Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SSM 46345
SOME 2005-2017 F-SUPER DUTY 4X4 VEHICLES OPERATED IN EXTREME DUST, MUD OR TAR SAND CONDITIONS MAY EXHIBIT ACCELERATED 4X4 VACUUM HUB SEAL AND OR WHEEL BEARING WEAR AS A RESULT OF HARSH OPERATING CONDITIONS. A KNUCKLE SEAL SHIELD KIT IS NOW AVAILABLE FOR CUSTOMER PURCHASE. THE KIT IS DESIGNED FOR SEVERE DUTY AND IS NON WARRANTABLE. THE KNUCKLE SEAL SHIELD KIT GC3Z-54024A38-A INCLUDES AN INSTRUCTION SHEET.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB-08-9-9
FORD: 6.0L DIESEL HARD START/LONG CRANK/NO START DU TO LOW INJECTOR CONTROL PRESSURE (ICP). IPE
07M08
FORD LINCOLN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CUSTOMER SATISFACTION PROGRAM 07M08: CERTAIN 2005 MODEL YEAR F-150, F-SUPER DUTY, EXPEDITION, AND NAVIGATOR VEHICLES WITH 5.4L 3V ENGINES-EXTENDED WARRANTY COVERAGE ON FUEL INJECTORS. CSC WAS RECEIVED. *NJ UPDATED 5/20/09. *PE
08-2-11
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
20064
2004-2006 F-650/F-750 AND 2006 LCF - FUEL TANKS. *NJ
07199
SOME 2004-2008 F-SUPER DUTY 650-750 VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT A CONDITION WHERE THE AIR SUSPENSION SPRINGS ARE NOT RE-INFLATING. *NJ
07219
6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
0792
DUAL FUEL TANK. ONE EMPTY FUEL DOES NOT TRANSFER. *KB UPDATED 2/6/08. *NJ
19989
2005-2008 F-SUPER DUTY MANUAL TRANSMISSION- CLUTCH PEDAL CONCERN. *NJ
19725
FUEL TANKS PUT INTO SOME VEHICLES WERE MADE OUT OF STEEL. WHICH ARE GOING TO BE REPLACED BY ALUMINUM TANKS. *KB
19728
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19614
AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
19621
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
19521
LACK OF POWER OR LACK OF PERFORMANCE CONDITION WHEN OPERATED ABOVE 5,000 FEET OF ALTITUDE. *KB
19529
MISFIRE AND DTC P0300. *KB
19532
TURN SIGNALS FLASHING RAPIDLY AFTER MODIFICATION. *KB
19537
MISFIRE AND DTC P0300. *KB
05B30
CUSTOMER SATISFACTION PROGRAM 05B30 -ACCESSORY DRIVE GEAR REPLACEMENT. *SC SUPPLEMENT #1. *TT
05204
VEHICLE DIAGNOSTICS AND PROGRAMMING USING WDS - F-650/750 WITH 6.0L ENGINE AND LOW CAB FORWARD WITH 4.5L ENGINE. *TT
19015
FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT
04235
NO START NO ECM/TCM COMMUNICATIONS AND OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *EH
05174
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT
18735
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
042421
SAFETY BELT RETRACTION SPEED. *TT
05511
RIGHT FUEL TANK EMPTY - FUEL DOES NOT TRANSFER FROM LEFT TANK. *TT
18409
CHECK REPLACEMENT FUEL LEVEL SENSOR PRIOR TO INSTALLATION. *TT
0512
TEMPERATURE GAUGE READS HOT. *TT
04233
MISFIRE LACK OF POWER BUCK JERK EXCESSIVE SMOKE CRANK NO START 6.0L ENGINE DIAGNOSTICS FOR FUEL SYSTEM . *EH SERVICE TIPS. *TT
05125
HARD START/LONG CRANK, LACK/LOSS OF POWER, RUNS ROUGH, BUCK/JERK, MISSES-COLD WEATHER REGIONS. *SC
042412
COMMUNICATION/DIAGNOSTIC ISSUES WITH ANTI-LOCK BRAKING SYSTEM (ABS) MODULES. *TT
04239
WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA. *TT
042121
NO START, NO ECM/TCM COMMUNICATIONS, AND/OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *TT
04222
BRAKE PAD SELECTION SERVICE TIP. *EH
17406
LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT
04167
DIAGNOSTIC TROUBLE CODE (DTC) 367 AFTER ELECTRONIC CONTROL MODULE (ECM) REPLACEMENT. TO INCLUDE 2005 F-650/750. *AR
04168
VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST. *AR
0451
VEHICLE DIAGNOSTICS AND PROGRAMMING USING WDS ON 2004 MEDIUM DUTY TRUCKS EQUIPPED WITH 6.0L POWER STROKE DIESEL ENGINE - SERVICE TIPS. *TT THIS ARTICLE SUPERSEDED TSB 04-5-1 TO UPDATE THE VEHICLE MODEL YEARS. FORD F-650/750 2005 INCLUDED. *AR
18102
TURN SIGNALS FLASHING RAPIDLY AFTER MODIFICATION - SERVICE TIP. *TT
02219
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS. *TT
06163
NO START, NO ECM/TCM COMMUNICATIONS AND/OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *KB
06169
RIGHT FUEL TANK EMPTY - FUEL DOES NOT TRANSFER FROM LEFT TANK. *KB
06177
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
06237
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
062401
6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
06257
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
07112
STUCK OR JUMPING/BOUNCING/ERRATIC SPEEDOMETER AND/OR TACHOMETER. *NJ
07153
SOME 2005-2007 F-650 AND F-750 VEHICLES EQUIPPED W/ A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *NJ
0769
BUCK/JERK WHEN PULLING LARGE HEAVY GOOSENECK TRAILERS. DIESEL ENGINES. REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH THE LATEST CALIBRATION MIGHT SOLVE THE ISSUE. *KB
0772
REAR OF VEHICLE IS TOO HIGH/LOW -5TH WHEEL AND GOOSE NECK APPLICATIONS. *KB
0798
ABS LIGHT ON AND POSSIBLE C1175, C1236, P0500,P0503. *KB
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.