletin/Repair Instructions
VEHICLE STALLS UPON ACCELERATION. *AK
98163
Service Bulletin/Repair Instructions
LOCKS FAILED. YD
98156
Service Bulletin/Repair Instructions
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
98158
Service Bulletin/Repair Instructions
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK
4614
Service Bulletin/Repair Instructions
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
4616
Service Bulletin/Repair Instructions
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
4617
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
4625
Service Bulletin/Repair Instructions
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
4629
Service Bulletin/Repair Instructions
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
4633
Service Bulletin/Repair Instructions
REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT
98810
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
980312
Service Bulletin/Repair Instructions
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
980325
Service Bulletin/Repair Instructions
COLD ENGINE UPPER KNOCK/TICK. *YC
982740
Service Bulletin/Repair Instructions
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A12
Service Bulletin/Repair Instructions
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
985A13
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A23
Service Bulletin/Repair Instructions
A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT
985A25
Service Bulletin/Repair Instructions
A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC
985A27
Service Bulletin/Repair Instructions
LUBRICANT LEAKING FROM REAR AXLE SEAL CONTAMINATING BRAKE SHOES. *YC
985A32
Service Bulletin/Repair Instructions
PROCEDURES ON CALIPER-MOUNT LATHE MACHINING SETUP. *YC
985A35
Service Bulletin/Repair Instructions
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC
985A5
Service Bulletin/Repair Instructions
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
98413
Service Bulletin/Repair Instructions
A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT
98419
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983074
Service Bulletin/Repair Instructions
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
9811346
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT
98113
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
98115
Service Bulletin/Repair Instructions
INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT
98122
Service Bulletin/Repair Instructions
INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.
98123
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
9814
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
980307
Service Bulletin/Repair Instructions
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
980323
Service Bulletin/Repair Instructions
DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.
983564
Service Bulletin/Repair Instructions
EXPERIENCING A SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLYING THE BRAKES ON SOME VEHICLES. *TT
97111097238
Service Bulletin/Repair Instructions
SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC
97090297187
Service Bulletin/Repair Instructions
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
97050110621
Service Bulletin/Repair Instructions
PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW
BC2301970501
Service Bulletin/Repair Instructions
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
BC2445970501
Service Bulletin/Repair Instructions
F SERIES WITH 7.5L ENGINES - VEHICLES HAVE EXHIBITED HIGH OIL LEVEL READINGS ON THE DIPSTICK. *TW
9778
Service Bulletin/Repair Instructions
HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
9779
Service Bulletin/Repair Instructions
WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD
97618
Service Bulletin/Repair Instructions
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
97627
Service Bulletin/Repair Instructions
NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- F-250 AND F-350 OVER 8500# GVW. *JD
97629
Service Bulletin/Repair Instructions
TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
97511
Service Bulletin/Repair Instructions
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
BC3130970221
Service Bulletin/Repair Instructions
DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW
9747
Service Bulletin/Repair Instructions
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
9748
Service Bulletin/Repair Instructions
ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD
BC3212970213
Service Bulletin/Repair Instructions
CAMSHAFT POSITION SENSOR INFORMATION . *TW
BC3241970210
Service Bulletin/Repair Instructions
EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW
BC3287970206
Service Bulletin/Repair Instructions
THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW
97310
Service Bulletin/Repair Instructions
NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
9735
Service Bulletin/Repair Instructions
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
BC0053972301
Service Bulletin/Repair Instructions
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
BC0321972301
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
BC1020897230
Service Bulletin/Repair Instructions
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD
BC3440972301
Service Bulletin/Repair Instructions
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVEMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNCTIONING HAS BEEN DELAYED. *JD
97215
Service Bulletin/Repair Instructions
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
97216
Service Bulletin/Repair Instructions
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
97113
Service Bulletin/Repair Instructions
AN ENGINE VIBRATION AND/OR "MOANING" NOISE AT 2600-3000 RPM MAY OCCUR ON SOME VEHICLES. *JD
97114
Service Bulletin/Repair Instructions
ENGINE COMPARTMENT NOISE-"BUZZING OR KNOCKING"- RIGHT FRONT OF ENGINE-AFTER STARTING. *JD
BC0053970201
Service Bulletin/Repair Instructions
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
BC0113970201
Service Bulletin/Repair Instructions
VEHICLES MAY DISPLAY A DRIFT/PULL CONDITION WHILE DRIVING, USUALLY TO THE LEFT SIDE. *JD
BC0187970201
Service Bulletin/Repair Instructions
VEHICLE IS FOUND TO BE EQUIPPED WITH RIVETS INSTEAD OF THREADED FASTENERS ON THE #4 CROSSMEMBER. *JD
BC0256970201
Service Bulletin/Repair Instructions
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
BC0321970201
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
BC1015397020
Service Bulletin/Repair Instructions
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
962612
Service Bulletin/Repair Instructions
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962621
Service Bulletin/Repair Instructions
VIBRATION- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS- VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13) TRANSMISSION- E4OD- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS- VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13). *JD
96265
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW
962510
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW
962511
Service Bulletin/Repair Instructions
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
96252
Service Bulletin/Repair Instructions
LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW
962521
Service Bulletin/Repair Instructions
STEERING - CLUNK NOISE FROM STEERING COLUMN ON ACCELERATING AND BRAKING. *TW
962412
Service Bulletin/Repair Instructions
BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW
962418
Service Bulletin/Repair Instructions
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
Service Bulletin/Repair Instructions
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0475961114
Service Bulletin/Repair Instructions
A "CLUNK" NOISE HEARD/FELT THROUGH THE STEERING COLUMN WHEN MANEUVERING IN PARKING LOTS, DRIVING IN STOP AND GO TRAFFIC OR DRIVING OVER BUMPS. *TW
BC0321961101
Service Bulletin/Repair Instructions
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
96221
Service Bulletin/Repair Instructions
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
962211
Service Bulletin/Repair Instructions
AIR CLEANER - DAMAGED AIR FILTER IN SEVERE DUSTY CONDITIONS - VEHICLES WITH 7.3L DIT DIESEL ENGINE BUILT THROUGH 5/8/96 - SERVICE TIP. *TW
962212
Service Bulletin/Repair Instructions
ENGINE COMPARTMENT NOISE - BUZZING OR KNOCKING - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F SERIES BUILT FROM 8/1/94 THROUGH 10/15/95 - ECONOLINES BUILT FROM 8/15/94 THROUGH 10/15/95. *TW
962213
Service Bulletin/Repair Instructions
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
96222
Service Bulletin/Repair Instructions
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96223
Service Bulletin/Repair Instructions
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW
96226
Service Bulletin/Repair Instructions
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0844961008
Service Bulletin/Repair Instructions
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
BC0883961004
Service Bulletin/Repair Instructions
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
BC5191961001
Service Bulletin/Repair Instructions
FOR CONCERNS OF STALLING, REFLASH PCM W/ 1996 CALIBRATION (R11 LEVEL). *TT
BC5195961001
Service Bulletin/Repair Instructions
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
BC5201961001
Service Bulletin/Repair Instructions
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
96715
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW SINGLE KEY LOCKSETS INSTALLED ON CERTAIN TRIAL VEHICLES. *TT
96718
Service Bulletin/Repair Instructions
SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNTED BRAKE ROTOR MACHINING ACCESSORIES FROM ROTUNDA, FOR CERTAIN VEHICLES, ARE NOW AVAILABLE FOR SERVICE USE. *TT
96720
Service Bulletin/Repair Instructions
EXPERIENCING FRONT END SHIMMY OCCURRING AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. *TT
96723
Service Bulletin/Repair Instructions
ON SOME VEHICLES, THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND CODE P1411 MAY BE STORED IN MEMORY. *TT
96727
Service Bulletin/Repair Instructions
EXPERIENCING A KNOCKING NOISE WHEN THE ENGINE IS COLD AND UNDER ACCELERATION. *TT
96728
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT
BC0131960102
Service Bulletin/Repair Instructions
4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
95212
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC4225
Service Bulletin/Repair Instructions
UNKNOWN
95616
Service Bulletin/Repair Instructions
COOLING SYSTEM - LEAKING RADIATOR HOSE - UPGRADED HOSE CLAMPS. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.