Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ASI-44534
FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-44404
FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
ASI-44408
FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE
08-2-11
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
20064
2004-2006 F-650/F-750 AND 2006 LCF - FUEL TANKS. *NJ
07199
SOME 2004-2008 F-SUPER DUTY 650-750 VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT A CONDITION WHERE THE AIR SUSPENSION SPRINGS ARE NOT RE-INFLATING. *NJ
07219
6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
0792
DUAL FUEL TANK. ONE EMPTY FUEL DOES NOT TRANSFER. *KB UPDATED 2/6/08. *NJ
19725
FUEL TANKS PUT INTO SOME VEHICLES WERE MADE OUT OF STEEL. WHICH ARE GOING TO BE REPLACED BY ALUMINUM TANKS. *KB
19728
LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
19614
AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103. *KB
19621
LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
19532
TURN SIGNALS FLASHING RAPIDLY AFTER MODIFICATION. *KB
06163
NO START, NO ECM/TCM COMMUNICATIONS AND/OR FLASHING AUTOMATIC TRANSMISSION INDICATOR. *KB
06169
RIGHT FUEL TANK EMPTY - FUEL DOES NOT TRANSFER FROM LEFT TANK. *KB
06177
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB
06237
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
062401
6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT. *KB
06257
WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START. *KB
071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.